Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, GASOLINE - STORAGE | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, OTHER | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, OTHER - STORAGE | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. | ||||||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - FILLING/CHARGING | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | 02/16/2011 | Fuel Spill During Refueling | ||
Odi found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, odi suspects that the nhtsa safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.a safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.see attached report for additional information.in addition, chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 jeep wrangler vehicles built from march 1, 2007 to march 31, 2008.chrysler will notify all affected vehicle owners of this action.consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.the vehicle build date can be found on the certification label located on the driver door or door jamb. | ||||||
PE10032 | CHRYSLER GROUP LLC | 08/23/2010 | Fuel Spill During Refueling | |||
Odi has received 217 consumer complaints alleging that fuel spills out of the filler port during the refueling process.this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off.consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, DIESEL | |||
04/30/2010 | |||
My gas tank over flows and gas squirts out as i'm filling my gas tank. this happens every time i get gas. as soon as it nozzle chicks, gas squirts out first and then when i take the nozzle out, gas gushes out all down the jeep and onto the ground. gas is extremely expensive for me to lose gas each time. i am a commuter and gas up often. also, what is the gas spilling on my jeep doing to the paint? | |||
FUEL SYSTEM, GASOLINE | |||
01/01/2010 | 12000 | ||
This problem started in 2010 every now and then, but is now happening each and every time i fill up. when filling the jeep with gas, the gas will overflow and splash out onto the person filling, the side of the jeep, the bumper, and all over the ground. creating a safety, fire, and health hazard. | |||
02/23/2012 | 56359 | ||
3rd fill up in 3 weeks, once again was filling up and gas poured all over side of my jeep and the ground when filling up. spilled approximately 3-4 quarts of fuel on the ground. | |||
04/09/2010 | 81000 | ||
Every time i fill the jeep up, it overflows either on to the vehicle, myself, or the ground. it is a very serious fire hazard that i know is a common problem. | |||
11/17/2010 | |||
I have a 2007 jeep wrangler and while filling gas tank a (back spalsh) of fuel comes out. to me and everyone i have seen about this is a concern to the enviroment & the person doing the filling of the tank. vey unsafe. | |||
10/06/2011 | 79000 | ||
Steering/suspension. we have had issues with excessive wobbeling and swaying of our jeep. believe this to be premature failure of the tie rods and stabelizing system. this has been very dangerous. fuel system: gas will shoot out of the tank spilling fuel on the outside of the vehicle when fueling. | |||
07/11/2011 | 109349 | ||
Every time i fill my tank up the pump nozzle does not shut of automatically and i get what seems like a half a gallon of fuel on the ground or on the side of my jeep. i've read many complaints about jeep owners having the same problem and its due to a faulty esim switch or something wrong with the whole gas tank on jeeps. | |||
06/02/2011 | 20000 | ||
Jeep wrangler jk spills fuel out the filler neck during refueling. this is caused by a faulty back flow preventer in the gas tank. chrysler has acknowledged a problem and offered an extended warranty to replace the fuel tanks of vehicles built during specified build dates. however this does not cover all the vehicles affected with this problem. it is a known issue and chrysler refuses to take any action. every fill up creates a potentially dangerous situation and spills hazardous material into the environment. | |||
01/26/2011 | 60000 | ||
2007 jeep wrangler jk - gas tank overflows when filling up. this is a very common problem with these jeeps creating a safety hazard when the gas spills out on the person filling the tank, on the side of the jeep and on the ground. it happens each and every time you fill up. | |||
06/02/2011 | 20000 | ||
