Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | ||||||||||||||||
97V069000 | CHRYSLER CORPORATION | from 07/01/1992 to 10/15/1996 | V (Vehicle) | 2500 | 06/20/1997 | MFR | CHRYSLER GROUP LLC | 04/28/1997 | 05/01/1997 | |||||||
Defect Summary | During assembly of the frame, a fillet weld that joins the inner steering gear attachment reinforcement to the frame rail, was omitted. | |||||||||||||||
Consequence Summary | Due to high steering load events, vehicles can exhibit broken steering gear attaching bolts or frame rail cracking at the steering gear attaching point increasing the risk of a vehicle crash. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicles for cracks in the frame rail. vehicles that show cracks will be equipped with reinforcement plates. vehicles that are found to be free of cracks will have a slot cut in the cross member and the fillet weld will be added. | |||||||||||||||
Notes | Owner notification:owner notification is expected to begin during may 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STEERING | |||||
050195 | 03/01/1995 | 39989 | Drift left under hard braking. *tw | 11/01/1995 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
STEERING - WHEEL AND HANDLE BAR | ||||||
RQ97004 | CHRYSLER GROUP LLC | 03/20/1997 | 09/18/1998 | STEERING COLUMN ASSEMBLY | 93V210000 | |
The steering column assembly may separate at the upper and lower connection causing loss of control of the vehicle |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STEERING | |||
01/08/2009 | 198000 | ||
Tl*the contact owns a 1995 jeep cherokee. while driving 10 mph, the steering box failed and separated from the frame. the steering box was hanging by the steering column and the driver lost control of the steering wheel. the vehicle was towed to the dealer and they determined that the frame cracked and caused the bolts to fail. the vehicle has not been repaired. the manufacturer informed him to take the vehicle to the dealer because it was included in a recall for the steering box; therefore, the repairs would be covered under the recall. the manufacturer called the dealer to determine the cause of the failure and called the contact back to inform him that no repairs would be covered under the recall. in addition, no compensation would be made. the failure and current mileages were 198,000. | |||
01/09/1995 | |||
While driving there was no steering. the steering wheel locked up and the driver could not turn the vehicle. *ak | |||
04/01/1996 | 2 | 04/01/1994 | |
Consumer was driving and lost control of the steering and brakes .*ak *jb | |||
09/08/1995 | 8 | ||
Steering locked up when making left urns twice. *dh | |||
01/01/1996 | |||
When turning the steering makes a loud popping noise, also gears are stuck in for drive. tt | |||
STEERING - COLUMN | |||
3 | |||
Adjustable steering wheel would create a short in ignition switch due to wires being cinked/cinched/pinched together. this causes vehicle to stall in middle of traffic. also causes turn signals to come on when not in use.*ak | |||
STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | |||
06/20/2001 | |||
Vehicle under recall 97v069000. had recall on steering gear box repaired. remedy failed not to long afterwards. took vehicle to independent mechanic, and was informed that recall was not performed properly. mechanic proceeded to correct the problem. steering gear box broke once again. towed to dealership. mechanic t indicated incorrect repairs, and proceeded to correct problem. *ak | |||
Recall 97v069000 concerning steering gear box. vehicle has been at dealership waiting for parts to be repaired for over a month. automobile nations dealer located in lithia springs , ga 770-745-3800. manufacturer has been notified.*ak | |||
05/29/1997 | |||
When driving at 20 mph consumer noticed a loud noise then lost control of the vehicle, vehicle went into a spin, hit a lamp pile. dealer determined the problem as a broken steering gear box. *ak | |||
STEERING - HYDRAULIC POWER ASSIST - POWER STEERING FLUID | |||
12/29/2004 | 92000 | 1 | |
While backing out of the driveway a noise from the engine was produced. while driving back into the driveway the power steering fluid began to pour out which caused complete steering failure. *ak | |||
STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
04/18/2002 | |||
While driving 55 mph lost control of vehicle, hit some trees, and airbags did not deploy.*ak | |||
11/16/2001 | |||
Vehicle was involved in a severe accident of 35-40 mph in which front left wheel came through the floorboard and crushed driver's left leg, and broke right leg. feel free to provide any further information concerning this matter.*ak | |||
11/26/1994 | 6 | ||
Power steering failed. | |||
STEERING - WHEEL AND HANDLE BAR | |||
01/29/1999 | |||
While driving at 25 mph and if hitting a bump, vehicle will shutdown. also, steering wheel will lock up and, the key will turn back. *ak | |||
01/01/1999 | |||
While driving at 25 mph hit a small bump and the vehicle died out, causing the steering wheel to lock up and the key was turned all the way back . *ak | |||
01/01/1999 | |||
Driveshaft had to be replaced, and the vehicle has been in the shop 27 times for service. also, consumer is having problems with the steering column/headlight's and radio and squeaking and noisy transmission. *ak | |||
07/28/1997 | 3 | ||
Noticed smoke coming from steering column while driving 45mph. parked vehicle at home & checked next day & noticed steering column had melted. took to dealer & informed did not know what caused problem & will inform driver when they know. *ak | |||
10/22/1996 | 1 | 10/30/1994 | |
Steering binds when going forward/backwards. | |||
10/12/1996 | 1 | ||
Steering column bolt sheared off, shaft inside the column fell down, and caused loss of steering while driving. *ak *jb | |||
07/20/1995 | |||
While driving the steering column makes a popping noise that can cause the steering wheel to lockup. please describe.*ak | |||
04/17/1995 | |||
Driving 25mph vehicle tried to pass .turned steering wheel it would not respond causing accident. airbag did not totally deploy. tt |