Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 041601 | 11/14/2005 | 05228 | 10018745 | Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt | 01/12/2006 |
| 18615 | 05/01/2005 | 10017917 | Unusual engine noise or engine knock concerns due to regular fuel. *tt | 12/07/2005 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 15588 | 01/01/2002 | 630144 | Some vehicles equipped with 3.9l v8 engine only, may exhibit a rattling noise from the hydraulic cooling fan pump. *tt | 04/15/2002 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| 15117 | 08/01/2001 | 624603 | Some vehicles may exhibit an engine overheating condition. *slc | 11/08/2001 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 031404 | 08/23/2004 | 04161 | 10011162 | Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04. | 01/06/2005 |
| 02177 | 09/02/2002 | 10008581 | Cooling system-motorcraft premium gold engine coolant-serivce tips. *mj | 08/05/2004 | |
| 16581 | 01/01/2004 | 10005092 | Intermittent engine quit on decel/stops/turns. oasis. *tt | 01/29/2004 | |
| 03144 | 07/21/2003 | 10003744 | Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt | 10/29/2003 | |
| 17061 | 08/01/2003 | 10003169 | Intermittent drivability symptoms - reduced power on deceleration. *tt | 10/09/2003 | |
| 0373 | 04/14/2003 | 10002682 | Engine flood during cold start, extended cranking time, or hard to start engine when cold. *tt | 09/10/2003 | |
| 0335 | 02/17/2003 | 10002482 | Idle air control (iac) valve diagnostic service tips. *tt | 09/03/2003 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 15622 | 05/01/2002 | 637692 | Subject regarding spark knock condition. *tt | 12/04/2002 | |
| 15772 | 04/01/2002 | 637466 | Some vehicles may exhibit a engine missing or rough running condition. *tt | 11/26/2002 | |
| 02161 | 08/19/2002 | 635972 | Engine flooding, extended engine cranking time required to start, or hard start condition. *tt | 11/04/2002 | |
| 15623 | 02/01/2002 | 630669 | Concerns with engine flooding or hard start condition after a cold start. *tt | 04/19/2002 | |
| 15622 | 02/01/2002 | 630667 | Concerns with spark knock condition. *tt | 04/19/2002 | |
| 01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
| 15418 | 11/01/2001 | 630434 | Some vehicles equipped with a 3.9l v8 engine may exhibit a spark knock condition. *tt | 04/17/2002 | |
| 15569 | 01/01/2002 | 630109 | Some vehicles may exhibit a long crank or engine flooded condition when attempting to start the engine cold. *tt | 04/12/2002 | |
| 0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
| 01205 | 10/15/2001 | 627927 | Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt | 02/26/2002 | |
| 012111 | 10/29/2001 | 627770 | Some vehicles may exhibit an engine overheating condition and / or the malfunction indicator lamp (mil) may also be illuminated with codes p1285 and p1299 stored in memory. *tt | 02/22/2002 | |
| 01217 | 10/29/2001 | 627764 | Exhibiting a moaning / droning noise during light acceleratins with the transmission in 5th gear at highway speeds 60-65 mph for v6 vehicles or 50-55 mph for v8 engines. *tt | 02/22/2002 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 05/11/2011 | 95000 | ||
| I was driving down the highway at 50 mph when i heard a loud noise coming from the back passenger side. then i felt the car go out of control and i managed to safely get the car to the shoulder. my passenger door side airbag came out. when i got out of the car my tire was almost completely of the rim. i had my car towed to the repair shop and they said i needed a new axle, wheel bearing, control arm, rotor, rim and tire. upon further inspection they realized the rim went through the underside of trunk and damaged battery and electrical components. they estimated it would cost about $3,000 to fix not including the body damage. i just replaced the right front hub assembly and control arm in feb. 2011. i have replaced engine coils and valve covers numerous times. | |||
| 10/01/2008 | 75000 | 1 | |
| I am concerned that there was a recall on the 2003 ford thunderbird as well as some lincolns for valve cover leaking oil into the spark plugs. this causes the vehicle to burn oil and fill the cabin with bad gases. it requires a consumer to spend appr. $700.00 to fix; replacing the valve cover gasket and probably needing the spark plugs that are filled with and burning oil replaced on top of this cost. the 2002 lincoln ls has this exact same problem, made at the same assembly plant with the same parts the year prior to the recall but i was told by ford customer relations that not enough people complained to include this particular vehicle. the current recall/ customer satisfaction program through ford motor is: 07m07 and it requires ford to fix the problem 10 years or up to 100k miles. it is disappointing to leave this burden on customers who take care of their vehicles and come to find out that there is a known defect. *tr | |||
| 06/05/2008 | 55400 | 1 | |