Jeep wrangler jk spills fuel out the filler neck during refueling. this is caused by a faulty back flow preventer in the gas tank. chrysler has acknowledged a problem and offered an extended warranty to replace the fuel tanks of vehicles built during specified build dates. however this does not cover all the vehicles affected with this problem. it is a known issue and chrysler refuses to take any action. every fill up creates a potentially dangerous situation and spills hazardous material into the environment. | |||
01/26/2011 | 60000 | ||
2007 jeep wrangler jk - gas tank overflows when filling up. this is a very common problem with these jeeps creating a safety hazard when the gas spills out on the person filling the tank, on the side of the jeep and on the ground. it happens each and every time you fill up. | |||
11/11/2009 | 12000 | ||
When fueling the vehicle gas will shoot out of the fuel hole when the tank nears full. pouring gas all over the vehicle and on the ground and you, if your standing near the vehicle fueling area. the pump handle will click off but that's to late when you hear the handle click off you better jump back unless you want gas on you. | |||
01/01/2010 | 54000 | ||
Tl* the contact owns a 2007 jeep wrangler unlimited sahara. the contact stated that when refueling the vehicle, the fuel would overflows once the fueling has stopped and the fuel tank was full. the vehicle was taken to the dealer where the technicians stated that the fuel tank needed to be replaced. the manufacturer was contacted and stated they would cover fifty percent of the repair costs. the vehicle was not repaired. the approximate failure mileage was 54,000. | |||
01/01/2010 | 54000 | ||
Tl- the contact owns a 2007 jeep wrangler unlimited sahara. while fueling the vehicle the fuel over flows once the fueling has stopped and the fuel tank is full. the vehicle was taken to the dealer where the technicians stated there was not a recall. the technicians stated the gas tank needed to be replaced. the manufacturer was contacted and stated they would cover half of the cost of repairs. the vehicle was not repaired. the approximate failure mileage was 54,000. ds | |||
01/12/2011 | |||
Vehicle stalls out in traffic, despite battery being fully charged. with a restart, the battery symbol remains illuminated, and eventually the vehicle will stall out again. occurred in heavy traffic creating traffic hazard. remains a recurring problem that is only remedied by completely shutting off engine and waiting several minutes, then restarting it and checking to confirm that the battery symbol is no longer illuminated. sometimes a battery jump-start is required. one dangerous alternative is to turn off the ignition while vehicle is rolling, restarting the vehicle, but obvious hazards of locked steering wheel, loss of control and possible crashes would result. | |||
02/01/2011 | 35000 | ||
07 jeep wrangler: fuel spills out of the filler neck when the tank is filled. the fuel spits back out before the fuel pump auto shut-off clicks in. | |||
02/14/2011 | 40000 | ||
2007 jeep wrangler jk sahara unlimited, issue started around 40,000 miles. current mileage is 63,000 miles. fuel tank overflows when filled at the pump. no matter what gas station i use, no matter what pump i use, the gas tank overflows on fill up. the handle for the pump has clicked off and stopped fueling, but gas spews out from the gas fill on my jeep and ground and a couple times even onto my clothing. i have had to go back home and change clothes because so much gas spewed onto my clothing. this is the second time i have filed for this issue. chrysler issued a tsb 14-001-11 on february 11, 2011 for this but is only build dates of march 07- 08. my build date is in 2006. granted, i have not incurred any damage, this is a safety hazard to myself and some gas stations have even had to shut down to clean up the spill. this is an ongoing issue for numerous jeeps and needs to include many different build dates outside of the recently issued tsb. thank you for your time. | |||
06/15/2010 | 48000 | ||
When re-fueling tank, a large amount of fuel overflows from filler neck as tank is nearing full. this problem occurs every time fuel pump is not manually stopped prior to tank reaching capacity. no fires or injuries have occured, and nothing to date has been done to correct the problem. | |||
06/01/2009 | |||
Gas overflows when refuling and spills on floor and person refuling. | |||
01/23/2011 | 29700 | ||
2007 jeep wrangler unlimited fuel spills out when refueling. every time i refuel, no matter if i use the auto pump or not, it will run out on the side of the vehicle. | |||
12/16/2010 | 39500 | ||
