Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||||
| 98733 | 12/01/1997 | 600604 | Subject on customer satisfaction notification #733--brake pedal shift interlock. *yc | 11/05/1999 | |
| POWER TRAIN - DRIVELINE | |||||
| 212194 | 11/01/1994 | 37855 | New front output seal and oil slinger for transfer case. *tw | 01/11/1995 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| POWER TRAIN | ||||||
| DP02005 | CHRYSLER GROUP LLC | 04/25/2002 | 09/10/2002 | SUDDEN ACCELERATION | ||
| Sudden vehicle acceleration is allegedly caused by a defect in the design and assembly of the connector interface between the main wiring harness and the powertrain control module | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 04/25/2003 | 24650 | 1 | |
| The gear shift box failed and caused the drive shaft to fall out the vehicle. *nlm | |||
| 105000 | 2 | ||
| The vehicle violently jerked and did not accelerate past 20 mph, the transmission was replaced twice. *jb | |||
| 05/27/1999 | 1 | 10/01/1998 | |
| Viscus coupler failure parts are a national backorder 3month waiting period. if this is not a safety recall i don't know what is? if this part should fail at a high rate of speed, loss of drivetrain, lockup of drivetrain could cause deadly accidents. how can they have a three month national backorder, without this being a major defect! | |||
| 07/12/1997 | 1 | 08/01/1993 | |
| Upon shifting todrive gear from a stopped position, vehicle suddenly accelerated. | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 10/09/2003 | 52000 | 100 | 10/15/1993 |
| Vehicle shuts down when slowing to a stop or deccelerating. rear collision and side impact collisions have been narrowly avoided. have tried 4 times to have it repaired but no one has made a solution. chrysler customer service had neither offered advice nor interest in this matter. *la | |||
| 3 | |||
| On three separate occasions the vehicle jumped from park to drive and instead of going forward the vehicle went forward, the consumer was able to stop the vehicle by depressing the brake. nlm | |||
| 02/19/2001 | 1 | 12/01/1998 | |
| Transmission: no prior problem. total failure without warning required total rebuilt including overdrive gears. fuel pump: intermittent stall issue over past 9 months. engine stalls occurred without warning anywhere from idle to 70 mph. appears problem occurs due to plastic fuel tank (?). | |||
| 02/09/2000 | 3 | 07/01/1999 | |
| Transmission has to be rebuilt @ $2,344.68. i do not tow. on 06/19/00 (94290) transmission failed again. i was charged $115.75 to replace anti drain back valve. on 11/14/00 (101,000) trans needs repair again. service manager says it is out of warranty and there is nothing free chrysler or he will do. i am stuck. help me. *ak | |||
| 01/31/2000 | |||
| While driving on highway travelling 75 mph, all of a sudden transmission failed and rpms went up. engine was racing. also, noticed that the overdrive light came on prior to acceleration. took vehicle to dealer, it needed a new transmission. *ak | |||
| 08/15/1995 | 1 | ||
| Owner shifted gear to park, turned off ignition, removed key, exited vehicle, pressed security remote control to lock doors, vehicle took off, rolled off embankment into neighbors's house, unoccupied, cause not determined. | |||
| 1 | 10/20/1993 | ||
| Transmission rebuilt/valve body replaced. | |||
| 10/23/1995 | |||
| Automatic transmission failure, loss of forward gears. tt | |||
| 10/10/1995 | |||
| Jeep was on in parking gear slipped into reverse no one was injured. tt | |||
| 07/15/1995 | 1 | ||
| Transmission jumped out of gear wand vehicle went backward ended in accident. tt | |||
| 06/01/1994 | |||
| Purchase car brand new car vibrate and a noise coming from the transmission. tt | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
| Transfer case viscous coupling malfunctioned, causing a loss of control while driving. dealer has been contacted. *ak | |||
| Differential wears excessively due to locking problem of 4-wheel drive. please describe details. tt | |||
| 09/01/1994 | 1 | ||
| 4 wheel drive locked up when attempting to back up. (other vehicle on 479569) | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - FLOOR SHIFT | |||
| 1 | |||
| Consumer complained about having problems with recall repairs that were performed on the floor shifter. it had actually made it worse on the shifter because the consumer had a hard time shifting gears. the manufacturer was contacted, and stated there was nothing that they could do. *ak it was difficult to place the shifter from reverse into park and would end up in neutral. *scc *jb | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||
| I work for the university of illinois parking department. we had an incident where a jeep cherokee was rolling out of a parking space. the vehicle transmission was in park. the vehicle was originally parked on a upsloped ramp, and then began to slowly roll back out of the parking space. the rollout was very gradual. i was able to stop the vehicle by placing bricks behind the tires. when the owner came to get his vehicle, i was unable to communicate with him since he spoke spanish.*ak | |||
