Investigations

NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
FUEL SYSTEM, GASOLINE
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, GASOLINE - STORAGE
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, OTHER
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, OTHER - STORAGE
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - FILLING/CHARGING
PE10032CHRYSLER GROUP LLC08/23/201002/16/2011Fuel Spill During Refueling
 Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb.
PE10032CHRYSLER GROUP LLC08/23/2010Fuel Spill During Refueling
 Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.

Consumer Complaints

Fail datemilesoccurencesPurchase date
FUEL SYSTEM, GASOLINE
04/04/2011100000
 Gas overflows instead of stopping when full. this happens whenever filling tank. dealer wanted 500.00 to replace entire tank as the answer when clearly the issue is with vent. gas spills around vehicle.
12/27/201065000
 Fuel spills out of fuel filler neck when filling tank completely. this happens every time i fill up my vehicle, spilling fuel on the side of the vehicle, bumper and ground.
01/01/2007100
 When fueling the gas tank, the auto-shutoff valve at any service station will not shut off in time to prevent fuel splash out of the filler pipe and get on the person doing the fueling and pours down on the ground. this is not isolated to just a few service stations - it happens each and every time you fill this vehicle with gas.
08/14/2011
 Each and every time i fill my gas tank the pump will cease the flow of gas from the nozzle and large quantities of gasoline will backwash/overflow from the tank. this is extremely dangerous for owners of jeeps with this issue. god forbid if someone is smoking around the area. as silly as that idea may be remember who sued mcdonalds corp. for spilling hot coffee on themselves and won millions! just because they didn't tell you the coffee wasn't hot doesn't mean it's not common sense just as is gasoline spilling violently from your vehicles gas tank is very dangerous with the potential to cause large amounts of property damage and loss of life. the gas tank needs to be recalled and modified or replaced.
03/13/201040000
 When filling gas, gas blows back onto person filling and draining down vehicle. told there was extended recall, but never received anything from manufacturer. told to submit issue to govt. contacted dealership who told me i would have to wait for letter, but never received any for this, however received others.
08/18/20071000
 I purchased a 2007 jeep wrangler rubicon new. shortly after purchase, i discovered that gasoline would frequently overflow the filler port when fueling the vehicle. for some reason, once the pump shuts off, fuel overflows the port and flows over the side of the vehicle and onto the ground.
07/10/2011
 Whenever i put gas into my tank and fill up, there is always an overflow of gasolline spilling out of the tank and onto my jeep as well as onto the floor. aside from the damage being done to my vehicle, this causes damage to the enviroment from fumes as well as raising the potential for fires.
07/13/201172000
 Every time i fill my jeep wrangler with gas as soon as the gas pump stops pumping it spits fuel back out of the filler tube. i have tried several gas stations and it happens every time.
06/26/201155500
 In the last month i have had a problem with gas overflowing out of the fuel tank filler after the gas pump clicks off. the gas comes out and runs down the side of my vehicle and onto the ground. the problem has occured during 3 out of 4 fill-ups in the last month. i have not done anything yet to correct the issue.
02/10/2010
 When filling up my 2007 jeep rubicon, after the pump handle clicks off fuel will spill out of the filler neck. it happens anytime from immediately after the pump stops to up to 5 seconds after. this happens about one-third of the time no matter what station i use of the prand of fuel that is put into the vehicle. i have owned the jeep for approx. 1 year and has done this since the week i've owned it. the vehicle has less than 20k miles on it.
03/15/201158000
 Vehicle spits out fuel if you allow the auto shut off to run from the pump. if i fill up my tank until the pump shuts off it will overflow about a quart of fuel on the floor. took it to the dealer but they said it did not happen for them. i have recorded the next three fill ups and it did it every time. my vehicle is a 2007 but was built in 10/2006. chrysler has issued a fix for this problem on similar vehicles built after 03/2007.
02/10/2010
 When filling up my 2007 jeep rubicon, after the pump handle clicks off fuel will spill out of the filler neck. it happens anytime from immediately after the pump stops to up to 5 seconds after. this happens about one-third of the time no matter what station i use of the prand of fuel that is put into the vehicle. i have owned the jeep for approx. 1 year and has done this since the week i've owned it. the vehicle has less than 20k miles on it.
03/15/201158000
 Vehicle spits out fuel if you allow the auto shut off to run from the pump. if i fill up my tank until the pump shuts off it will overflow about a quart of fuel on the floor. took it to the dealer but they said it did not happen for them. i have recorded the next three fill ups and it did it every time. my vehicle is a 2007 but was built in 10/2006. chrysler has issued a fix for this problem on similar vehicles built after 03/2007.
02/10/2010
 When filling up my 2007 jeep rubicon, after the pump handle clicks off fuel will spill out of the filler neck. it happens anytime from immediately after the pump stops to up to 5 seconds after. this happens about one-third of the time no matter what station i use of the prand of fuel that is put into the vehicle. i have owned the jeep for approx. 1 year and has done this since the week i've owned it. the vehicle has less than 20k miles on it.
03/15/201158000
 Vehicle spits out fuel if you allow the auto shut off to run from the pump. if i fill up my tank until the pump shuts off it will overflow about a quart of fuel on the floor. took it to the dealer but they said it did not happen for them. i have recorded the next three fill ups and it did it every time. my vehicle is a 2007 but was built in 10/2006. chrysler has issued a fix for this problem on similar vehicles built after 03/2007.
02/04/201090000
 Every time i fuel up my 2007 jeep wrangler x, the gas overflows. this has caused the gas to spill onto the ground and or onto my feet. i have been told that this problem is quite prevalent with other jeep owners. i am the second owner of this vehicle and purchased it in feb. of 2010. it has occured ever since i first fueled it.
03/03/201116500
 Purchased a 2007 jeep wrangler jk about 6 weeks ago. i have tried different gas stations. gas will spill out when filling up. pump nozzle will release/pop after gas is already over flowed and on the ground.
06/01/20080
 My 2007 jeep wrangler spits back fuel when filling the gas tank. this has been going on since i bought the jeep. i have had the fuel tank, o-ring, fuel pump and level unit replaced
03/03/201116500
 Purchased a 2007 jeep wrangler jk about 6 weeks ago. i have tried different gas stations. gas will spill out when filling up. pump nozzle will release/pop after gas is already over flowed and on the ground.
06/01/20080
 My 2007 jeep wrangler spits back fuel when filling the gas tank. this has been going on since i bought the jeep. i have had the fuel tank, o-ring, fuel pump and level unit replaced
03/03/201116500
 Purchased a 2007 jeep wrangler jk about 6 weeks ago. i have tried different gas stations. gas will spill out when filling up. pump nozzle will release/pop after gas is already over flowed and on the ground.
06/01/20080
 My 2007 jeep wrangler spits back fuel when filling the gas tank. this has been going on since i bought the jeep. i have had the fuel tank, o-ring, fuel pump and level unit replaced
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
03/03/201116500
 Purchased a 2007 jeep wrangler jk about 6 weeks ago. i have tried different gas stations. gas will spill out when filling up. pump nozzle will release/pop after gas is already over flowed and on the ground.
06/01/20080
 My 2007 jeep wrangler spits back fuel when filling the gas tank. this has been going on since i bought the jeep. i have had the fuel tank, o-ring, fuel pump and level unit replaced
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
02/08/201144487
 Gas tank overflows when gas pump is left in automatic position. there has been a recall for my year and model of vehicle, but it's not within the manufacture date of the recall. there are many other jeep wrangler owners with the exact same problem. i am a firefighter, so i do realize that this is a very serious safety issue that needs to be addressed as soon as possible. the manufacture date is 12/06.