When refueling the gas will spray out of the port when it is reaching full before the pump will kick off. i have gotten gas on my shoes and pants several times. it has even sprayed out so bad before that gas got on another person on the other side of the pump. it is almost impossible to fill up without spilling everywhere. | |||
06/01/2009 | |||
Gas overflows when refuling and spills on floor and person refuling. | |||
01/23/2011 | 29700 | ||
2007 jeep wrangler unlimited fuel spills out when refueling. every time i refuel, no matter if i use the auto pump or not, it will run out on the side of the vehicle. | |||
12/16/2010 | 39500 | ||
When refueling the gas will spray out of the port when it is reaching full before the pump will kick off. i have gotten gas on my shoes and pants several times. it has even sprayed out so bad before that gas got on another person on the other side of the pump. it is almost impossible to fill up without spilling everywhere. | |||
01/23/2011 | 29700 | ||
2007 jeep wrangler unlimited fuel spills out when refueling. every time i refuel, no matter if i use the auto pump or not, it will run out on the side of the vehicle. | |||
12/16/2010 | 39500 | ||
When refueling the gas will spray out of the port when it is reaching full before the pump will kick off. i have gotten gas on my shoes and pants several times. it has even sprayed out so bad before that gas got on another person on the other side of the pump. it is almost impossible to fill up without spilling everywhere. | |||
01/23/2011 | 29700 | ||
2007 jeep wrangler unlimited fuel spills out when refueling. every time i refuel, no matter if i use the auto pump or not, it will run out on the side of the vehicle. | |||
12/16/2010 | 39500 | ||
When refueling the gas will spray out of the port when it is reaching full before the pump will kick off. i have gotten gas on my shoes and pants several times. it has even sprayed out so bad before that gas got on another person on the other side of the pump. it is almost impossible to fill up without spilling everywhere. | |||
01/17/2011 | 50000 | ||
While fueling up the 2007 jeep wrangler sahara unlimited the fuel spills out of the fill port causing gas to spill over the vehicle and the ground. this has happend on numerous occasions. | |||
01/02/2011 | 33685 | ||
Filled up my 2007 jeep wrangler sahara unlimited and the gas overflowed and sprayed in my face and eyes. i had to rush into the bathroom and flush my eyes and face with water. i does this everytime you fill up, this time it just got me in the face. needs to recalled and fixed. my dealer won't fix it under warranty since its been over 3 years. its gonna kill someone, what if it caught fire? not to mention the environmental impact of putting that much gas on the ground. | |||
12/16/2010 | 12000 | ||
Fuel spills out of my 2007 jeep wrangler when i fill up. this happens every time i fill the jeep up. this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off. | |||
01/02/2011 | 33685 | ||
Filled up my 2007 jeep wrangler sahara unlimited and the gas overflowed and sprayed in my face and eyes. i had to rush into the bathroom and flush my eyes and face with water. i does this everytime you fill up, this time it just got me in the face. needs to recalled and fixed. my dealer won't fix it under warranty since its been over 3 years. its gonna kill someone, what if it caught fire? not to mention the environmental impact of putting that much gas on the ground. | |||
12/16/2010 | 12000 | ||
Fuel spills out of my 2007 jeep wrangler when i fill up. this happens every time i fill the jeep up. this condition generally occurs when the fuel tank is filled to the full or nearly full level and the gas pump automatically shuts or clicks off. | |||
12/21/2010 | 50000 | ||
Gas overflows every time when filling up. | |||
12/10/2010 | 30000 | ||
Fuel overflowfrom filler tube onto person pumping fuel, vehicle and surrounding enviornment. | |||
12/21/2010 | 50000 | ||
Gas overflows every time when filling up. | |||
12/10/2010 | 30000 | ||
Fuel overflowfrom filler tube onto person pumping fuel, vehicle and surrounding enviornment. | |||
12/21/2010 | 50000 | ||
Gas overflows every time when filling up. | |||
12/10/2010 | 30000 | ||
Fuel overflowfrom filler tube onto person pumping fuel, vehicle and surrounding enviornment. | |||
12/18/2010 | 46000 | ||
When filling gas tank to full, fuel overflows and spills down the side of the vehicle. this is a potentially dangerous condition. | |||
06/15/2009 | |||
Fuel spills out of filler neck with auto fill, will loose up to a pint of fuel down side of vehicle and on to the ground. started after about 18 months of use, dealer never heard of problem and had no idea of how to fix. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