| 10/28/1998 | 1 | ||
| Whiling idling vehicle jumped into reverse/ went out of control, and hit another vehicle.vehicle sounded as though gas pedal was to the floor, and wheels locked.contacted dealer. *ak police report states that consumer put vehicle in reverse and the throttle went wide open, consumer attempted to hit the brakes, however they did not work. *slc | |||
| 07/01/2001 | 0 | ||
| Vehicle was parked inside of garage area. after vehicle began running, without prior warning, it slipped into a reverse gear and backed out into the street. driverside door was opened, and hit another vehicle. dealership was aware of problem.*ak | |||
| 03/02/1999 | 1 | 05/30/1995 | |
| Consumer got in vehicle, turned it on and vehicle revved backward and it started spinning around. vehicle was crashing into other vehicles. vehicle stopped on its own. manufacturer sent an investigator to inspect, but no problem was found. *ak consumer states brake lock cable shifted. *slc | |||
| 03/04/1997 | 1 | 05/01/1994 | |
| Vehicle was in park or neutral and suddenly accelerated out of control. *ak | |||
| 08/15/1995 | |||
| Auto-transmission; vehicle rolled across parking lot w/gear shift in drive and no key in ignition. please describe details. tt | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||
| 1 | 10/20/1993 | ||
| Torque converter failed. | |||
| POWER TRAIN - AXLE ASSEMBLY | |||
| 01/17/1996 | |||
| Left rear axle broke while driving. | |||
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||
| 1 | 10/20/1993 | ||
| Rear transmission seals replaced. | |||
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
| 10/17/1999 | 07/01/1995 | ||
| Was driving vehicle when the tire went flat. placed the spare tire on vehicle, which was p22570r/15. the other 3 tires were 24570r/15. the front differential overheated & failed due to having a smaller tire on vehicle. taking vehicle to dealer to check. *ak | |||
| 05/30/1999 | |||
| Vehicle experience loss of both front and rear differential(after spare tire changed). dealer notified and made repairs. after 28 miles, condition reoccurr dealer informed consumer that failure was due to spare tire. can nhtsa provide addtional information or help in this matter. *ak | |||
| 06/10/1998 | 1 | 01/03/1998 | |
| Vehicle was backed down driveway, stopped then shifted into first gear. driver heard popping noise, car would not move. after being towed to garage, dealer states that pinion gear in rear differential was broken, pinion gear was all shrapnel. because casing was broken, rear axle must be replaced. this major component should not have broken on a vehicle with only 31,000+ miles. | |||
| 11/30/1997 | 0 | ||
| The rear differential was leaking oil. smelled smoke & pulled over. got out of vehicle & checked. noticed flames near rear. moved away & it was engulfed in flames. insurance inspector is looking at it. fire department assumed it was in rear differential. *ak | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| Please add more information. mr | |||
| 05/28/1996 | |||
| When it is cold it is almost impossible to shift the gears on the manual transmission. please describe. *ak | |||
| 05/02/1994 | 1 | ||
| Faulty neutral safety switch caused jeep to lurch forward forward striking 7-year old who was walking in front of the jeep. *ak | |||
| 05/21/1994 | |||
| The driver side door hinges not weld,can start car with out using the clutch and the horn out side the car not working lower side. tt | |||
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
| 04/17/2003 | 58000 | 1 | 06/15/2001 |
| The transfer case on the 4 wheel drive unit makes a creaking noise after it has been driven for more than 20 miles. the noise is most evident on coming to a complete stop and then turning (either left or right) after about 20 miles. i have replaced the drive shaft universals and inspected the cv joint in an effort to solve this problem. i have also had the rear transfer case seal replaced, although it has been leaking fluid at a very slow rate since it was replaced by my mechanic. i had two different mechanics inspect the problem and they are unable to isolate the problem other than it emanates from the area of the transfer case. the vehicle has less than 65,000 miles on it, a transfer case should not fail with mileage so low.*jb | |||
| 03/14/2002 | 1 | ||
| While traveling the consumer notice smoke coming from the rear of the vehicle and found that the vehicle had caught on fire under rear driver side tire. the fire was started from the 4 wheel drive gear transfer case. ohio traffic crash report (10-90-118) *yh | |||
| 05/01/1995 | 2 | 08/01/1994 | |
| Loud noise upon breaking, caused by the suspension compressing and forcing the driveshaft cv joints to bind while entering the transfer case. | |||