Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EXTERIOR LIGHTING | |||||
12219 | 12/01/1998 | 615480 | For all vehicles with lighting control module concerns that require a module replacement, the technican must call for approval before removing and / or replacing the module. *tt | 01/17/2001 | |
EXTERIOR LIGHTING - BRAKE LIGHTS | |||||
99139 | 06/28/1999 | 606508 | Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt | 08/26/1999 | |
EXTERIOR LIGHTING - HEADLIGHTS | |||||
BC3274970207 | 02/07/1997 | 51872 | Replacement headlamp bulbs - several aftermarket companies are offering replacement bulbs with a higher wattage that are not dot approved - sold with disclaimer of for off-road use only - the bulbs draw more current than the oem bulbs a | 07/17/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
EXTERIOR LIGHTING | |||
08/04/2011 | 120000 | ||
Headlights and dash panel cut of intermittantly while driving on smooth pavement for past 10 years. i have had dealership experience this but they could not find any problem. also, the speedometer shows car speed at 100 or more mph when starting car but goes to normal when moving. i just replaced the motorcraft alternator with a rebuild version and the speedometer problem is gone. can't be sure that the headlight issue is gone too, but this seems to be the magic fix. i'm wondering if a batch of intermittantly defective motorcraft alternators were oem since this seems to be a problem for others. it is very scary to be driving 55 mph and have the headlights cut off for a short time. months go by and nothing happens; then there it is again. i was thinking that the car was haunted. i still have the old motorcraft alternator but i will return it to autozone to get my core back unless it can be used to determine it is defective. over the years i have spent a lot at repair shops and the dealership trying to locate the cause of this. at the suggestion of the dealer service manager, i replaced the speed sensor twice over the years to fix the erratic speed at startup but without any change. | |||
1 | 10/08/1996 | ||
When turning on headlights the panel lights dim due to design, this results in difficulty in seeing dash components during daytime. | |||
EXTERIOR LIGHTING - HEADLIGHTS | |||
12/09/2007 | 1 | ||
There is a very high number of vehicles of all types on the road on which the headlight lenses have become foggy or yellowed as a result of uv or chemical age. this results of loss of headlight range, clarity of vision and glare to oncoming vehicles as the result of scattered light rather than focused. i have experienced this problem on my 1996 lincoln town car and cleared it up to some extent using fine polishing cream but lens is not left clear and is getting more foggy as time passes. i consider this a hazardous fault and believe that all such headlight lenses/assemblies should be recalled and replaced. *tr | |||
09/23/2006 | 138660 | 5 | 08/10/2006 |
While driving down a narrow highway, using the high beams, the headlight system failed (no dash lights or headlights). i was using the autolamp system. i pulled to the side of the road, and tried to manually turn on lights to no avail. after waiting a minute with the car off, started it back up and headlights came back on. this happened again several times as i tried to get home. the 18 amp breaker for the lighting system was very hot. i traded the 20 amp circuit breaker from the power locks/windows system with the 18 amp breaker on the lighting system, and drove home. it did not act up again. i will try replacing the 18 amp breaker and check the load on the system with a multimeter. *nm | |||
5 | |||
Headlights failed on five occasions in the last two years, both headlights have suddenly shut off, once even when traveling at 55 mph. lights come on intermittently, about every 10-15 seconds. dealership has offerred to replace the present 18 amp headlight circuit braker with a 25 amp circuit breaker. however, owners manual indicates that using a circuit breaker with a higher amp could cause severe wire damage and cause fire. *tt | |||
07/02/2000 | 5 | 06/27/1998 | |
While driving, the headlights went off for about 10-15 seconds and then came back. *ak the consumer states that both headlights have suddenly shut off, once leaving the consumer deserted in a 2 lane highway with no other light sources. *scc | |||
3 | 06/14/2001 | ||
While driving with head lights on, the lights went out twice and the third time would not come back on. *yh | |||
08/27/2001 | 2 | 08/01/1996 | |
The entire light system fails while traveling. this has happened twice. we have had it checked and the headlight switch replaced. the incident still occurred after the replacement .*ak | |||
03/25/2000 | |||
Headlights go out frequently at night, not allowing consumer to see. dealer looked at vehicle and found nothing wrong with it. *ak | |||
04/01/1999 | 6 | 06/01/1996 | |
The headlights / dashboard lights are malfunctioning which could result in an accident due to poor visibility. neither dealer nor ford has provided help. *yc *ml | |||
04/12/1999 | 4 | ||
While driving at 2:00 am, without prior warning all the headlights went out. this is the fourth time this happened, and the dealer can't determine the cause. *ak | |||
EXTERIOR LIGHTING - HEADLIGHTS - HIGH/LOW BEAM DIMMER SWITCH | |||
03/01/1999 | 2 | ||
Whenever the high beams are in use, the entire electrical systems would shut down. vehicle was taken to dealer & consumer was informed by mechanic nothing could be found to cause the electrical shut down. *ak | |||
EXTERIOR LIGHTING - TURN SIGNAL | |||
Vehicles turn signal lights do not stay in on position if the vehicle is slightly turned to the left or right thirty degrees. dealer says that it's normal. *ak | |||
EXTERIOR LIGHTING - TURN SIGNAL - FLASHER UNIT | |||
02/01/1999 | |||
When using the right turning signal the turning signal won't stay latched at all until the driver turns the steering wheel five or ten degrees to the right/left or center in order for turning signal to work. *ak |