06/15/2009 | |||
Fuel spills out of filler neck with auto fill, will loose up to a pint of fuel down side of vehicle and on to the ground. started after about 18 months of use, dealer never heard of problem and had no idea of how to fix. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
11/24/2010 | 47000 | ||
When we go to the gas station to fill our 2007 jeep wrangler, we engage the auto fill on the gas pump and every time gas spills out all over the side of the vehicle and onto the ground. checked path of hoses from tank to inlet and saw no visible problems that would cause this serious safety issue. i have not spoken with a dealer nor third party mechanic. please advise. | |||
06/15/2009 | |||
Fuel spills out of filler neck with auto fill, will loose up to a pint of fuel down side of vehicle and on to the ground. started after about 18 months of use, dealer never heard of problem and had no idea of how to fix. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
11/24/2010 | 47000 | ||
When we go to the gas station to fill our 2007 jeep wrangler, we engage the auto fill on the gas pump and every time gas spills out all over the side of the vehicle and onto the ground. checked path of hoses from tank to inlet and saw no visible problems that would cause this serious safety issue. i have not spoken with a dealer nor third party mechanic. please advise. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
11/24/2010 | 47000 | ||
When we go to the gas station to fill our 2007 jeep wrangler, we engage the auto fill on the gas pump and every time gas spills out all over the side of the vehicle and onto the ground. checked path of hoses from tank to inlet and saw no visible problems that would cause this serious safety issue. i have not spoken with a dealer nor third party mechanic. please advise. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
11/24/2010 | 47000 | ||
When we go to the gas station to fill our 2007 jeep wrangler, we engage the auto fill on the gas pump and every time gas spills out all over the side of the vehicle and onto the ground. checked path of hoses from tank to inlet and saw no visible problems that would cause this serious safety issue. i have not spoken with a dealer nor third party mechanic. please advise. | |||
11/26/2010 | 88000 | ||
2007 jeep sahara unlimited. fuel overflows out of the filler tube when refueling. spills onto the vehicle, the ground, and sometimes the person fueling. | |||
11/02/2010 | 41400 | ||
Jeep 2007 wrangler unlimited. when filing the vehicle with gas the pump does not automatically shut off causing gas to overflow and spill down the side of the vehicle. as this situation has occurred at several filing stations and to other jeep owners i suspect this is a design flaw of the vehicle. | |||
11/24/2010 | 47000 | ||
When we go to the gas station to fill our 2007 jeep wrangler, we engage the auto fill on the gas pump and every time gas spills out all over the side of the vehicle and onto the ground. checked path of hoses from tank to inlet and saw no visible problems that would cause this serious safety issue. i have not spoken with a dealer nor third party mechanic. please advise. | |||
06/01/2010 | 30000 | ||
2007 jeep wrangler shara, when fueling vehicle fuel spills out of tank. | |||
10/22/2010 | 51000 | ||
When filling up the gas tank on my 2007 jeep wrangler the fuel spills out when the filler nozzle shuts off. this gets fuel on me, the side of the jeep and the ground. | |||
10/14/2010 | |||
Everytime i go to fuel up my 2007 jeep wrangler unlimited sahara, gasoline spills all over the car and ground. i have even gotten gasoline on me a couple of times. your attention to this matter is greatly appreciated. thank you. | |||
10/11/2010 | 20000 | ||
Fuel spill during a refuel of my 2007 jeep wrangler. it happens on every time i refuel and it it is getting close to full. pumps kicks off and at that precise moment the fuel backs up and spills | |||
10/14/2010 | |||
Everytime i go to fuel up my 2007 jeep wrangler unlimited sahara, gasoline spills all over the car and ground. i have even gotten gasoline on me a couple of times. your attention to this matter is greatly appreciated. thank you. | |||
10/11/2010 | 20000 | ||
Fuel spill during a refuel of my 2007 jeep wrangler. it happens on every time i refuel and it it is getting close to full. pumps kicks off and at that precise moment the fuel backs up and spills | |||
10/14/2010 | |||
