Jayco Jay Flight 2003
Model Jay Flight made in 2003 by Jayco got 4 consumer complains there is 1 recall as well as 1 service bulletin. Consumer complaints with reference, among others things, to equipment, service brakes, electric and service brakes, hydraulic. Technical service bulletines regarding equipment. There was one recall concerning equipment .
Model 2003
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
03V383000 | JAYCO, INC. | from 07/06/2001 to 10/15/2003 | V (Vehicle) | 6442 | MFR | JAYCO, INC. | 10/09/2003 | 10/22/2003 | ||||||||
Defect Summary | On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or jayco at 1-574-825-0608. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EQUIPMENT - MECHANICAL - JACKS | |||||
04177 | 12/01/2003 | 10005771 | Rear stabilizer jacks. jayco technical service bulletin and jayco folding camping trailer outstore bunk skirt option installation and set up instructions. *tt | 03/15/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
EQUIPMENT | |||
05/30/2006 | 1 | 07/03/2003 | |
Dt*: the contact stated the microwave oven in the trailer is defective. there has not been an electrical short involving the microwave. the contact unplugged the microwave to avoid an electrical short and is therefore unable to use it. there was a recall letter received in november 2005 concerning recall, # 03v383000 on the vehicle regarding the equipment. the parts needed to repair the vehicle are not available at the local dealership. the manufacturer confirmed the parts are not available. | |||
EQUIPMENT - RECREATIONAL VEHICLE | |||
10/01/2004 | 1 | 06/23/2003 | |
2003 jay flight 27bh trailer brakes locking up. *bf the consumer took the rv back to the dealer who stated the brake lines were too short so they had to be adjusted. the screen had to be fixed because the were not sealed properly, there were gaps between the screens and the window frames. the consumer encountered other problems such as the shower wall separating from the corner which caused the wall to bulge, the fresh water tank was not properly tightened so when the consumer used it for the first time water leaked all over the floor and soaked the carpet. the mounting which held the drawers in place fell apart, the water heater stopped working, all of the screws which held the seating around the table fell out, he water pump was very loud. *jb | |||
SERVICE BRAKES, ELECTRIC | |||
09/16/2004 | 1 | 02/28/2003 | |
Consumer discovered that the right side electrical brake line was not hooked up on this travel trailer from the manufacturer plant. dealer was not notified . *ak | |||
SERVICE BRAKES, HYDRAULIC | |||
10/01/2004 | 1 | 06/23/2003 | |
2003 jay flight 27bh trailer brakes locking up. *bf the consumer took the rv back to the dealer who stated the brake lines were too short so they had to be adjusted. the screen had to be fixed because the were not sealed properly, there were gaps between the screens and the window frames. the consumer encountered other problems such as the shower wall separating from the corner which caused the wall to bulge, the fresh water tank was not properly tightened so when the consumer used it for the first time water leaked all over the floor and soaked the carpet. the mounting which held the drawers in place fell apart, the water heater stopped working, all of the screws which held the seating around the table fell out, he water pump was very loud. *jb |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
WI | CLEVELAND | WAGNERS |