10/23/200932000
 I own a 2007 jeep wrangler 2-dr rubicon model that chrysler's recently released tsb to replace gas tanks due to fuel tank overflow and spillage does not cover. my build date is 11-06 and is prior to the 3-07 beginning build date that chrysler will repair. i have this fuel overflow and spillage problem every time i fill up. first i would do everything to avoid spilling fuel for my and others safety however after being left out of the tsb from chrysler and you all closing the case on the incident i feel completely disenfranchised and i have decided to let you know the seriousness and need for this to expedited that i will no longer be careful and i will allow this problem to occur everytime i fill up. this opinion is shared by many others and our idea is we are going to give this problem every chance of being as disasterous as possible to get this problem solved as quickly as possible. i know this tactic is not safe or responsible however neither is what has been done wit this situation all together. hopefully this dangerous and aggravating situation can be resolved quickly.
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
02/08/201144487
 Gas tank overflows when gas pump is left in automatic position. there has been a recall for my year and model of vehicle, but it's not within the manufacture date of the recall. there are many other jeep wrangler owners with the exact same problem. i am a firefighter, so i do realize that this is a very serious safety issue that needs to be addressed as soon as possible. the manufacture date is 12/06.
10/23/200932000
 I own a 2007 jeep wrangler 2-dr rubicon model that chrysler's recently released tsb to replace gas tanks due to fuel tank overflow and spillage does not cover. my build date is 11-06 and is prior to the 3-07 beginning build date that chrysler will repair. i have this fuel overflow and spillage problem every time i fill up. first i would do everything to avoid spilling fuel for my and others safety however after being left out of the tsb from chrysler and you all closing the case on the incident i feel completely disenfranchised and i have decided to let you know the seriousness and need for this to expedited that i will no longer be careful and i will allow this problem to occur everytime i fill up. this opinion is shared by many others and our idea is we are going to give this problem every chance of being as disasterous as possible to get this problem solved as quickly as possible. i know this tactic is not safe or responsible however neither is what has been done wit this situation all together. hopefully this dangerous and aggravating situation can be resolved quickly.
10/01/201065000
 Fuel gushes out of the filler neck on my 2007 jeep wrangler when i fill up the tank. result is gas soaked hand, pants and shoes with spillage on the ground at the pump and gas running down the side of my jeep. this happens every time i fill up. this has got to be a huge safety issue!
01/10/201128000
 2007 jeep wrangler x when filling the gas tank, it flows back, almost a 1/4 of a gallon of gas.
01/25/201129000
 Everytime i fill up my 2007 jeep wrangler at the gas station, it overflows about 1/2 gallon of fuel down the side of my jeep and onto the ground. i have tried using different pump stations, but nothing stops it from overflowing.
02/08/201144487
 Gas tank overflows when gas pump is left in automatic position. there has been a recall for my year and model of vehicle, but it's not within the manufacture date of the recall. there are many other jeep wrangler owners with the exact same problem. i am a firefighter, so i do realize that this is a very serious safety issue that needs to be addressed as soon as possible. the manufacture date is 12/06.
10/23/200932000
 I own a 2007 jeep wrangler 2-dr rubicon model that chrysler's recently released tsb to replace gas tanks due to fuel tank overflow and spillage does not cover. my build date is 11-06 and is prior to the 3-07 beginning build date that chrysler will repair. i have this fuel overflow and spillage problem every time i fill up. first i would do everything to avoid spilling fuel for my and others safety however after being left out of the tsb from chrysler and you all closing the case on the incident i feel completely disenfranchised and i have decided to let you know the seriousness and need for this to expedited that i will no longer be careful and i will allow this problem to occur everytime i fill up. this opinion is shared by many others and our idea is we are going to give this problem every chance of being as disasterous as possible to get this problem solved as quickly as possible. i know this tactic is not safe or responsible however neither is what has been done wit this situation all together. hopefully this dangerous and aggravating situation can be resolved quickly.
01/05/201120000
 While fueling, the gas tank and vent pipe cause back pressure resulting in fuel spray and overflow. the overflow can cover the person filling in fuel and spill up to a gallon of gasoline on the vehicle and ground.
02/08/201144487
 Gas tank overflows when gas pump is left in automatic position. there has been a recall for my year and model of vehicle, but it's not within the manufacture date of the recall. there are many other jeep wrangler owners with the exact same problem. i am a firefighter, so i do realize that this is a very serious safety issue that needs to be addressed as soon as possible. the manufacture date is 12/06.
10/23/200932000
 I own a 2007 jeep wrangler 2-dr rubicon model that chrysler's recently released tsb to replace gas tanks due to fuel tank overflow and spillage does not cover. my build date is 11-06 and is prior to the 3-07 beginning build date that chrysler will repair. i have this fuel overflow and spillage problem every time i fill up. first i would do everything to avoid spilling fuel for my and others safety however after being left out of the tsb from chrysler and you all closing the case on the incident i feel completely disenfranchised and i have decided to let you know the seriousness and need for this to expedited that i will no longer be careful and i will allow this problem to occur everytime i fill up. this opinion is shared by many others and our idea is we are going to give this problem every chance of being as disasterous as possible to get this problem solved as quickly as possible. i know this tactic is not safe or responsible however neither is what has been done wit this situation all together. hopefully this dangerous and aggravating situation can be resolved quickly.
01/05/201120000
 While fueling, the gas tank and vent pipe cause back pressure resulting in fuel spray and overflow. the overflow can cover the person filling in fuel and spill up to a gallon of gasoline on the vehicle and ground.
10/23/200932000
 I own a 2007 jeep wrangler 2-dr rubicon model that chrysler's recently released tsb to replace gas tanks due to fuel tank overflow and spillage does not cover. my build date is 11-06 and is prior to the 3-07 beginning build date that chrysler will repair. i have this fuel overflow and spillage problem every time i fill up. first i would do everything to avoid spilling fuel for my and others safety however after being left out of the tsb from chrysler and you all closing the case on the incident i feel completely disenfranchised and i have decided to let you know the seriousness and need for this to expedited that i will no longer be careful and i will allow this problem to occur everytime i fill up. this opinion is shared by many others and our idea is we are going to give this problem every chance of being as disasterous as possible to get this problem solved as quickly as possible. i know this tactic is not safe or responsible however neither is what has been done wit this situation all together. hopefully this dangerous and aggravating situation can be resolved quickly.
01/05/201120000
 While fueling, the gas tank and vent pipe cause back pressure resulting in fuel spray and overflow. the overflow can cover the person filling in fuel and spill up to a gallon of gasoline on the vehicle and ground.
01/02/201170000
 2007 jeep wrangler gas tank overflows during/ after refueling ( surge of fuel) happens every time tops of tanks
10/12/201033000
 Gas tank overflows on every single fill up at multiple gas stations.
01/02/201170000
 2007 jeep wrangler gas tank overflows during/ after refueling ( surge of fuel) happens every time tops of tanks
10/12/201033000
 Gas tank overflows on every single fill up at multiple gas stations.
01/02/201170000
 2007 jeep wrangler gas tank overflows during/ after refueling ( surge of fuel) happens every time tops of tanks
10/12/201033000
 Gas tank overflows on every single fill up at multiple gas stations.
