Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| STEERING - WHEEL AND HANDLE BAR | ||||||||||||||||
| 93V210000 | CHRYSLER CORPORATION | V (Vehicle) | 115000 | 01/25/1994 | ODI | CHRYSLER GROUP LLC | 12/13/1993 | 12/30/1993 | ||||||||
| Defect Summary | The molded plastic pin which connects the upper steering column shaft and the lower column shaft may have been sheared prior to installation of the steering column assembly into the vehicle. if this occurred, the upper steering shaft will separate from the lower steering shaft. | |||||||||||||||
| Consequence Summary | If the upper and lower steering shafts separate, completeloss of steering control will occur, which could result in an accident. | |||||||||||||||
| Corrective Summary | A restraining sleeve will be added to the intermediate shaft to limit the amount of steering shaft movement available. | |||||||||||||||
| Notes | System: steering; column shaft; upper.vehicle description: multipurpose passenger vehicles.note: if you have a problem obtaining the needed repair, please contact thechrysler zone office in your area. it is listed under service assistance inyour owner's manual. a zone representative will arrange for prompt attention toyour vehicle. also contact the national highway traffic safety administration'sauto safety hotline at 1-800-424-9393. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STEERING | |||||
| 050195 | 03/01/1995 | 39989 | Drift left under hard braking. *tw | 11/01/1995 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| STEERING | ||||||
| PE93091 | CHRYSLER GROUP LLC | 10/13/1993 | 01/25/1994 | STEERING SHAFT FAILURE | 93V210000 | |
| There is no summary currently available | ||||||
| DP97004 | CHRYSLER GROUP LLC | 10/01/1997 | 01/20/1998 | VISCOUS COUPLING FAILURE | ||
| Alleged that the viscous coupling in the transfer case of his 1993 grand cherokee vehicle failed which affected steering, braking and starting of the vehicle. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING | |||
| 05/20/2009 | 131000 | ||
| Tl*the contact owns a 1993 jeep grand cherokee. the contact stated that the steering suddenly failed in her vehicle while driving away from her residence. the bolt that connects the entire gear box exploded. the vehicle was inspected by a mechanic and the contact was informed that an entirely new gear box and a new steering column were needed. the dealer stated that the vin was not included in nhtsa campaign id number 93v210000 (steering:wheel and handle bar), although the failures were identical. the dealer would not assist. the vehicle will be repaired at the contact's expense. the failure and current mileages were 131,000. | |||
| 04/11/2007 | 260401 | 1 | 05/15/1997 |
| After driving 125 miles to a sales location, i pulled off of i-85 to make a few cell calls before my meeting. i sat in the car with it idling in a shopping center parking lot making my calls. after about 10 minutes i put the jeep in drive and started rolling through the parking lot. i turned the steering wheel left/right with no response. the front wheels did not respond to the steering wheel at all. had it towed to my mechanic. the 3 bolts holding the steering box to the frame had sheared. two of three bolt tops were still in the steering box, one had dropped out. the three broken studs were still in the frame with the blue thread locker still in place. no warning, no wandering steering, no pop, no nothing. no service had ever been performed on the steering box. rolled in off i-85 where i was doing 70 mph to this parking lot and that was it. had i waited to get off at the next exit, well, i probably would not be writing this now. *tr | |||
| 01/01/1901 | 7 | ||
| Problems with steering equipment on 1993 jeep cherokee.*mr the steering damper has failed on seven different occasions. each time it has happened, the steering wheel shakes uncontrollably and the consumer could barely steer the car off the road to the breakdown lane. *bf *nm | |||
| 1 | |||
| Consumer states that after waiting four hours to have recall done, was told that part were not available. nlm | |||
| 1 | |||
| Vehicle experiencing inproper function of the steering unit. *yc | |||
| 03/27/1999 | 1 | ||
| Steering damper failed. *yc | |||
| 04/25/1997 | 1 | 03/04/1997 | |
| Steering damper failed. | |||
| 1 | 01/05/1996 | ||
| Steering vibration at high speeds. | |||
| STEERING - COLUMN | |||
| 01/12/2004 | 149000 | 1 | |
| Steering column separation just as recall #604 mentions. pin sheared off and column separates. per nhtsa 93v-210 recall. dealer refuses to fix per recall says vehicle not part of recall. *la | |||
| STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | |||
| 08/08/2003 | 141768 | 1 | 09/03/1999 |
| Steering gear mounting failure; while driving at 30mpg complete loss of steering occured. one of the 3 mounting bolts had sheered off, another bolt was in place but the bolt tab had broken from the steering gear, and the third bolt was still connected to the steering gear. this vechicle has 141k miles and is not abused or used for off road driving. there was no corrosion on bolts or steering gear. failure of this part at highway speeds could be fatal | |||
| 05/12/2002 | |||
| Consumer was traveling approximately 20mph when total steering was lost. bolts anchoring steering gear box broke due to corrosion. consumer lost slight vehicle control. manufacturerwas contacted. please provide more information.*ak | |||
| 12/31/2001 | 1 | 04/01/1997 | |