| Purchased 2002 lincoln ls with the v8 motor and got extended warranty from mepco vcs premier ultimate warrant corp. for past 2-3 years this car has been in shop over 6 times; 3 times for overheating. first 2 times of overheating they stated the fan clutch was bad and replaced it and it seemed to not run hot as often but still had symptoms.. now we are waiting to find out what the new problem is; in the meantime the warranty is about to expire and i feel i have a lemon car and the warranty has yet paid me back for past few repairs to this car owing us 726.17 and if they don't fix the problem i am going to end up with a car note in repairs on this car soon... *tr | |||
| 07/31/2006 | 58000 | 4 | 09/24/2002 |
| (1) vehicle emissions system indicator light appeared on display (2) vehicle hesitates (jerks slightly) at speeds up to 60 mph, cars also kills randomly while the car is in motion (3) i have not done any repairs yet ( i have been searching for recall information) i have viewed many forums online on defective coil packs on these vehicles. *nm | |||
| 08/23/2004 | 17482 | 2 | 01/15/2004 |
| Car accelerates with no prior warning engine hit 3000 rpms had to slam on brakes did not hold car had to turn motor off. this has happened twice. dealership couldn't reproduce this they replace idle air control valve they think this is the problem? i'm not happy with the fact they are not sure if this is it what if it happens again?*ak | |||
| 06/29/2003 | 18000 | 1 | 06/15/2002 |
| Making a soft right turn at speed of 10mph, engine failed, shifted into n to restart the vehicle while moving without power steering, rear-ended a front vehicle. engine started without a problem and hasnt happened since. damage to front vehicle was at $310. damage to ls was at $960. | |||
| 05/04/2003 | |||
| Consumer states that while driving the vehicle and no warning the vehicle would accelerate. dealer notified. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 04/30/2005 | 25000 | ||
| My car has numerous parts that tear up repeatedly, within a 6 months time. valve cover gasket had replaced twice within a 6 months time. the coil packs go up very often. i had panel buttons just tear up for no reason three times! wheel caps replaced numerous times. overheating issues, door locking issues, battery replaced twice within 2 years time. ac issues, (i never used my ac..at all) . this car has a lot of problems on the t.s.bulletin. i contacted ford in reference to the multiple issues i was having with the car, the company representatives told me to take the complaint to the establishment of which i had been dealing with. then they said lincoln is an independent owned establishment so i am totally confused by this whole ordeal, they know that they have had a lot of multiple problems out of that car. and they refuse to recall some of those (as i would say) hazardous issues. i was at the dealer 2 weeks ago, i was conversing with a rep. at the dealership and he was telling me how the lincoln ls was their most problem vehicle, and cash maker for repairs. (oh by the way.......i researched to find this site. to answer the question in the consumer section) | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
| 06/04/2007 | 2 | 2 | 04/10/2005 |
| 2002 ls overheated. dealership replaced thermostat for $130. drove the car less than a mile from the dealership and it overheated again. took it back to ford and they now said the hydraulic cooling fan (hcf) is bad. they said it tested good when replacing thermostat. how can the hcf just go bad? the car still overheats even with the new fan. the new fan with labor will cost me $1000. plus the engine still overheats. why did they not see this when they did the diagnostics testing? my ls is still overheating and $1130 spent and they don't know what to do. why? | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 04/30/2005 | 25000 | ||
| My car has numerous parts that tear up repeatedly, within a 6 months time. valve cover gasket had replaced twice within a 6 months time. the coil packs go up very often. i had panel buttons just tear up for no reason three times! wheel caps replaced numerous times. overheating issues, door locking issues, battery replaced twice within 2 years time. ac issues, (i never used my ac..at all) . this car has a lot of problems on the t.s.bulletin. i contacted ford in reference to the multiple issues i was having with the car, the company representatives told me to take the complaint to the establishment of which i had been dealing with. then they said lincoln is an independent owned establishment so i am totally confused by this whole ordeal, they know that they have had a lot of multiple problems out of that car. and they refuse to recall some of those (as i would say) hazardous issues. i was at the dealer 2 weeks ago, i was conversing with a rep. at the dealership and he was telling me how the lincoln ls was their most problem vehicle, and cash maker for repairs. (oh by the way.......i researched to find this site. to answer the question in the consumer section) | |||
| 06/18/2009 | 75000 | 1 | |
| My 2002 lincoln ls's engine light came on at the end on may, i had autozone do a free test on it and it read that it was misfiring on cylinders 3 and 4. i took it on and had a tune up and replaced 2 of the 8 coils (which was about $500 total). a month later it started doing the same thing, it shutters when i reach the speed of 40 mph and it idles like a semi. i have yet to take it in, i rarely drive it because of it. i got an estimate for another $500, just for the other 6 coils. *tr | |||