02/07/201035000
 Tl-the contact owns a 2007 jeep wrangler 2 door 4x4. the contact stated that when going to fill up his gas tank the fuel would spill back out after completion. the vehicle was inspected by a dealer they advised him that they were unaware of any defect. the vehicle has not been inspected nor has it been repaired. the failure mileage was approximately 35,000. tb
01/08/201140000
 My jeep gas tank overflows when filling the tank at the gas station.
02/07/201035000
 Tl-the contact owns a 2007 jeep wrangler 2 door 4x4. the contact stated that when going to fill up his gas tank the fuel would spill back out after completion. the vehicle was inspected by a dealer they advised him that they were unaware of any defect. the vehicle has not been inspected nor has it been repaired. the failure mileage was approximately 35,000. tb
01/08/201140000
 My jeep gas tank overflows when filling the tank at the gas station.
10/21/201035000
 About three months ago fuel starting spilling out of vehicle during re-fueling
02/07/201035000
 Tl-the contact owns a 2007 jeep wrangler 2 door 4x4. the contact stated that when going to fill up his gas tank the fuel would spill back out after completion. the vehicle was inspected by a dealer they advised him that they were unaware of any defect. the vehicle has not been inspected nor has it been repaired. the failure mileage was approximately 35,000. tb
10/21/201035000
 About three months ago fuel starting spilling out of vehicle during re-fueling
02/07/201035000
 Tl-the contact owns a 2007 jeep wrangler 2 door 4x4. the contact stated that when going to fill up his gas tank the fuel would spill back out after completion. the vehicle was inspected by a dealer they advised him that they were unaware of any defect. the vehicle has not been inspected nor has it been repaired. the failure mileage was approximately 35,000. tb
01/08/201140000
 My jeep gas tank overflows when filling the tank at the gas station.
10/21/201035000
 About three months ago fuel starting spilling out of vehicle during re-fueling
01/08/201140000
 My jeep gas tank overflows when filling the tank at the gas station.
10/21/201035000
 About three months ago fuel starting spilling out of vehicle during re-fueling
11/24/2010
 I have a 2007 jeep wrangler rubicon 2-door and every time i fill gasoline it spews out everywhere and this does not matter how fast the flow of gas is or at what depth the pump handle is. it is enough gas to come up and out of the filler tube run down my rear quarter panel and make a puddle on the ground. not a safe situation with the uncontrollable discharge of a highly flamable liquid.
01/16/2010200
 My 2007 jeep wrangler overfills when ever i add gas. this results in sometimes spraying on me but, always spilling over onto the vehicle and ground.
12/01/20091000
 Filling the fuel tank till the pump nozzle shuts off automatically will result in a fuel spill. this condition has existing since new. rate of occurrence is approximately 8 out of 10 fillings. resulting spill is sufficient to wet the side of the vehicle, left end of rear bumper, and the ground below the fill port. spill quantity estimated at approximately 8 - 10 ounces of fuel each occurrence.
01/16/2010200
 My 2007 jeep wrangler overfills when ever i add gas. this results in sometimes spraying on me but, always spilling over onto the vehicle and ground.
12/01/20091000
 Filling the fuel tank till the pump nozzle shuts off automatically will result in a fuel spill. this condition has existing since new. rate of occurrence is approximately 8 out of 10 fillings. resulting spill is sufficient to wet the side of the vehicle, left end of rear bumper, and the ground below the fill port. spill quantity estimated at approximately 8 - 10 ounces of fuel each occurrence.
11/01/201032425
 Fuel overflow beginning at 32,345 miles on an 07 jeep wrangler x model.
06/17/2010
 07 jeep wrangler 2 door rubicon spills gas at every fill up of the tank before the pump nozzle clicks off. spill down rear of jeep and makes a puddle on ground.
12/01/20091000
 Filling the fuel tank till the pump nozzle shuts off automatically will result in a fuel spill. this condition has existing since new. rate of occurrence is approximately 8 out of 10 fillings. resulting spill is sufficient to wet the side of the vehicle, left end of rear bumper, and the ground below the fill port. spill quantity estimated at approximately 8 - 10 ounces of fuel each occurrence.
11/01/201032425
 Fuel overflow beginning at 32,345 miles on an 07 jeep wrangler x model.
06/17/2010
 07 jeep wrangler 2 door rubicon spills gas at every fill up of the tank before the pump nozzle clicks off. spill down rear of jeep and makes a puddle on ground.
11/01/201032425
 Fuel overflow beginning at 32,345 miles on an 07 jeep wrangler x model.
06/17/2010
 07 jeep wrangler 2 door rubicon spills gas at every fill up of the tank before the pump nozzle clicks off. spill down rear of jeep and makes a puddle on ground.
01/03/200723667
 About 1 out of every 2 times i refuel my 2007 jeep wrangler x, it doesnt sense that it is full and overflows all over the vehicle, ground, and myself. not good for the environment, my paint, and my exposure to gasoline on my skin.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
01/03/200723667
 About 1 out of every 2 times i refuel my 2007 jeep wrangler x, it doesnt sense that it is full and overflows all over the vehicle, ground, and myself. not good for the environment, my paint, and my exposure to gasoline on my skin.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
12/28/201023000
 2007 jeep wrangler. gas overflows when refueling. it happens when you just let the pump click off when full. i have never tried to overfill it, or top it off. you simply fill until the pump clicks, and then a fair amount of fuel seems to bubble back out. it runs down the side of the vehicle and then leaves a fairly large puddle on the ground. this is definately a safety hazard. this did not happen for about the first 2-1/2 years of ownership (23,000 miles) now it is just about every fill up.
01/03/200723667
 About 1 out of every 2 times i refuel my 2007 jeep wrangler x, it doesnt sense that it is full and overflows all over the vehicle, ground, and myself. not good for the environment, my paint, and my exposure to gasoline on my skin.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
12/28/201023000
 2007 jeep wrangler. gas overflows when refueling. it happens when you just let the pump click off when full. i have never tried to overfill it, or top it off. you simply fill until the pump clicks, and then a fair amount of fuel seems to bubble back out. it runs down the side of the vehicle and then leaves a fairly large puddle on the ground. this is definately a safety hazard. this did not happen for about the first 2-1/2 years of ownership (23,000 miles) now it is just about every fill up.
01/03/200723667
 About 1 out of every 2 times i refuel my 2007 jeep wrangler x, it doesnt sense that it is full and overflows all over the vehicle, ground, and myself. not good for the environment, my paint, and my exposure to gasoline on my skin.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
12/28/201023000
 2007 jeep wrangler. gas overflows when refueling. it happens when you just let the pump click off when full. i have never tried to overfill it, or top it off. you simply fill until the pump clicks, and then a fair amount of fuel seems to bubble back out. it runs down the side of the vehicle and then leaves a fairly large puddle on the ground. this is definately a safety hazard. this did not happen for about the first 2-1/2 years of ownership (23,000 miles) now it is just about every fill up.
01/03/200723667
 About 1 out of every 2 times i refuel my 2007 jeep wrangler x, it doesnt sense that it is full and overflows all over the vehicle, ground, and myself. not good for the environment, my paint, and my exposure to gasoline on my skin.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
12/28/201023000
 2007 jeep wrangler. gas overflows when refueling. it happens when you just let the pump click off when full. i have never tried to overfill it, or top it off. you simply fill until the pump clicks, and then a fair amount of fuel seems to bubble back out. it runs down the side of the vehicle and then leaves a fairly large puddle on the ground. this is definately a safety hazard. this did not happen for about the first 2-1/2 years of ownership (23,000 miles) now it is just about every fill up.