Everytime i go to fuel up my 2007 jeep wrangler unlimited sahara, gasoline spills all over the car and ground. i have even gotten gasoline on me a couple of times. your attention to this matter is greatly appreciated. thank you. | |||
10/11/2010 | 20000 | ||
Fuel spill during a refuel of my 2007 jeep wrangler. it happens on every time i refuel and it it is getting close to full. pumps kicks off and at that precise moment the fuel backs up and spills | |||
07/25/2010 | 36500 | ||
Gas spills over every time i fill up my 2007 jeep wrangler. it never automatically shuts off when that gas tank is nearly full no matter what gas station i go to. | |||
03/01/2010 | 35000 | ||
While filling up my 2007 jeep wrangler sahara unlimited with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it happens everytime i try to completely fill the tank. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click. dealership says nothing can be done for free without a recall. | |||
10/11/2006 | 25 | ||
2007 jepp wrangler, jk 2dr sahara. fuel overflows/spits back/spills down side of vehicle when refueling. this has been a problem every time it has been refueled since. | |||
09/20/2010 | 25000 | ||
2007 jeep wrangler gas over flows | |||
07/25/2010 | 36500 | ||
Gas spills over every time i fill up my 2007 jeep wrangler. it never automatically shuts off when that gas tank is nearly full no matter what gas station i go to. | |||
03/01/2010 | 35000 | ||
While filling up my 2007 jeep wrangler sahara unlimited with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it happens everytime i try to completely fill the tank. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click. dealership says nothing can be done for free without a recall. | |||
10/11/2006 | 25 | ||
2007 jepp wrangler, jk 2dr sahara. fuel overflows/spits back/spills down side of vehicle when refueling. this has been a problem every time it has been refueled since. | |||
09/20/2010 | 25000 | ||
2007 jeep wrangler gas over flows | |||
08/17/2010 | 41000 | ||
While filling up my 2007 jeep wrangler with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it does not happen every time, i would say 2 or 3 out of every 10 times. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click, but this still seems dangerous to me. no other fix is known for this condition. | |||
07/25/2010 | 36500 | ||
Gas spills over every time i fill up my 2007 jeep wrangler. it never automatically shuts off when that gas tank is nearly full no matter what gas station i go to. | |||
03/01/2010 | 35000 | ||
While filling up my 2007 jeep wrangler sahara unlimited with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it happens everytime i try to completely fill the tank. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click. dealership says nothing can be done for free without a recall. | |||
10/11/2006 | 25 | ||
2007 jepp wrangler, jk 2dr sahara. fuel overflows/spits back/spills down side of vehicle when refueling. this has been a problem every time it has been refueled since. | |||
09/20/2010 | 25000 | ||
2007 jeep wrangler gas over flows | |||
08/17/2010 | 41000 | ||
While filling up my 2007 jeep wrangler with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it does not happen every time, i would say 2 or 3 out of every 10 times. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click, but this still seems dangerous to me. no other fix is known for this condition. | |||
07/25/2010 | 36500 | ||
Gas spills over every time i fill up my 2007 jeep wrangler. it never automatically shuts off when that gas tank is nearly full no matter what gas station i go to. | |||
03/01/2010 | 35000 | ||
While filling up my 2007 jeep wrangler sahara unlimited with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it happens everytime i try to completely fill the tank. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click. dealership says nothing can be done for free without a recall. | |||
10/11/2006 | 25 | ||
2007 jepp wrangler, jk 2dr sahara. fuel overflows/spits back/spills down side of vehicle when refueling. this has been a problem every time it has been refueled since. | |||
09/20/2010 | 25000 | ||
2007 jeep wrangler gas over flows | |||
08/17/2010 | 41000 | ||
While filling up my 2007 jeep wrangler with gas, the gas seems to overfill and spit back out of the fuel fill neck. this occurs at different pumps with no apparent consistent factors. when the tank gets full and the pump clicks off all of a sudden about a half a gallon of gas, or more, spits back out of the neck onto me, the vehicle and the ground. it does not happen every time, i would say 2 or 3 out of every 10 times. now i have adapted my fill up strategy and fill only to what i think is near full and not let it click, but this still seems dangerous to me. no other fix is known for this condition. | |||