| 05/15/2009 | 73000 | 1 | |
| My 2002 lincoln ls v8 has broken down in numerous ways. all ignition coils have had to be replaced, two window motors, airbag connector clip, my tie rod ends are bad, my car has actually shut off completely while driving up the 15 north three times while my son was in the car with me and now my transmission has completely stopped working. when it came to fixing the airbag connector problem lincoln told me it was fixed and i went to pick up my car and it was still doing the same thing the three beeps so they fixed it for free and then told me my instrument panel on one side was burned out but the lights seems to work on it when i turn them on. they wanted to charge me 800 dollars for that but i refused. the ignition coil replacement was roughly 1000 dollars and i am waiting on my estimate for my transmission. both window motors were 200 dollars a piece. i have had numerous taillights replaced and actually had a door lock jam closed on me. i truly feel that this car is a safety hazard for me and my son if it turns completely off at 65 miles an hour on a freeway with my son in the car. *tr | |||
| 05/01/2009 | 78000 | 1 | |
| Misfiring . *tr | |||
| 12/01/2006 | 60000 | 1 | 03/01/2003 |
| Tl*the contact owns a 2002 lincoln ls. the contact smelled a strong odor similar to burning oil when the vehicle was started. there were no warning indicator lights. the dealer stated that the valve cover gaskets were leaking onto the manifold. the dealer stated that new gaskets and covers were needed. no repairs were made. the failure mileage was 60,000 and current mileage is 75,000. | |||
| 06/01/2007 | 57000 | 3 | 08/16/2006 |
| Tl*the contact owns a 2002 lincoln ls. the contact stated that all of the electrical circuits, such as the doors and windows, are jammed. she stated that the vehicle stalls while at a stop light. the dealer stated that they did not have the parts to repair the vehicle and recommended she go to another dealer. the consumer affairs office stated that her vehicle is under the lemon law act. the current and failure mileages were 57,000. | |||
| 06/19/2005 | 1 | 04/18/2005 | |
| I was slowing down to turn right onto the on ramp of the highway when making the right hand turn and pressing on the brake the car just shut off. i lost power steering and brake power. after i used to emergency brake to stop the car, i was able to restart the car and continue on. the next time i drove the car, it mysteriously overheated. i took the car in and explained the sudden engine stope and the overheating...and the dealer only addressed the over heating problem. nothing was said or discussed about the car just turning off for no reason. | |||
| 09/29/2003 | 33000 | 10/25/2001 | |
| Engine stalls when slowing to make a right hand turn. battery power remains, but power steering is out and car must be stopped to restart. | |||
| 08/30/2003 | 1500 | 1 | 12/30/2002 |
| 2002 lincoln ls experiences sporadic engine failure. the vehicle has stalled at low and high speeds. i have spoke to two separate representatives form ford. they have acknowledged that the problem exists and as of this date they have no repair available. i was told that the problem is with a computer program. *ak | |||
| 06/06/2003 | 1 | ||
| While applying the brakes vehicle will stall without prior warning. consumer had no power steering or brakes. *ak | |||
| 05/22/2003 | 1 | ||
| While driving, the vehicle stalled and did not restart. *jb | |||
| 08/14/2002 | 8500 | 5 | 01/16/2002 |
| 2002 ls, under slow speeds and making a right turn, vehicle shuts down, including power steering and power brakes. vehicle must coast to a stop before attempting to re-start engine. *jb | |||
| 03/08/2003 | 1 | ||
| The engine stalled without warning. *jb | |||
| 02/26/2003 | 17600 | 1 | 11/02/2002 |
| 2002 lincoln ls sometimes shuts off abruptly when under braking, including light braking. so far it has always been at low speed. however, one incident resulted in minor damage because the female driver was unable to steer around a very sharp corner due to loss of engine (and therefore power steering). *jb | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 03/01/2007 | 61200 | 1 | 12/13/2001 |
| Vehicle had burning oil smell coming from engine compartment , valve cover gaskets were leaking oil into spark plug wells, requiring spark plug replacement and possible coil pack damage if not gaskets not replaced. this just after a 60,000 multi-point inspection, oil change, air filter change, fuel filter change and fuel induction svc at another lincoln dealer. lincoln should recall all ls's and replace the gaskets at no cost in order to prevent vehicle stalling at highway speeds, as coil packs and plug damage can occur and cause loss of power. *jb | |||
| 07/25/2002 | |||
| While driving at any speed and with no warning vehicle will shut off, causing consumer to pull over. it will be hard to get vehicle to start again. dealer notified.*ak | |||