05/31/200730
 Starting from the first time i filled my gas tank on my 2007 jeep wrangler 2 door xs package, every time i fill or come close to filling the gas tank and the pump automatically shuts off the fuel spills/ and or sprays out of the fuel filling tube. many times it has sprayed me or whoever is pumping the gas.
12/27/201043450
 When refueling, when the tank is full and the fuel pump nozzle shuts off, fuel splashes out of the fill neck. this happens on each fill up.
09/09/201027000
 Jeep is a 2007 wrangler. when filling up, gasoline overflows out of the fuel tank just as the tank gets full. started at about 27k miles. jeep now has 28,500 miles. it does not matter if the fuel tank starts out empty or if it is half full. it spills out every time now. the gas spills out onto the vehicle and runs onto the ground. this can't be good for the environment. in addition i get gasoline on my hands which is not healthy.
12/28/201023000
 2007 jeep wrangler. gas overflows when refueling. it happens when you just let the pump click off when full. i have never tried to overfill it, or top it off. you simply fill until the pump clicks, and then a fair amount of fuel seems to bubble back out. it runs down the side of the vehicle and then leaves a fairly large puddle on the ground. this is definately a safety hazard. this did not happen for about the first 2-1/2 years of ownership (23,000 miles) now it is just about every fill up.
05/31/200730
 Starting from the first time i filled my gas tank on my 2007 jeep wrangler 2 door xs package, every time i fill or come close to filling the gas tank and the pump automatically shuts off the fuel spills/ and or sprays out of the fuel filling tube. many times it has sprayed me or whoever is pumping the gas.
12/27/201038642
 Fuel overflows out of tank.
05/31/200730
 Starting from the first time i filled my gas tank on my 2007 jeep wrangler 2 door xs package, every time i fill or come close to filling the gas tank and the pump automatically shuts off the fuel spills/ and or sprays out of the fuel filling tube. many times it has sprayed me or whoever is pumping the gas.
12/27/201038642
 Fuel overflows out of tank.
12/02/201051000
 1) this failure happens at the end of refueling my gas tank. just about the time the tank hits the full point. 2) the failure is that the gas sprays out of the tank when the tank hits the full mark. this causes the entire side of the car and bumper to be covered in gasoline as well as my hands and clothing 3) so far nothing has been done to correct the problem other than just not filling the tank to full.
11/15/201020000
 2007 jeep wrangler x fuel spits back when filling. started at about 20,000 miles.
12/27/201038642
 Fuel overflows out of tank.
12/02/201051000
 1) this failure happens at the end of refueling my gas tank. just about the time the tank hits the full point. 2) the failure is that the gas sprays out of the tank when the tank hits the full mark. this causes the entire side of the car and bumper to be covered in gasoline as well as my hands and clothing 3) so far nothing has been done to correct the problem other than just not filling the tank to full.
11/15/201020000
 2007 jeep wrangler x fuel spits back when filling. started at about 20,000 miles.
12/27/201038642
 Fuel overflows out of tank.
12/02/201051000
 1) this failure happens at the end of refueling my gas tank. just about the time the tank hits the full point. 2) the failure is that the gas sprays out of the tank when the tank hits the full mark. this causes the entire side of the car and bumper to be covered in gasoline as well as my hands and clothing 3) so far nothing has been done to correct the problem other than just not filling the tank to full.
11/15/201020000
 2007 jeep wrangler x fuel spits back when filling. started at about 20,000 miles.
12/19/201045782
 When refueling my vehicle, gasoline spills out of the filler tube and on to the vehicle and the person refueling.
12/02/201051000
 1) this failure happens at the end of refueling my gas tank. just about the time the tank hits the full point. 2) the failure is that the gas sprays out of the tank when the tank hits the full mark. this causes the entire side of the car and bumper to be covered in gasoline as well as my hands and clothing 3) so far nothing has been done to correct the problem other than just not filling the tank to full.
11/15/201020000
 2007 jeep wrangler x fuel spits back when filling. started at about 20,000 miles.
12/19/201045782
 When refueling my vehicle, gasoline spills out of the filler tube and on to the vehicle and the person refueling.
12/17/201035000
 When filling up 2007 jeep wrangler fuel spills everywhere when the pump clicks off. the happens every time when filling the tank.
10/15/200827000
 Tl-the contact owns a 2008 jeep wrangler. while filling the vehicle with gasoline it will spill over and out. the vehicle was taken to the dealer who stated there is no fix for this failure. the manufacturer was contacted and a claim was file. the failure mileage was 27,000.-mw
12/17/201035497
 When filling the gas tank using the auto shutoff on the pump handle, the gas tank shoots gas out all over just after the auto shutoff clicks off. it has sprayed on me and the ground and the vehical.
12/16/201034788
 Every time i refuel my 2007 jeep wrangler, fuel spills. when the tank is full the gas pump kicks off and fuel gushes from fuel filler... it does not matter where i get fuel or how much fuel is in tank when i begin filling... it always spills...
12/17/201035000
 When filling up 2007 jeep wrangler fuel spills everywhere when the pump clicks off. the happens every time when filling the tank.
10/15/200827000
 Tl-the contact owns a 2008 jeep wrangler. while filling the vehicle with gasoline it will spill over and out. the vehicle was taken to the dealer who stated there is no fix for this failure. the manufacturer was contacted and a claim was file. the failure mileage was 27,000.-mw
12/17/201035497
 When filling the gas tank using the auto shutoff on the pump handle, the gas tank shoots gas out all over just after the auto shutoff clicks off. it has sprayed on me and the ground and the vehical.
12/16/201034788
 Every time i refuel my 2007 jeep wrangler, fuel spills. when the tank is full the gas pump kicks off and fuel gushes from fuel filler... it does not matter where i get fuel or how much fuel is in tank when i begin filling... it always spills...
10/15/200827000
 Tl-the contact owns a 2008 jeep wrangler. while filling the vehicle with gasoline it will spill over and out. the vehicle was taken to the dealer who stated there is no fix for this failure. the manufacturer was contacted and a claim was file. the failure mileage was 27,000.-mw
12/17/201035497
 When filling the gas tank using the auto shutoff on the pump handle, the gas tank shoots gas out all over just after the auto shutoff clicks off. it has sprayed on me and the ground and the vehical.
12/16/201034788
 Every time i refuel my 2007 jeep wrangler, fuel spills. when the tank is full the gas pump kicks off and fuel gushes from fuel filler... it does not matter where i get fuel or how much fuel is in tank when i begin filling... it always spills...
12/17/201035497
 When filling the gas tank using the auto shutoff on the pump handle, the gas tank shoots gas out all over just after the auto shutoff clicks off. it has sprayed on me and the ground and the vehical.
12/16/201034788
 Every time i refuel my 2007 jeep wrangler, fuel spills. when the tank is full the gas pump kicks off and fuel gushes from fuel filler... it does not matter where i get fuel or how much fuel is in tank when i begin filling... it always spills...
12/04/201045000
 When fueling up the vehicle, when the auto shut off turns the pump off the fuel overflows out of the fuel port. even when slow pumping it still overflows.
11/30/201033600
 My 2007 jeep wrangler has all of a sudden started spewing fuel from the gas tank each time i fill up. i don't try to top off the gas tank. basically, the pump clicks, and then when i remove the nozzle from the tank, fuel starts spewing all over. it got on my hands and shoes, and all over the side of my jeep. this now seems to happen every time i fill up.
12/04/201045000
 When fueling up the vehicle, when the auto shut off turns the pump off the fuel overflows out of the fuel port. even when slow pumping it still overflows.