| While backing out of parking space with steering wheel turned to right, a very loud noise was heard and steering lost. a 4 bolt with threads sheared off was located on ground under vehicle. a repair shop reported that the entire steering box had separated from the vehicle frame. of the three steering box attach bolts, one was still holding a portion of a mounting ear that had previously cracked and separated from the steering box; one had sheared at the threads and was missing; and the third had sheared at the threads and located on the ground. this loss of steering at highway speeds could have resulted in fatal crash. | |||
| Steering would make noises whenever turning. it would not return to original position afterwards. took to several mechanics. was informed by first mechanic it was suspension, and not safe to drive. another mechanic informed consumer it was gear box causing noise. also, driver's door came apart at seams, holding it together with a rope. *ak | |||
| 03/21/2000 | 1 | 08/30/1993 | |
| Steering gear assembly replaced. mjs | |||
| 06/04/1998 | 1 | 02/01/1993 | |
| Vehicle vibrates due to failure of the tie rods, shock absorber and steering gear assembly. | |||
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||
| 06/01/1999 | 1 | 04/01/1998 | |
| Truck seems to be falling apart after 100,000 - numerous items: speed sensor failed, oil sensor and coolent sensor alway on, even at proper levels, rear door rattles, head gasket starting to go, numerous rattles, engine leakes oil, starting to rust | |||
| 07/03/2000 | 1 | 10/01/1993 | |
| Power steering leaked at return line fitting on reservoir, fitting on reservoir broken off due to excessive heat that builds up in engine compartment. i have had to replace other plastic components in the engine compartment which have become brittle from seven years of exposure to heat build up within engine compartment. this failure could have caused engine fire, steering fluid was spraying onto exshaust manifold, feel very lucky that i did not have a fire. | |||
| 07/07/1995 | 1 | 02/01/1993 | |
| Power steering pump leaks. | |||
| 02/18/1997 | 4 | 07/22/1993 | |
| Was driving and the steering locked up, took to mechanic an replaced the the power steering pump. *ak | |||
| 07/22/1993 | 2 | ||
| Power steering pump failed, causing steering to lock up. *dh | |||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
| 09/12/1995 | 2 | ||
| Power steering failed. *dsh | |||
| 07/19/1994 | 1 | ||
| Replaced steering damper. *ak | |||
| 01/01/1995 | 1 | ||
| Steering damper failed, causing vehicle to wobble/vibrate when braking. *ak | |||
| STEERING - LINKAGES | |||
| 01/22/2002 | 1 | 04/01/2001 | |
| While driving could hear loud noise coming from shock absorber. it will not hold when driving over a hole. had contacted dealer. *ak the left front end of the vehicle had vibration due to outer and inner tie rod failures. the seal and the cylinder on the rear left and right failed. *yh | |||
| 12/07/1998 | 1 | 08/30/1993 | |
| Steering dampener failed causing leakage, causing vibration. mjs | |||
| STEERING - LINKAGES - KNUCKLE - SPINDLE - ARM | |||
| 11/21/2000 | 1 | ||
| Steering knuckles worn. *slc | |||
| 09/10/1996 | |||
| Abs, brake failure, while driving applied brakes had complete brakes failure, rotor broke, causing knuckle to break and a loss of steering. *ak | |||
| STEERING - LINKAGES - ROD - RELAY - CONNECTING | |||
| 06/04/1998 | 1 | 02/01/1993 | |
| Vehicle vibrates due to failure of the tie rods, shock absorber and steering gear assembly. | |||
| STEERING - LINKAGES - TIE ROD ASSEMBLY | |||
| 01/22/2002 | 1 | 04/01/2001 | |
| While driving, consumer could step on the brake pedal and could feel pedal pulsating, front rotors had to be replaced due to sticking, also seal had to be fixed. *ak consumer states the tie rod ends failed and was replaced. *yh | |||
| 03/21/2000 | 1 | 08/30/1993 | |
| Tie rod end at steering box needs repairs. mjs | |||
| 12/19/1999 | 15 | 08/01/1997 | |
| Intermittent problem, while engine is running the engine cuts off. after 10 - 15 minutes the engine will restart. engine failure every ~ 10 miles. fuel pressure is ok. coils and ecm are ok. no clear diagnostic indication of error. *ak | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 06/13/2003 | 138000 | 1 | |
| Nhtsa#the molded plastic pin which connects the upper steering column shaft and the lower column shaft may have been sheared prior to installation of the steering column assembly into the vehicle. if this occurred, the upper steering shaft will separate from the lower steering shaft. the consumer has the same problem. however this vehicle was not under recall due to vin. *ak the driver lost control of the vehicle when the steering column failed. it was discovered at the garage that the steering column had come apart and needed to be replaced. *scc *jb | |||
| While parking vehicle, consumer turned steering wheel to the right. consumer heard a popping noise from within the steering column. vehicle lost power steering. ts | |||
| 06/28/2002 | |||
| While traveling about 15mph on a side road steering and brakes lock up. dealership is aware of problem.*ak | |||
| 02/02/2002 | 3 | 05/01/1993 | |
| Viscous coupling was replaced at 47,000 - 94,000 and now needing replacement at 116,00 miles. this item causes vehicle to have hard steering and even stopping vehicle when turning sharply and slow. making turns now involve backing up unnecessarily and doing 3 point turns instead or simple turning. a very dangerous situation and costly repairing this failure that was unique to 93 vehicles and corrected the next year. unfortunally, 1993 owners are left to fare for themselves.*ak | |||
| Steering column has rotated which caused cruise control to be on top instead of on side. contacted the manufacturer, and was informed there were no recalls or technical service bulletins. there should be no problem with steering. *ak | |||
| 1 | 08/17/1993 | ||
| Steering column problems. | |||
| Recall #93v210000 part was replaced three times, problem still exists. tt | |||