Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 05161 | 06/07/2005 | 10017926 | Clunk/grind/thump noise from rear of vehicle when transmission is shifted - vehicles built before 6/13/2005. *tt | 12/07/2005 | |
| 18711 | 07/01/2005 | 10017859 | A clunk/thump noise from the rear when the transmission is engaged or shifted, during a change in vehicle direction or on acceleration. *tt | 12/05/2005 | |
| 18439 | 02/01/2005 | 10012977 | Tiny crack or cracks around the transfer case drain plug. *eh | 04/05/2005 | |
| 18252 | 10/01/2004 | 10010745 | Transmission related concerns - service tip. *tt | 12/07/2004 | |
| 18247 | 10/01/2004 | 10010742 | Harsh engagement into drive/reverse, clunk shifting from drive to park, and/or high effort to shift out of park. oasis. also includes 2005 expedition and f150. *tt | 12/07/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 18440 | 02/01/2005 | 10012978 | Check transmission control module connector this may not be fully seated. *eh | 04/05/2005 | |
| 18394 | 02/01/2005 | 10012957 | Transmission slips, shifts slow or leaks - service tip. *tt | 04/05/2005 | |
| 041912 | 10/04/2004 | 10010720 | 6hp26 6-speed automatic transmission - service tips. *tt | 12/07/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| 19846 | 06/01/2007 | 10022762 | Failed tcm programming *nj | 09/26/2007 | |
| 042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
| 04217 | 11/01/2004 | 10013369 | General power train control module (pcm) programming procedures. *tt | 04/15/2005 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - FLOOR SHIFT | |||||
| 0623 | 01/01/2006 | 10019376 | Floor mounted shifter stuck in park. *tt | 03/13/2006 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 05618 | 04/01/2005 | 10017892 | Rear axle noise repair. *tt | 12/06/2005 | |
| 18466 | 03/01/2005 | 10014659 | Axle whine howl. this includes 1997-05 ford vehicles. *eh | 05/05/2005 | |
| 18478 | 05/01/2005 | 18590 | 10014668 | Axle seal leaks. *eh | 05/05/2005 |
| 06216 | 01/01/2006 | 0644 | 10014100 | Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers. *tt | 04/28/2005 |
| 18423 | 02/01/2005 | 10012959 | Axle whine howl service with individual parts instead of an axle assembly. *eh | 04/05/2005 | |
| 18213 | 10/01/2004 | 10010729 | Grinding noise from front axle wheel hubs on acceleration in 2wd - service tip. various models including 2005 expedition/navigator. *tt | 12/07/2004 | |
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||||
| TSB-08-19-3 | 05/01/2009 | 10028736 | Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. oil separation appears to be and is often misdiagnosed, as an axle lube leak. *pe | 05/20/2009 | |
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||||
| TSB-08-19-3 | 05/01/2009 | 10028736 | Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. oil separation appears to be and is often misdiagnosed, as an axle lube leak. *pe | 05/20/2009 | |
| 04105 | 06/07/2005 | 05155 | 10008994 | Axle seal leaks. leaks from rear halfshaft axle seal. service tips. *tt | 09/07/2004 |
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
| 18815 | 09/01/2005 | 10018069 | A tiny crack, or cracks, around the transfer case drain plug hole. *tt | 12/14/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 03/31/2010 | 74000 | ||
| My vehicle is a 2005 lincoln navigator. the vehicle came to a stall while driving on the expressway. the motor was running but the vehicle would not accelerate. this is very frightening as vehicles following closely are unable to determine when my vehicle is slowing down because the brakes are not applied. the vehicle slows rapidly and there is no way to drive the vehicle to a safe place out of traffic. | |||
| 08/31/2005 | 2195 | 31 | 06/17/2005 |
| Ltr from senator hutchison on behalf of constituent, re problems with her 2005 lincoln navigator. *nj the consumer stated there was a noise coming from the engine. the front end vibrated constantly. the consumer was informed the track bar and cad mount bushings needed to be replaced to correct the vibrating. the sunroof leaked, the cd changer scratched the cd's, the drivers seat was repaired 3 times, the tire pressure sensor didn't work, the remote start did not work, the transmission was slipping, the rear windows were grinding, the drivers side door would not open, the mirror would not adjust and the wipers were replaced. the consumer stated after two years of being told there was nothing wrong with the vehicle, it finally broke down and the dealer had to perform major engine work. after the engine work was completed the consumer stated the engine continued to make noise and there was also hesitation problems. *jb updated 03/01/10. | |||
| 05/19/2005 | 2824 | 3 | 04/07/2005 |
| Dt: the consumer stated 2005 lincoln navigator was having problems with the suspension and the gear shift. the vehicle has been in the repair shop three times. the manufacturer has not been called. the consumer talked to the dealer, and they could not help him. the first time the electrical work was done, it was fixed. afterwards, the vehicle has been in the shop the past wee, and nothing has been fixed. no date was set when the vehicle will be fixed. the dealership does not know when the parts will come in. *ak | |||