Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC | |||||
| 01011901 | 10013878 | Rear brake noise. *jb | 04/27/2005 | ||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, AIR - DISC | |||
| When brake pedal is pressed there was a mushy feeling. dealer replaced the back plate assembly, and brake shoes. please provide any further information. ph | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 10/20/2009 | 87000 | 1 | |
| T proportioning valve is leaking on my 2002 kia, loosing all brake fluid. kia dealer said this is a common problem they can repair for $230.00. the proportioning valve should not fail on any car. has this been reported before? i feel this should be a warranty item and possibly a dealer recall, what can you tell me? *tr | |||
| 08/01/2004 | 3 | ||
| Brake problems, comments from odi web user. *bf the consumer took vehicle in for recall service twice. besides the recalls ( # 04v179000). the consumer has taken the vehicle in for repair three timesfor mechanical problems, leaking gaskets, check engine light being on, and air flow meter sensor damaged. *tc | |||
| 12/01/2003 | 1 | ||
| Vehicle made grinding noises from the left front wheel. *ph the consumer also noticed that the left front hub cap and the surrounding area of the body were noticeably discolored. the vehicle was also pulling to the left and it seemed that a wheel bearing was wearing out. the consumer contacted the dealer since the vehicle was still under warranty. the dealer wasn't doing warranty work and suggested that the consumer go to another dealer. the vehicle was service by a dealer who determined that the left front brake was worn down to the bare metal while the passenger side front brake pad was still at 25% thickness. at the consumer's request the dealer investigated what caused the left side to wear significantly faster than the right but was unable to determine the cause. the consumer feels that since this was not normal wear that he should be reimbursed for replacing the brake pads and rotors. *nm | |||
| 12/22/2003 | 15000 | 1 | 03/10/2002 |
| I have a kia rio with 15,000 miles on it, and the passenger side front brakes are shot. the other brakes are not shot. they are like brand new. if this would be wear and tear it would be all around. this is poor make of this vehicle and kia does not care. the front brake broke and dug into the rotor causing much damage. and the caliber is also shot. not a wear and tear problem and kia does not want to fix this. i bought a new car so i would not have any problems. boy was i wrong. *la | |||
| 2 | 07/01/2002 | ||
| Front seat belts do not retract properly. the dealer had to replace both seat belt systems. *ak when the consumer went to the dealer they declined to repair the safety features, the consumer was told the buckle assembly was worn due to dirt being inside the assembly and was not a warranty issue.. * cb the dealer recommended that the brakes, transmission and engine mounts be replaced. also the radiator was stopped up with mud. *jb | |||
| 08/04/2003 | 8100 | 1 | 08/20/2002 |
| While applying the brakes pedal went all the way to the floor. *ak *ts | |||
| 07/14/2003 | 1 | ||
| While traveling about 35mph on the highway and without prior warning brakes gave out, the pedal went all the way to the floor. *ak | |||
| 04/01/2002 | 3 | 11/25/2002 | |
| The vehicle experienced intermittent stalling, the dealer replaced the vapor and service the fuel injection, but the vehicle continued to stall. *ak the brakes were repaired and the vehicle pulled to the right when driving. *jb | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 09/01/2002 | 100 | 3 | 08/15/2002 |
| Dt: in the high humidity or rain the rear brakes lock. it makes a scraping and scratching noise, when the brakes dry out. there is no forewarning; noticed this problem since purchasing the vehicle on september 1, 2002. have contacted three dealers, and a manufacturer's representative said that this was normal. one dealer did replaced the brake lines. *ak | |||
| 04/01/2004 | 12000 | 6 | |
| The brakes locked up when they were depressed on a wet surface. dealership deglazed and lined the brakes several times. consumer was unsure if this corrected the problem since it didn't rain when the brakes were lined. this vehicle was a programmed vehicle at time of purchase. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 1 | 06/29/2002 | ||
| The consumer states that the brakes went out and the car wouldn't stop. the closed valve caused a thumping in the vehicle and air had come in causing a loud whistling noise and the vehicle becomes hard to steer. *scc | |||
| 07/17/2002 | 2 | 06/29/2002 | |
| Consumer stated when she attempted to apply the brakes, the vehicle would not stop, and lost control of the vehicle, which resulted in a scrath on the vehicle.*jb | |||
| 3 | 12/01/2001 | ||
| Consumer states that the brakes screach, the brakes have been readjusted and cleaned 3 times. *slc | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 08/25/2002 | 2 | 07/01/2002 | |
| I was wondering if other kia owner's have had similar problems? i had the front brakes replaced due to a clip that fell off and got between the brake pad and drum, and the rear brakes replaced due to brake dust and glazing of drums. now less than two weeks later, i'm starting to have the same grinding noise in the rear brakes again and i have an appt. with my kia dealer on wed. 9/11/02 to have the rear brakes examined again. the grinding noise gets louder as time goes by, and occasionally the brakes grab. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
| 07/15/2004 | 4144 | 1 | |
| Vehicle vibrated after driving 45 mph or more. the faster vehicle was going the more it vibrated. consumer took vehicle to the dealer, who had the front brake rotors and calipers replaced. vehicle did not have abs brakes, yet the vehicle continued to shake. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 07/15/2004 | 4144 | 1 | |
| Vehicle vibrated after driving 45 mph or more. the faster vehicle was going the more it vibrated. consumer took vehicle to the dealer, who had the front brake rotors and calipers replaced. vehicle did not have abs brakes, yet the vehicle continued to shake. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM | |||
| 08/25/2002 | 2 | 07/01/2002 | |
| I was wondering if other kia owner's have had similar problems? i had the front brakes replaced due to a clip that fell off and got between the brake pad and drum, and the rear brakes replaced due to brake dust and glazing of drums. now less than two weeks later, i'm starting to have the same grinding noise in the rear brakes again and i have an appt. with my kia dealer on wed. 9/11/02 to have the rear brakes examined again. the grinding noise gets louder as time goes by, and occasionally the brakes grab. | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | |||
| 08/20/2002 | 25 | 50 | 08/01/2002 |
| While braking for a stop light consumer's vehicle was rear ended by a truck. during high humidity the brakes grabbed, causing the vehicle to stop too short. the problem happened more than fifty times with this vehicle. the dealer examined the vehicle four times. an independent mechanic found the brake lining was the problem. *ak *nm | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | |||
| 09/02/2003 | 1090 | 5 | |
| Upon coming to a stop sign and engaging the brakes the pedal went to the floor. dealer claimed that master cylinder wore out. this vehicle had been serviced for this same problem four times earlier. *ak | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC - HOSES, LINES/PIPING, AND FITTINGS | |||
| 09/01/2002 | 100 | 3 | 08/15/2002 |
| Dt: in the high humidity or rain the rear brakes lock. it makes a scraping and scratching noise, when the brakes dry out. there is no forewarning; noticed this problem since purchasing the vehicle on september 1, 2002. have contacted three dealers, and a manufacturer's representative said that this was normal. one dealer did replaced the brake lines. *ak | |||