02/04/2010 | 15000 | ||
Fuel spraying out of fuel tank when filling up at pump. 2007 jeep wrangler. this occurs on every fill up. no damage other than fuel spraying all over vehicle, fuel pump area, etc. | |||
02/21/2010 | 55000 | 1 | |
2007 jeep wrangler sahara edition 4wd. gas overflows out of fuel filler when tank achieves full status. the auto shutoff on pump works and gas flow is cut off, however gas overflow valve in jeep appears faulty, gas shoots back out of tank. *tr | |||
02/15/2010 | 42000 | 1 | |
Everytime i fill up gas tank overflows and gas goes everywhere. *tr | |||
10/18/2009 | 40000 | 1 | |
Fuel tank over flows when filling up *cn | |||
01/04/2010 | 30000 | 1 | |
While filling up with gas on my 2007 jeep wrangler unlimited right after the auto shut off on the gas pump clicks gas surges out of the filler tube all over the side of the jeep and ground. (approximately 8 oz or so) does this now everytime i fill up if i let the gas pump use auto shut off. *tr | |||
09/14/2009 | 46000 | 1 | |
When filling fuel tank, auto shut off no longer prevents fuel spilling when tank is full. nozzle shuts off automatically, but approximately 1/2 quart of fuel is spilled onto the body, fender flare, bumper, and ground. occurs at every fuel fill-up since reaching 46,000 miles (48,000 now, so approximately 10 occurrences). *tr | |||
12/23/2009 | 25000 | 1 | |
When re-fueling, the pump clicks when full to shut off but the tank burps out fuel all over the side of the vehicle and the ground. it doesn't matter what gas station you use or how fast or slow you pump - it happens everytime. *tr | |||
12/01/2009 | 1 | ||
2007 jeep wrangler unlimited: fuel overflows everytime i fill the tank with gas. the fuel overflow does not seem to work properly. i have to slowly pump the last gallon to fill up or else it will overflow. there are multiple dates of this incident occurring. *tr | |||
11/19/2009 | 60000 | 1 | |
When filling the vehicle gas tank at standard gas pumps, the fuel routinely spills over and out the fuel fill hole after the pump shuts off. approximately 100ml of gas will shoot out of the gas tank once the pump has clicked off. *tr | |||
11/15/2009 | 1 | ||
When filling fuel tank with gas, the fuel will spill out of the filler neck after the pump is shut off. i am not topping off. this happens everytime i fill up and is unavoidable. there are many complaints on the jeep forum of the same issues. this is a major safety issue that must be addressed asap. *tr | |||
11/14/2009 | 35000 | 1 | |
Gas tank overflows after gas pump auto shuts off the first time. i am not overfilling the tank. this has happened numerous times in the last several months. *tr | |||
10/10/2009 | 29500 | 1 | |
Gas tanks spills fuels right after the click. no topping off of tank. *tr | |||
09/02/2009 | 47856 | 1 | |
I am having a problem with gasoline overflowing when the tank gets full. i have tried different gasoline stations and the same problem keeps occurring. i had one dangerous instance where gasoline splashed back onto a gas attendants sleeve and shoulder. *tr | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
10/17/2009 | 50000 | ||
Tl*the contact owns a 2007 jeep wrangler sahara. the contact stated that when filling up the fuel tank, the pump failed to shut off when the vehicle was full. the gas would overflow out of the tank at times when it was full instead of shutting off the pump. the dealer is familiar with the failure and an appointment was scheduled and then cancelled. the vehicle has not been repaired to-date. he retrieved a service bulletin from the dealer which outlined the problem. he called the manufacturer and filed a complaint. the current mileage was approximately 55,000. the failure mileage was approximately 50,000. | |||
FUEL SYSTEM, OTHER | |||
10/16/2010 | |||
When feeling my 07 jeep wrangler it always overflows with gas. when it overflows the gas goes all over the side of my jeep and on the ground. | |||
10/17/2010 | |||
Filling up my jeep wrangler (2007) when the pump clicks off it will overflo and spill gas on the ground, side of jeep and on my shoes. | |||
08/24/2010 | |||
2007 jeep wrangler. when filling up gas tank the fuel overflows when full level is reached, spilling out of tank nozzle onto vehicle, ground and on person installing the fuel. this happens every time. |