11/30/201033600
 My 2007 jeep wrangler has all of a sudden started spewing fuel from the gas tank each time i fill up. i don't try to top off the gas tank. basically, the pump clicks, and then when i remove the nozzle from the tank, fuel starts spewing all over. it got on my hands and shoes, and all over the side of my jeep. this now seems to happen every time i fill up.
12/04/201045000
 When fueling up the vehicle, when the auto shut off turns the pump off the fuel overflows out of the fuel port. even when slow pumping it still overflows.
11/30/201033600
 My 2007 jeep wrangler has all of a sudden started spewing fuel from the gas tank each time i fill up. i don't try to top off the gas tank. basically, the pump clicks, and then when i remove the nozzle from the tank, fuel starts spewing all over. it got on my hands and shoes, and all over the side of my jeep. this now seems to happen every time i fill up.
10/01/200811000
 Starting in late 2008, when refueling my 2007 jeep wrangler jk, the automatic shutoff at gas pumps doesn't shut off when my tank is full causing fuel to overflow and occasional splash out of the fuel filler neck of the vehicle. if i do not shut off the gas pump manually before it is full, this has occurred every time i put fuel in the vehicle. this issue has resulted in minor to significant fuel spillage including soaking my hands and feet in fuel at various times. other than monitoring and stopping the pump during refueling, i have taken no action to resolve the issue.
11/27/201045200
 When filling up my fuel tank on my 2007 jeep wrangler at any gas station an alarming amount of gasoline gushes out of the fuel filler neck after the fuel pump has automatically shut off. i do not recalling this happening when the vehicle was new, it's only recently that this has occurred. probably started around 8 months ago. it does not appear to be gas pump specific, i've tried approximately 20 different gas stations over the amount of time that this has been occurring. fuel spills out onto the vehicle, the ground and also myself. sometimes to the point that i've had to change clothes due to fuel splashing onto my garments.
11/30/201033600
 My 2007 jeep wrangler has all of a sudden started spewing fuel from the gas tank each time i fill up. i don't try to top off the gas tank. basically, the pump clicks, and then when i remove the nozzle from the tank, fuel starts spewing all over. it got on my hands and shoes, and all over the side of my jeep. this now seems to happen every time i fill up.
10/01/200811000
 Starting in late 2008, when refueling my 2007 jeep wrangler jk, the automatic shutoff at gas pumps doesn't shut off when my tank is full causing fuel to overflow and occasional splash out of the fuel filler neck of the vehicle. if i do not shut off the gas pump manually before it is full, this has occurred every time i put fuel in the vehicle. this issue has resulted in minor to significant fuel spillage including soaking my hands and feet in fuel at various times. other than monitoring and stopping the pump during refueling, i have taken no action to resolve the issue.
11/27/201045200
 When filling up my fuel tank on my 2007 jeep wrangler at any gas station an alarming amount of gasoline gushes out of the fuel filler neck after the fuel pump has automatically shut off. i do not recalling this happening when the vehicle was new, it's only recently that this has occurred. probably started around 8 months ago. it does not appear to be gas pump specific, i've tried approximately 20 different gas stations over the amount of time that this has been occurring. fuel spills out onto the vehicle, the ground and also myself. sometimes to the point that i've had to change clothes due to fuel splashing onto my garments.
10/01/200811000
 Starting in late 2008, when refueling my 2007 jeep wrangler jk, the automatic shutoff at gas pumps doesn't shut off when my tank is full causing fuel to overflow and occasional splash out of the fuel filler neck of the vehicle. if i do not shut off the gas pump manually before it is full, this has occurred every time i put fuel in the vehicle. this issue has resulted in minor to significant fuel spillage including soaking my hands and feet in fuel at various times. other than monitoring and stopping the pump during refueling, i have taken no action to resolve the issue.
11/27/201045200
 When filling up my fuel tank on my 2007 jeep wrangler at any gas station an alarming amount of gasoline gushes out of the fuel filler neck after the fuel pump has automatically shut off. i do not recalling this happening when the vehicle was new, it's only recently that this has occurred. probably started around 8 months ago. it does not appear to be gas pump specific, i've tried approximately 20 different gas stations over the amount of time that this has been occurring. fuel spills out onto the vehicle, the ground and also myself. sometimes to the point that i've had to change clothes due to fuel splashing onto my garments.
10/01/200811000
 Starting in late 2008, when refueling my 2007 jeep wrangler jk, the automatic shutoff at gas pumps doesn't shut off when my tank is full causing fuel to overflow and occasional splash out of the fuel filler neck of the vehicle. if i do not shut off the gas pump manually before it is full, this has occurred every time i put fuel in the vehicle. this issue has resulted in minor to significant fuel spillage including soaking my hands and feet in fuel at various times. other than monitoring and stopping the pump during refueling, i have taken no action to resolve the issue.
11/27/201045200
 When filling up my fuel tank on my 2007 jeep wrangler at any gas station an alarming amount of gasoline gushes out of the fuel filler neck after the fuel pump has automatically shut off. i do not recalling this happening when the vehicle was new, it's only recently that this has occurred. probably started around 8 months ago. it does not appear to be gas pump specific, i've tried approximately 20 different gas stations over the amount of time that this has been occurring. fuel spills out onto the vehicle, the ground and also myself. sometimes to the point that i've had to change clothes due to fuel splashing onto my garments.
01/09/200940000
 Everytime i fill the tank it spits back gas. no matter how slow or what station i go to. it was fine untill about 40k miles. now it is a real safty issue.
08/01/201043000
 When filling gas on my 2007 jeep wrangler. the gas nozzle will click off at full. and then apox 2-3 seconds latter aprox. one quart of gas will spill out of the filler neck down the side of the jeep onto the ground. this has been an on going problem for the last 3 months.
11/21/201038000
 2007 jeep wrangler 2-door 1) nearly every time i fill up my gas tank, which holds 15 - 16 gallons per my estimate and fill-up history, it overflows (i have had the car for 13 months, fill up twice a week; 56 weeks x 2 = 112 * 0.90 = 100 times this has happened). the overflow is not because the tank is over-filled, as it is possible, in my experience, to add an additional gallon after initial overflow. 2) the mechanism that shuts off the pump handle automatically when the fuel tank is becoming full does not stop the pump. this results in excess fuel ending up all over the side of my car, the attached gas cap, and one's shoes and person if one is not expecting the fuel to spit back out. 3) nothing has been done as of yet to correct the failure.
01/09/200940000
 Everytime i fill the tank it spits back gas. no matter how slow or what station i go to. it was fine untill about 40k miles. now it is a real safty issue.
08/01/201043000
 When filling gas on my 2007 jeep wrangler. the gas nozzle will click off at full. and then apox 2-3 seconds latter aprox. one quart of gas will spill out of the filler neck down the side of the jeep onto the ground. this has been an on going problem for the last 3 months.
11/21/201038000
 2007 jeep wrangler 2-door 1) nearly every time i fill up my gas tank, which holds 15 - 16 gallons per my estimate and fill-up history, it overflows (i have had the car for 13 months, fill up twice a week; 56 weeks x 2 = 112 * 0.90 = 100 times this has happened). the overflow is not because the tank is over-filled, as it is possible, in my experience, to add an additional gallon after initial overflow. 2) the mechanism that shuts off the pump handle automatically when the fuel tank is becoming full does not stop the pump. this results in excess fuel ending up all over the side of my car, the attached gas cap, and one's shoes and person if one is not expecting the fuel to spit back out. 3) nothing has been done as of yet to correct the failure.
