Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
041601 | 11/14/2005 | 05228 | 10018745 | Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt | 01/12/2006 |
0361 | 03/31/2003 | 10001855 | Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb | 07/23/2003 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
15893 | 05/01/2002 | 637773 | Some vehicles may exhibit an inoperative engine cooling fan. *tt | 12/06/2002 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
07212 | 10/01/2007 | 10023943 | Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe | 02/20/2008 | |
031404 | 08/23/2004 | 04161 | 10011162 | Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04. | 01/06/2005 |
16380 | 11/01/2002 | 10008319 | Service cylinder head gasket for 4.6l applications. *tt | 07/27/2004 | |
03256 | 12/22/2003 | 10008278 | Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj | 07/26/2004 | |
03164 | 08/18/2003 | 10003118 | Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt | 10/08/2003 | |
0322 | 02/03/2003 | 10002472 | Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without | 09/03/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
0254 | 03/18/2002 | 636045 | On some vehicles equipped with the 4.6l engine, the front end accessory drive (fead) belt may hydroplane on the water pump pulley whenthe belt is splashed with water. *tt | 11/04/2002 | |
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
01205 | 10/15/2001 | 627927 | Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt | 02/26/2002 | |
15158 | 08/01/2001 | 624571 | Some vehicles may exhibit a fead belt jump-off toss. *yh | 11/07/2001 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
02M01 | 06/01/2004 | 02M01 | 10007207 | Customer satisfaction program 02m01 supplement #4. certain ford 2000 through 2003 vehicles equipped with a tube-mounted egr pressure sensor - additional egr pressure sensor warranty coverage. *tt supplement #3. *mj supplement #6 | 06/03/2004 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
11/01/2010 | 98000 | ||
Tl. the contact owns a 2002 lincoln town car. the contact stated while driving 35 mph and without warning the vehicle started jerking with loud noises coming from underneath the vehicle. the contact drove the vehicle to a local mechanic. the local mechanic noticed one of the cylinders have been malfunctioned causing the vehicle to run on seven cylinders instead of eight. also the dealer notice coolant leaking into the engine. the dealer replaced the manifold and replaced the plug wire for the cylinder. the contact called the manufacturer regarding reimbursement and the manufacturer will not provide assistance for the contact. the contact stated if the vehicle was driving on the highway a crash could have occurred. the failure mileage was 98,000. jo | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
07/11/2002 | 2 | 05/01/2002 | |
While driving down a mountain, the engine went into an uncontroled speed. it was if someone floored the gas and the engine screamed. the brakes did not work, nor did the emergency brake. the only was to slow it down some was to put it in neutral. when put into drive again, we fishtailed the car. finally, my husband, turned the car off. each time we went up a hill we slowed down but not enough to stop, then would pick up speed when we hit another hill. after several miles my husband, when there wasn't a gully, drove on the side in dirt and high grass to slow us down. finally, just before we crested another hill, he was able to pull over more and stop. this doesn't even describe how horrible it was. we didn't think we were going to die, we knew we were, but weren't sure if we'd go over a cliff or into trees. we still don't know how we pulled it off. needless to say, i'm angry that we had brought the car in 5 weeks before for the same problem, but on flat road, and they found nothing wrong with the car. i have been informed that the nemith motors found out by calling the manufacurer, that this had been a problem. had they known 5 weeks before this, they would not have given back our car to us. i would like any report that this has happened to others, and hope their experience turned out as well as ours.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||
10/22/2003 | 2 | 06/20/2002 | |
When attempting to start the vehicle it failed to start. vehicle was towed to dealer. dealer replaced cluster panel computer and crankcase. however, the problem still occurred. *ak |