Jayco Greyhawk 2005
Model Greyhawk made in 2005 by Jayco got 7 recalls as well as 2 service bulletins. Technical service bulletines regarding electrical system. There were some recalls concerningelectrical system and engine and engine cooling.
Model 2005
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - BATTERY - CABLES | ||||||||||||||||
| 05V008000 | JAYCO, INC. | from 07/13/2004 to 12/02/2004 | V (Vehicle) | 688 | 02/28/2005 | MFR | JAYCO, INC. | 01/12/2005 | 01/12/2005 | |||||||
| Defect Summary | On certain motor homes the battery cable may have been routed too close to the exhaust manifold. | |||||||||||||||
| Consequence Summary | This could cause the cable to melt, creating an electrical short, which could result in a fire. | |||||||||||||||
| Corrective Summary | Dealers will inspect and reroute and/or replace the battery cable free of charge. the recall began on february 28, 2005. owners may contact jayco at 574-825-5861. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
| 06V095000 | JAYCO, INC. | from 11/01/2002 to 06/30/2004 | V (Vehicle) | 1107 | MFR | JAYCO, INC. | 03/31/2006 | 03/31/2006 | ||||||||
| Defect Summary | Certain motor homes built on ford chassis may experience stalling without warning while driving and may or may not restart. | |||||||||||||||
| Consequence Summary | Should the engine stall, a vehicle crash could occur. | |||||||||||||||
| Corrective Summary | Ford motor company is conducting the owner notification and remedy for this campaign. dealers will upgrade the fuel injection control module (ficm) wire harness or replaced, and/or have a new injection control pressure (icp)) sensor connector installed free of charge. owners may contact ford at 1-800-392-3673 or jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| 05V354000 | JAYCO, INC. | from 06/20/2003 to 05/19/2004 | V (Vehicle) | 285 | 08/22/2005 | MFR | JAYCO, INC. | 08/08/2005 | 08/09/2005 | |||||||
| Defect Summary | On certain motor homes, the cable ties, which attach the main wiring harness to the frame rails, may break and cause the wire harness to drop into the exhaust system. | |||||||||||||||
| Consequence Summary | This could result in the cable melting and creating an electrical short and/or fire. | |||||||||||||||
| Corrective Summary | Dealers will inspect the motor homes and attach new heavy duty cable ties. the recall began on august 22, 2005. owners may contact jayco at 1-574-825-5861. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| ENGINE AND ENGINE COOLING | ||||||||||||||||
| 06V082000 | JAYCO, INC. | from 11/01/2002 to 06/30/2004 | V (Vehicle) | 1107 | MFR | JAYCO, INC. | 03/28/2006 | 03/28/2006 | ||||||||
| Defect Summary | On certain motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. this change in filter paper composition, combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles. | |||||||||||||||
| Consequence Summary | These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire. | |||||||||||||||
| Corrective Summary | Ford motor company is conducting the owner notification and remedy for this campaign. dealers will inspect and replace the air filter element. owners should contact ford at 1-800-392-3673 or jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| EQUIPMENT - OTHER - LABELS | ||||||||||||||||
| 06V109000 | JAYCO, INC. | from 03/01/2005 to 04/30/2005 | V (Vehicle) | 135 | MFR | JAYCO, INC. | 04/10/2006 | 04/10/2006 | 571 | 120 | ||||||
| Defect Summary | Certain motor homes built on ford e-450 chassis, and equipped with lt225/75r16e tires fail to comply with the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for motor vehicles other than passenger cars.' the tire pressure is incorrectly listed on the label for the rear tires. | |||||||||||||||
| Consequence Summary | At the incorrectly stated pressure, the rear tires are unable to support the gross axle weight rating (gawr) for the rear axle. | |||||||||||||||
| Corrective Summary | Owners will be mailed supplementary tire labels containing the correct rear tire inflation information. owners may contact ford at 1-800-392-3673 or jayco at 1-800-283-8267 . | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 05V476000 | JAYCO, INC. | from 11/18/2002 to 09/22/2005 | V (Vehicle) | 237 | 10/31/2005 | MFR | JAYCO, INC. | 10/14/2005 | 10/14/2005 | |||||||
| Defect Summary | Certain motor homes built on chevrolet c3500 (express) cutaway chassis have a towing pigtail that will not show brake lights on the towed vehicle if hooked to the towing pigtail. | |||||||||||||||
| Consequence Summary | This condition could result in a crash, injury or death. | |||||||||||||||
| Corrective Summary | Dealers will rewire the towing pigtail wires to include the brake light circuit free of charge. the recall began on october 31, 2005. owners may contact jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| TRAILER HITCHES | ||||||||||||||||
| 05V556000 | JAYCO, INC. | from 07/11/2003 to 08/05/2004 | V (Vehicle) | 1878 | 01/10/2006 | MFR | JAYCO, INC. | 12/16/2005 | 12/16/2005 | |||||||
| Defect Summary | On certain motor homes, the hitch receiver may have missing reinforcing plates. when a load is applied to the hitch, it may become partially detached from the frame if these plates are missing. | |||||||||||||||
| Consequence Summary | This condition, if not addressed, could result in a crash, personal injury or death. | |||||||||||||||
| Corrective Summary | Dealers will inspect and replace the reinforcing plates with new hardware. the recall began on january 10, 2006. owners may contact jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 05186 | 08/01/2005 | 10016923 | The porch light circuit from the step controller was wired with no back feed protection on jayco motorhomes equipped wth a kwikee 9000 step. *tt | 10/17/2005 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| 05V008 | 03/29/2005 | 10013222 | Battery wire recall on 2005 jayco granite ridge, greyhawk, escapade, and starcraft ambient motorhomes. *tt | 04/13/2005 | |