08/01/201043000
 When filling gas on my 2007 jeep wrangler. the gas nozzle will click off at full. and then apox 2-3 seconds latter aprox. one quart of gas will spill out of the filler neck down the side of the jeep onto the ground. this has been an on going problem for the last 3 months.
11/21/201038000
 2007 jeep wrangler 2-door 1) nearly every time i fill up my gas tank, which holds 15 - 16 gallons per my estimate and fill-up history, it overflows (i have had the car for 13 months, fill up twice a week; 56 weeks x 2 = 112 * 0.90 = 100 times this has happened). the overflow is not because the tank is over-filled, as it is possible, in my experience, to add an additional gallon after initial overflow. 2) the mechanism that shuts off the pump handle automatically when the fuel tank is becoming full does not stop the pump. this results in excess fuel ending up all over the side of my car, the attached gas cap, and one's shoes and person if one is not expecting the fuel to spit back out. 3) nothing has been done as of yet to correct the failure.
11/09/201020000
 Fuel spills out of the filler port during fueling. it happens when filling the tank to full. when the gas pump automatically shuts or clicks off, fuel spills down the side of the vehicle or shoots from the fill or nozzle. this covers the side of the vehicle, the ground, and sometimes the person fuleing if standing nearby. issue has occured at many different pumps. issue began at approximatly 20,000 miles (reached in approx 2008) and has continued ever since.
10/31/20102000
 While filling fuel tank, fuel spills out of filler neck after fuel pump shuts off.
10/15/200940169
 Gas overflows tank @ almost every fill-up
01/21/201019000
 Gas tank overflow during fill up. this occurs almost every time i fill to full. i have stopped filling the tank to full to help stop this issue.
10/31/20102000
 While filling fuel tank, fuel spills out of filler neck after fuel pump shuts off.
10/15/200940169
 Gas overflows tank @ almost every fill-up
01/21/201019000
 Gas tank overflow during fill up. this occurs almost every time i fill to full. i have stopped filling the tank to full to help stop this issue.
10/31/20102000
 While filling fuel tank, fuel spills out of filler neck after fuel pump shuts off.
10/15/200940169
 Gas overflows tank @ almost every fill-up
01/21/201019000
 Gas tank overflow during fill up. this occurs almost every time i fill to full. i have stopped filling the tank to full to help stop this issue.
10/15/200940169
 Gas overflows tank @ almost every fill-up
01/21/201019000
 Gas tank overflow during fill up. this occurs almost every time i fill to full. i have stopped filling the tank to full to help stop this issue.
10/15/200940169
 Gas overflows tank @ almost every fill-up
01/21/201019000
 Gas tank overflow during fill up. this occurs almost every time i fill to full. i have stopped filling the tank to full to help stop this issue.
04/15/200923000
 Everytime i refuel, gasoline will overflow and spill onto the ground. the pump will not stop the flow of fuel in time to prevent spillage. i've tried to slow the flow as it nears a full tank, but the problem has persisted. the only thing that will stop the fuel from overflowing is simply not filling the tank completely full. i have to stop at about 7/8ths.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
04/15/200923000
 Everytime i refuel, gasoline will overflow and spill onto the ground. the pump will not stop the flow of fuel in time to prevent spillage. i've tried to slow the flow as it nears a full tank, but the problem has persisted. the only thing that will stop the fuel from overflowing is simply not filling the tank completely full. i have to stop at about 7/8ths.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
10/16/201068300
 1. filling the tank with fuel. 2. wait for the pump to click off on it's own. every time i let the pump auto shutoff, it will spill 6-20 oz of fuel out the spout and onto the ground. 3. have not corrected the problem.
04/15/200923000
 Everytime i refuel, gasoline will overflow and spill onto the ground. the pump will not stop the flow of fuel in time to prevent spillage. i've tried to slow the flow as it nears a full tank, but the problem has persisted. the only thing that will stop the fuel from overflowing is simply not filling the tank completely full. i have to stop at about 7/8ths.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
10/16/201068300
 1. filling the tank with fuel. 2. wait for the pump to click off on it's own. every time i let the pump auto shutoff, it will spill 6-20 oz of fuel out the spout and onto the ground. 3. have not corrected the problem.
04/15/200923000
 Everytime i refuel, gasoline will overflow and spill onto the ground. the pump will not stop the flow of fuel in time to prevent spillage. i've tried to slow the flow as it nears a full tank, but the problem has persisted. the only thing that will stop the fuel from overflowing is simply not filling the tank completely full. i have to stop at about 7/8ths.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
10/16/201068300
 1. filling the tank with fuel. 2. wait for the pump to click off on it's own. every time i let the pump auto shutoff, it will spill 6-20 oz of fuel out the spout and onto the ground. 3. have not corrected the problem.
04/15/200923000
 Everytime i refuel, gasoline will overflow and spill onto the ground. the pump will not stop the flow of fuel in time to prevent spillage. i've tried to slow the flow as it nears a full tank, but the problem has persisted. the only thing that will stop the fuel from overflowing is simply not filling the tank completely full. i have to stop at about 7/8ths.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
10/16/201068300
 1. filling the tank with fuel. 2. wait for the pump to click off on it's own. every time i let the pump auto shutoff, it will spill 6-20 oz of fuel out the spout and onto the ground. 3. have not corrected the problem.
07/05/2010
 Fuel spills out arfter the nozzle kicks offoff
10/21/201049000
 When you fill up, after the pump clicks off, lots of gas pours back out of the tank. it could run down near the muffler and ignite. not to mention the environmental effects of gasoline on and in the ground.
10/16/201068300
 1. filling the tank with fuel. 2. wait for the pump to click off on it's own. every time i let the pump auto shutoff, it will spill 6-20 oz of fuel out the spout and onto the ground. 3. have not corrected the problem.
10/08/2010
 2007 jeep wrangler gas filler neck. when topping off the tank with gas about 1-2 cups of gas comes out of the filler neck. using the same pump on other cars it shuts off fine. even when filling at a slow rate this happens.
09/06/201040100
 I bought a used 2007 jeep wrangler 2 door with 34,000 miles on it. i had fiilled the gas tank several times only to have it backflow on to me and the side of the jeep making a real mess and creating a major safety hazard. of course i blamed the service station pump for not stopping in time but this happens on every fill up when trying to fill the tank full. this problem is a dangerous problem and should be corrected before someone gets injured. my warranty is up 40,000 miles and i am told it needs a new gas tank to repair which of course is several hundred dollars of repair cost. this faulty part demands a safety recall be implemented or maybe a possible class action lawsuit before someone is injured.
09/24/201061700
 My 2007 jeep wrangler x has had a recurring problem with fuel spilling from the fuel tank nozzle during fill-ups. when the tank is full and the gas pump shuts off, fuel gushed from the filler tube and down the side of the vehicle and onto the ground. the fender and bumper near the fill nozzle are now discolored due to the situation. i have brought the vehicle to a dealer to complain about this, and they replaced the gas tank. this did not solve the problem. every fill up, i have the same problem. i am concerned that at some point, the fuel will hit a hot area and ignite. i see that a number of complaints on this very issue have been filed (pe10032). please address it!!!!
09/06/201040100
 I bought a used 2007 jeep wrangler 2 door with 34,000 miles on it. i had fiilled the gas tank several times only to have it backflow on to me and the side of the jeep making a real mess and creating a major safety hazard. of course i blamed the service station pump for not stopping in time but this happens on every fill up when trying to fill the tank full. this problem is a dangerous problem and should be corrected before someone gets injured. my warranty is up 40,000 miles and i am told it needs a new gas tank to repair which of course is several hundred dollars of repair cost. this faulty part demands a safety recall be implemented or maybe a possible class action lawsuit before someone is injured.
