Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
0801001 | 05/25/2001 | 620059 | Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt | 07/10/2001 | |
0800600REV | 12/29/2000 | 080600 | 618049 | Subject regarding wire splice repairs. *sb | 04/03/2001 |
0832097 | 09/19/1997 | 6088834 | Information regarding nhtsa authorized airbag deactivation for medical necessity. *nlm | 01/10/2000 | |
ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
241794 | 11/01/1994 | 24-17-92 | 37858 | Pcm not properly disengaging a/c clutch via the relay also the pcm may not energize the a/c clutch relay. *tw | 01/13/1995 |
ELECTRICAL SYSTEM - WIRING | |||||
080600 | 02/25/2000 | 609995 | This bulletin provides a revised wire splice procedure and related parts. *tt | 04/12/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
08/01/2010 | 198000 | ||
Tl- the contact owns a 1993 jeep grand cherokee. the contact stated the vehicle radio, clock, and fuel gauge failed at the same time. the vehicle was taken to the garage diagnosed located the failure at the radio wires are cross causing the fuel gauge, clock, radio and battery to drain. the manufacturer will be contacted. the failure mileage was 198,000 and the current mileage was 201,000. li | |||
11/25/2008 | 0 | ||
Tl-the contact owned a 1993 jeep grand cherokee laredo. while the vehicle was parked he started the vehicle to warm it up and it caught on fire. he stated the fire started near the engine. he called the fire department and also the police department came out. a police report was filed. the vehicle was purchased used on november 19,2008. the contact stated no one was injured. the vehicle was destroyed in the fire. the contact was unable to provide a vin. the failure mileage was unknown. vwb | |||
02/04/2009 | 165700 | 1 | |
I own a 1993 jeep grand cherokee limited. engine computer bought 9/03/07 from advance auto zone. installed 9/04/07 by thompsons' in marquette. mi. jeep broke down december 17,2008. 1st engine computer bought from carquest 2/04/09. installed 2/06/09 by tompsons'(defective) price $357.97. returned the part. i ordered from advance auto zone 2/09/09. installed by thompson's 2/10/09. check engine light will not light up/ jeep will not run. price $213.99. my mechanic asked me to make sure the engine computer numbers match. they did. carquest informed me there is a national recall on the engine computer & it can take up to 6 months to get me a part. i need my vehicle running. i can't afford to buy a vehicle right now. i need alot of advice. please help! *tr | |||
05/08/2003 | 100000 | 1 | |
While driving the vehicle a normal speed, smoke emitted from the rear of the vehicle and then caught on fire. *jb | |||
07/21/2000 | 0 | ||
While driving at about 50 mph all power shutdown without warning. consumer had no power steering, and no brakes. *ak | |||
06/01/1998 | 07/15/1998 | ||
Electrical system constantly shorts out. | |||
1 | 09/01/1993 | ||
Electrical system failures on many occasions. | |||
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
05/28/1999 | 1 | 08/30/1993 | |
Alternator assembly shorted causing damage to the wiring harness terminals (burned and melted). mjs | |||
10/01/1992 | |||
Alternator/braking system/window wiring, motor mounts failed. had to be replaced. these failures could result in a crash. please provide further information.*ak | |||
Consumer heard a blast and noticed that truck was a blaze. the insurance adjustor and an electrical engineer said the cause was faulty wiring in the alternator. the manufacturer will be notified. *ak | |||
ELECTRICAL SYSTEM - BATTERY | |||
06/09/1999 | 1 | 08/30/1993 | |
Battery failed. mjs | |||
2 | 07/01/1992 | ||
Battery failed twice. | |||
04/01/1993 | 1 | ||
Battery failure. *aw | |||
ELECTRICAL SYSTEM - BATTERY - CABLES | |||
01/20/1999 | 1 | 08/30/1993 | |
Battery cable broken. mjs | |||
ELECTRICAL SYSTEM - IGNITION | |||
06/01/2000 | 7 | 10/21/1999 | |
Defective ignition coil. *mr the ignition coil had caused the vehicle to break down on numerous occasions. the consumer tried to find what the cause may have been and determined the vehicle was getting enough fuel but no spark, unfortunately this repair didn't remedy the problem. the consumer requested to be compensated for the time, money, and effort spent on fixing the vehicle. *scc *jb | |||
Intermittent stalling due to ignition coil burning out. *ak | |||
11/01/2002 | |||
Consumer states that ignition coil has failed 4x in the past two years causing vehicle to break down while driving. ts | |||
07/12/2002 | |||
Vehicle had two ignition coils replaced each year ,and propblem was reoccurring, all occurred within month of july. a third replacement is needed. manufacturer notified. feel free to provide any further information.*ak | |||
02/26/2002 | 2 | 04/01/1997 | |
No summary listed for above vehicle. *ak | |||
02/26/2002 | 1 | 06/01/1997 | |
1)ignition: in cold weather difficult to start. ignition coil failed , 2)motor mounts cracked causing engine to rotate on axis, 3) speed sensors in transmission failed, causing lack of shifting to lower gear, 4) windshield wiper control unit under dash burned out, causing smoke to fill compartment, 5) torque converter failedcoming apart ,6) brake rotors replaced as per recall, but within 2000-2500 miles replaced rotors defective (bent/warped)/and too thin to resurface | |||
1 | |||
The ignition coil failed.*jb | |||
05/13/1998 | 3 | 06/29/1992 | |
Crankshaft sensor failed two times already. consumer was traveling about 65mph on highway, and vehicle shutdown without prior notice. dealership is aware of problem. *ak vehicle shutdown due to coil failure. *yh | |||
11/09/2000 | 10 | 04/01/1996 | |
When runnning it runs normally and then when you shut it off it will not start up we have changed the fuel filter and the plug wires also new battery and cap and rotor and put a new fuel pump relay switch and also 20.00 of gas and some injector cleaner and still will not start after shutting off . *ak | |||