09/24/201061700
 My 2007 jeep wrangler x has had a recurring problem with fuel spilling from the fuel tank nozzle during fill-ups. when the tank is full and the gas pump shuts off, fuel gushed from the filler tube and down the side of the vehicle and onto the ground. the fender and bumper near the fill nozzle are now discolored due to the situation. i have brought the vehicle to a dealer to complain about this, and they replaced the gas tank. this did not solve the problem. every fill up, i have the same problem. i am concerned that at some point, the fuel will hit a hot area and ignite. i see that a number of complaints on this very issue have been filed (pe10032). please address it!!!!
09/22/201022000
 Gas overflows and spills out of the gas filler tube every time i fill up on my 2007 jeer wrangler x.
09/06/201040100
 I bought a used 2007 jeep wrangler 2 door with 34,000 miles on it. i had fiilled the gas tank several times only to have it backflow on to me and the side of the jeep making a real mess and creating a major safety hazard. of course i blamed the service station pump for not stopping in time but this happens on every fill up when trying to fill the tank full. this problem is a dangerous problem and should be corrected before someone gets injured. my warranty is up 40,000 miles and i am told it needs a new gas tank to repair which of course is several hundred dollars of repair cost. this faulty part demands a safety recall be implemented or maybe a possible class action lawsuit before someone is injured.
09/24/201061700
 My 2007 jeep wrangler x has had a recurring problem with fuel spilling from the fuel tank nozzle during fill-ups. when the tank is full and the gas pump shuts off, fuel gushed from the filler tube and down the side of the vehicle and onto the ground. the fender and bumper near the fill nozzle are now discolored due to the situation. i have brought the vehicle to a dealer to complain about this, and they replaced the gas tank. this did not solve the problem. every fill up, i have the same problem. i am concerned that at some point, the fuel will hit a hot area and ignite. i see that a number of complaints on this very issue have been filed (pe10032). please address it!!!!
09/22/201022000
 Gas overflows and spills out of the gas filler tube every time i fill up on my 2007 jeer wrangler x.
09/24/201061700
 My 2007 jeep wrangler x has had a recurring problem with fuel spilling from the fuel tank nozzle during fill-ups. when the tank is full and the gas pump shuts off, fuel gushed from the filler tube and down the side of the vehicle and onto the ground. the fender and bumper near the fill nozzle are now discolored due to the situation. i have brought the vehicle to a dealer to complain about this, and they replaced the gas tank. this did not solve the problem. every fill up, i have the same problem. i am concerned that at some point, the fuel will hit a hot area and ignite. i see that a number of complaints on this very issue have been filed (pe10032). please address it!!!!
09/22/201022000
 Gas overflows and spills out of the gas filler tube every time i fill up on my 2007 jeer wrangler x.
09/21/201028000
 2007 jeep wrangler every time i fill the tank with gas it will overflow and spill out. it appears to be anywhere from a few ounces to maybe as much as a half a gallon. i now turn the key to accesory position whlie pumping gas so that i can watch the gauge and stop pumping before it reaches full.
09/22/201022000
 Gas overflows and spills out of the gas filler tube every time i fill up on my 2007 jeer wrangler x.
09/21/201028000
 2007 jeep wrangler every time i fill the tank with gas it will overflow and spill out. it appears to be anywhere from a few ounces to maybe as much as a half a gallon. i now turn the key to accesory position whlie pumping gas so that i can watch the gauge and stop pumping before it reaches full.
09/13/201021500
 I recently purchased a 2007 jeep wrangler 4x4 from a dealer. the past handful of times we have filled the vehicle with gas, gas has sprayed out all over the car, ground and myself. i am not topping off the vehicle - i am filling up to the point of when the pump automatically stops. this is not safe and i have seen numerous complaints of this same type. something needs to be done to correct this.
08/31/201039665
 Jeep wrangler 2007 vehicle consistently spills gas when refueling
08/27/2010
 Gas tank over flow when filling up 2007 jeep jk wrangler rubicon. the pump doesnt even have to stop for it to happen. i can fill it up with 10 gallons of gas, stop the pump and as soon as you pull the pump out of the neck gas sprays out. the option below to enter a date only allows for one date. this happens every time i fill up the jeep.
08/04/201051000
 Gas gushes out of the filler after the pump shuts off. tried different angles and depths it is inserted but it happens when it shuts off and makes a mess on the vehicle and the ground. this happens every time i fill up the tank.
10/01/200940000
 When i fuel the jeep it spits out gas. it only started doing this after 40k miles. it now does it every time!
04/02/201034000
 When filling up the gas tank, no matter how slow i do it, there is an overflow and in a couple cases a forcible splash. it was so forcible this weekend that my pants and shoes were soaked. i have read on a jeep forum that this is happening to a number of owners of the jeep wranglers. there are even a number of youtube videos documenting the situation. at the very least this is an environmental issue but it could escalate into something far more dangerous because of the amount of gas that overflows.
03/07/201038000
 The gas tank overflls every time i pump gas into it at the gas station.
10/12/200920000
 Fuel spills out when pumping gas at any station.