06/08/2000 | |||
Electrical system is causing the ignition coil to continously fail. dealer's remedy was to replace coil. the coil has been replaced on 3 different occasions and continues to burn out.*ak | |||
09/01/1993 | |||
Brakes failed within first month--cause not found. lost all power and control--ignition coil replaced twice. | |||
4 | |||
No summary | |||
4 | 04/01/1997 | ||
I have replaced electronic ignition coil 4 times in 1 1/2 yrs | |||
05/24/1998 | 2 | 08/06/1994 | |
Ignition coil, 1993 - 12/21-05/27 models. engine shut off with a medal clanking noise while driving, dealer states the wire harness was defective along with ignition coil. *ak after replacement of the ignition coil, vehicle stalled again, this time the dealer replaced the ignition coil and installed a wire harness to the ignition coil per a technical service bulletin, the improper resistance in one of the wires was causing the problems. *slc | |||
3 | |||
Engine stalled due to failed coil. | |||
03/14/1993 | 5 | ||
Engine shuts down while driving without warning, caused by electrical problem in ignition harness; nearly caused an accident. *ak | |||
03/12/1994 | |||
While driving vehicle loses power, stalls. *ak | |||
06/01/1995 | |||
Engine stalls unexpectantly. tt | |||
ELECTRICAL SYSTEM - IGNITION - ANTI-THEFT CONTROLLER | |||
01/16/2006 | 10 | ||
1) car wont start, alarm disables the engine. 2)replace pcm alarm still defective. 3)again, car wont start. *jb | |||
11/15/1999 | 100 | 06/01/1999 | |
Security system error code shows when key is turned. engine will not start until key has been turned on and off and on again several times. may take from 5 minutes to 75 minutes before starting you hear sound of fuel injection. no fuel to engine until that time. then car starts immediately. console shows rear lamp failure when all lights are working. sometimes shows this error code when lights are turned off. *ak | |||
ELECTRICAL SYSTEM - IGNITION - MODULE | |||
12/04/1996 | 05/27/1996 | ||
A malfunction within the computer caused a fire. *ak | |||
12/04/1996 | 05/27/1996 | ||
Vehicle fire caused by a malfunction in the computer. *ak | |||
ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
08/24/1998 | 1 | 06/01/1996 | |
Ignition switch failed causing the pcm module box to burn. | |||
ELECTRICAL SYSTEM - WIRING | |||
06/23/1998 | |||
Vehicle parked overnight and vehicle caught on fire. vehicle was completely destroyed. the fire occurred in the rear passenger's door. was inspected & was informed of possible electrical wiring shorting out. was noted nothing from manufacturer. *ak | |||
05/01/1998 | 10/01/1993 | ||
There was a short circuit in electrical of fuse box, causing vehicle to catch on fire. dealers noted faulty wires. *ak | |||
1 | 08/17/1993 | ||
Wiring harness problems. | |||
10/05/1997 | |||
Fire in rear of vehicle near fuel tank caused by wiring harness shorting out. *ak | |||
03/14/1995 | 1 | ||
Exposed wires in front door caused power windows to fail. | |||
04/08/1995 | |||
Electrical wires going to both of the front doors break. | |||
05/03/1997 | |||
Electrical: wiring harness on driver's side broke, replaced in feb. 1995. problem returned in april 1997. took in on may 28, and they will replace part, but will have to pay labor charges. *ak | |||
11/28/1996 | |||
Electrical short in the heater , the vehicle was in the on position and the vehicle caught fire in the heater due to a electrical wiring malfunctioning. consumer took the vehicle to the dealer and the dealer replaced the wiring harness. *ak | |||
10/15/1995 | 1 | 06/01/1993 | |
The wiring harness that controls the automatic windows and doors is broken. tt *jb | |||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
07/15/2002 | |||
Consumer states that the wire harness broke causing the windows not to go up or down. mr | |||
12/20/2000 | |||
While vehicle was parked in garage it caught on fire. took vehicle to electrical shop to find out what caused fire, fire started with a fuel leakage and burned wires where vehicle could not be repaired due to unreplaceable parts. ak | |||
07/25/1999 | |||
While driving at 70mph white smoke came from underneath the vehicle, vehicle caught on fire, and was totaled. *ak | |||
03/02/1999 | 1 | 09/01/1997 | |
Vehicle caught fire while starting engine. | |||
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
05/01/1997 | 3 | 03/01/1993 | |
Power window wiring between the drivers door and body (flex conduit) failed, and left only the driver with window control.inspection showed split insulation (fatigue) exposed conductor and open circuit. repair of wire lasted for 4-5 months before additional wires failed and or the same wire failed in a new location. wire insulation seems to be too stiff and cracked, causing stress on the conductors ,and subsequent failure. most resent failure 5-99 caused wires to melt. seatbelt failure: drivers belt will not retract, and is there for loose and unsafe. belt retractor spring was broken and sticking out of unit. *ak | |||
05/24/1998 | 2 | 08/06/1994 | |
Ignition coil, 1993 - 12/21-05/27 models. engine shut off with a medal clanking noise while driving, dealer states the wire harness was defective along with ignition coil. *ak after replacement of the ignition coil, vehicle stalled again, this time the dealer replaced the ignition coil and installed a wire harness to the ignition coil per a technical service bulletin, the improper resistance in one of the wires was causing the problems. *slc | |||
1 | 09/01/1993 | ||
Numerous components within the computer system have failed. | |||
ELECTRICAL SYSTEM - WIRING - REAR COMPARTMENT/TRUNK | |||
Electrical wiring harness that goes through engine and door pillar post has broken off. please describe details. tt |