03/01/2010360001
 Fuel overflowing when filling tank in a 2007 jeep wrangler, design does not shut off fuel fill when tank is full resulting in backsplashing onto vehicle, ground and most importantly the person filling the fuel tank. this could be deadly! *tr
03/09/2010393831
 After 25,000 miles, my jeep wrangler's gas tank overflows every time i fill up. the event occurs every time i fill up with gas. gas blows forcibly up out of the hole where the gas nozzle from the pump goes into the vehicle. the gas goes all over my vehicle and everything/everyone in the immediate vicinity. chrysler refuses to admit there is a problem. *tr
03/07/2010530001
 While pumping gas, when it is nearly full the gas pump will spit the gas out at you. more info here: http://www.jeepforum.com/forum/f9/have-fuel-spill-problems-like-many-us-submit-complaint-force-recall-974337/. *tr
02/27/2010300001
 2007 jeep wrangler gas overflow when filling the gas tank. quite a substantial amount of gas overflows when the gas tank is filled. even when i try to slowly fill the tank it still overflows. this is a serious safety issue and is common among the jk model jeep. *tr
01/03/2010200001
 2007 jeep wrangler- when filling up for gas the tank overflows before the pump is switched off. i have tried multiple gas stations in multiple states, still overflows every time. *tr
10/25/200730001
 Fuel overflows whenever pump is left on fill. this occurs every time i fill the vehicle with gasoline. for the last 3 years i have been told by the dealer that they can't find any problem. i now just add a few dollars worth of gas at a time so i know it won't hit the shut off point & overflow. *tr
10/01/2009280001
 When trying to do a complete fill-up of fuel, the pump will shut off as it should, and then a moderate amount of fuel will burp out of the opening. it spills down the side of the vehicle and on to the ground. unsafe, unpleasant, and environmentally irresponsible. this is a recurring problem. the jeep had no issues for over two years, since fall of 2009 it has been occurring, will do it everytime i do a full fill-up, no matter what gas station i use. i no longer do full fill-ups as a result, which makes it difficult to properly track fuel economy. *tr
01/06/2010310001
 The gas inside of my gas tank shoots out after the pump automatically shuts off when the tank is full. *cn
01/28/2010300001
 Gas overflow at every fill up on my 2007 jeep wrangler tw*
01/25/201020000
 2007 jeep wrangler jk, 2 door, sahara model when filling the gas tank, there is gas overflow back outside the tank, splashes over the nozzle handle, down the side of the jeep and pools on the pavement. this happens regardless of station, holding the gas spigot by hand or with various automatic settings.*cw
01/02/2010172501
 Vehicle failed to shut off fuel pump during refueling operation when tank became full, allowing fuel to overflow onto the side of the jeep, and onto the ground. *tr
12/01/2009530001
 Gas gushes out of filler tube when done filling tank. *tr
12/01/2009350001
 After the fuel pump at a gasoline station shuts off indicating my gas tank is full, gasoline spews back out of the tank through the opening where the gas pump nozzle is inserted once the nozzle is pulled out after fueling. the amount of fuel spilled is significant. i believe it could cause damage to my paint and plastic pieces on my vehicle and is also a fire and environmental hazard. this is not a result of continuing to pump fuel while removing the nozzle. the flow of fuel through the nozzle has stopped but pressure from inside the tank forces fuel out when the gas nozzle is removed. this has occurred on multiple occasions at multiple gas stations and did not occur earlier in the vehicle's history and does not occur when i am fueling other vehicles. *tr
12/27/2009273001
 In the past month the vehicle has begun to spit up gasoline when filling up at the service station. whenever i fill the tank to full and the fill nozzle automatically cuts off, a good amount of gasoline comes up through the filler neck spilling out onto the ground. various jeep owners have encountered the same issue and have posted it on the net those that have sought to have the problem remedied have usually had a new tank installed and/or some sort of emissions valve replaced. my vehicle is out of warranty and my dealer will not even look at it without me paying a 'diagnosis' fee. furthermore i cannot afford to pay for a new gasoline tank on a vehicle that's only 3 years old and has 27,300 miles! i have resorted to only filling my tank 3/4 of the way. i feel this presents various safety issues since there is a significant amount of gasoline spillage presenting a dangerous situation at the pump. *tr
12/01/2009200001
 When fueling my jeep wrangler the pump shuts off then sprays gasoline. we have two similar jeeps (2007, 2010) and they both do it. *tr
12/21/2009220001
 2007 jeep wrangler x overflows at the gas pump even after the pump 'clicks'. this is the fourth time this has happened. pump should shut off at around 18 gallons when the click occurs but for some reason the click sounds goes off and gas begins to overflow out of the jeep. gas spills all over the jeep, the ground, and me. nothing has been done to fix the failure as i am unsure to what the issue is/what the dealer will do. planning on taking it in to the dealer after christmas. *tr
01/01/2009150001
 Gas tank overflows and shoots gas out on the jeep and myself everytime i fill up. *tr
11/01/20091
 When filling the gas tank on my 2007 jeep wrangler, gas will overflow onto the jeep, the ground and myself. happens everytime i try to fill tank. this is both a safety hazard and an environmental hazard. *tr
12/14/2009155001
 When i go to fill up my gas tank. this is without even toping it off myself. this happens when you fill up till it clicks. and no further. i fill my tank with fuel and it overflows causing fuel to spill all over the vehicle and the ground at the gas station. this happens every time i fill my tank. *tr
11/27/2009210001
 When i use auto fill on my vehicle, it overflows as it stops pumping. this has been happening every time i fill up (last couple times). *tr
11/22/2009300001
 I have a 2007 jeep wrangler x and it seems every other time i fill the gas tank the tank will over fill and fuel will spray out of the filler neck. it is not just a slow over flow it is literally a spray of gasoline coming out. i talked to the local dealer and they said that they have heard this from many other owners but do not see anything wrong with my jeep. i have tried many different gas stations and i get the same result everywhere i go. so it would seem that this is a problem with the jeep and not the pump. *tr
11/22/2009350001
 Every time i fill my 2007 jeep wrangler with gas at a gas station, the automatic shutoff triggers too late and gas spews out of the fill tube. usually enough spills to leave a 1-2 ft^2 puddle on the ground. i've tried many different gas stations all with exactly the same result.*tr
11/14/2009100701
 Fuel overfills from filler neck when filling at gas station. i've tried several different things to get it to not overfill, but it doesn't. and now i've read that many people are having the same issue. *tr
11/13/2009293181
 Fuel blows out of tank after fuel pump shuts off. i've tried different gas stations and pumps but it does it every time. *tr
10/25/2009238001
 Fuel sprays from the filler neck while refueling. problem has occurred for the past six months. occurred at every station i have attempted to refuel. *tr
10/23/2009325951
 Fuel spills out of gas tank nozzle when filling up. *tr
07/31/2007200207/13/2007
 300 miles on my new 2007 jeep wrangler. it will not idle correctly. incorrect gas-cap analysis. in for service 2 times for same problem. jeep needs another recall on this piece of junk. *tr
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
02/05/200818000312/03/2006
 My car was parked on an incline of about 20 degrees and i had 1/4 tank of gas. when i went to start the car it wouldn't turn on. all the lights on the dash came on, but the engine wouldn't turn over. my radio and lights worked fine. this is the 3rd time that this has happened in a year and 2 months. the two prior times, i coasted down to a flat area and the car started. tonight it didn't. i think there is a problem with the fuel delivery system or fuel pump. the three times that this has happened i have had 1/4 of a tank of gas or less. *tr
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP
03/16/201030000
 Tl*the contact owns a 2007 jeep wrangler. the contact stated that whenever gasoline was added to the fuel tank at least six ounces of it would leak out of the tank. the failure was not diagnosed by the dealer. the failure mileage was 30,000 and the current mileage was 33,000.
09/10/200746804
 Tl*the contact owns a 2007 jeep wrangler. while adding fuel to the tank and it reached the capacity, the fuel began to spill out of the tank splashing onto the contact the ground. the contact has called the manufacturer regarding the gas tank and the manufacturer stated they weren't aware of any related failures. the contact has made an appointment to have a diagnostic test done on the vehicle. the contact is concerned that the failure could cause a fire to occur. the failure mileage was 46,804.
FUEL SYSTEM, OTHER
02/19/2011
 I own a 2007 jeep wranlger that was manufactured in february of 2007. every time i fill up the gas tank the fuel overflows and spills out of the nozzle, creating a hazardous puddle of flammable gasoline on the fender, the tire, the ground, and the person fueling it(me).
12/10/2010
 2007 jeep wrangler just before fuel nozzle automatically shuts off while refueling vehicle, gas flows out of the filler neck and down the side of the vehicle on to the ground. happens every time i refuel, at any gas station doesn't matter which supplier.
11/26/201024786
 Gas overflow when filling tank, spills on ground contaminate or safety cancer or fire, epa concerns of every new wrangler spills that is gallons of gas wasted or contiminating across the usa epa get involved please , every time filling up jeep wrangler 2007!!!! it spills!!!
08/01/201043000
 When filling gas on my 2007 jeep wrangler. the gas nozzle will click off at full. and then apox 2-3 seconds latter aprox. one quart of gas will spill out of the filler neck down the side of the jeep onto the ground. this has been an on going problem for the last 3 months.
02/09/2010291201
 I have a 2007 jeep wrangler. everytime i fill it up with gas the automatic cutoff fails and gas overflows and spills down the side of the jeep and onto the ground. it doesn't what gas station or where, it happens everytime. *tr
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - FILLING/CHARGING
01/30/200738901/24/2007
 My fuel tank overflows when filling tank. every time. every filling station we have tried. *tr

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.