Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 01600 | 11/20/2000 | 615641 | Subject regarding inspection procedure - water pump leak. *tt | 01/26/2001 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||||
| B010/95 | 06/01/1995 | 44095 | Idle vibration due to mis-positioned dampers. *tw | 11/01/1995 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 01599 | 05/21/1999 | 606033 | Information regarding piston standardization for vehicles within certain vin ranges. *tt | 08/05/1999 | |
| 00598 | 11/04/1998 | 604035 | Experienceing a metallic tapping noise heard from the right ( rear ) cylinder head exhaust cam area. *yc | 03/16/1999 | |
| 97083000597 | 08/30/1997 | 54216 | Subject on establishment of distributor components. *yc | 03/30/1998 | |
| 97102300397 | 10/23/1997 | 54318 | Subject pertaining to mtx overhaul information. *yc | 03/30/1998 | |
| 97102300797 | 10/23/1997 | 54320 | Vehicle experiencing a oil leak at valve cover. *yc | 03/30/1998 | |
| 970716006/97 | 07/16/1997 | 53007 | Descriptions of typical engine noises. *yc | 11/06/1997 | |
| B007/95 | 04/01/1995 | 43093 | Unknown | 11/01/1995 | |
| B004/95 | 02/01/1995 | 39755 | Seal plate modification (v6 engine) *tw | 11/01/1995 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| S019/95 | 06/01/1995 | 45000 | Rattle noise from pre-muffler bracket. *tw | 11/01/1995 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| 004/97B | 05/19/1997 | 52498 | Partial engine replacement (pcv system modification). *tw | 08/14/1997 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 11/13/2006 | 103696 | 1 | 04/30/1994 |
| Tl*the contact owns a 1994 mazda 626. the vehicle was overheating and a noise was coming from the brakes. the mechanic didn't check the overheating failure. however, stated that the vehicle had a terrible vibration. the mechanic rebuilt the front end. after the repairs were performed the vehicle would pull from the left to the right, the vehicle would not drive straight , and the brakes were completely damaged. the second repair shop stated that they couldn't repair the vehicle due to the damages. the vehicle had not been repaired. the current and the failure mileage was 103696 ,and the current mileage was 104,000. *ak the consumer stated prior to the most recent repairs the following services were performed: new radiator, complete transmission service, engine tuned, and new tires. the dealer stated steering gear drifts during turns. updated 06/26/07 *tr | |||
| 11/18/2002 | 90504 | 1 | 08/13/2001 |
| The alternator or water pump belt broke due to water pump pulley alignment causing the engine to overheat and require rebuilding process. water pump pulley is positioned too close to the engine and not aligned with the alternator and harmonic balancer. v-belt shreds over time due to misalignment and lost of charging and cooling is instant. water pump pulley alignment should be checked and adjusted if needed, during engine assembly. *la | |||
| 09/01/1997 | |||
| Engine stalls continually. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 02/01/2002 | |||
| When shifting vehicle it jerks really hard. took vehicle to dealer, and dealer stated that vehicle needed engine cooling system and transmission replaced. *ak. | |||
| Whole emission system has gone out. the catalytic converter does not work. also, distributor/ water pump and thermostat failed. dealer has been contacted*ak. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| Whole emission system has gone out. the catalytic converter does not work. also, distributor/ water pump and thermostat failed. dealer has been contacted*ak. | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 01/01/2001 | 1 | 08/01/1994 | |
| Engine mounts broke. dealer has replaced mounts. *ak all motor mounts broke in two pieces, consumer paid for all repairs. *slc | |||
| 01/01/2000 | 12/01/1999 | ||
| Motor mount broken, constant problems. *ak | |||
| The valve cover gaskets are leaking oil onto engine, causing vehicle to jerk and hesitate. dealer has seen vehicle. | |||
| 01/01/1998 | |||
| When driving the vehicle it would not shift. transmission was replaced. also, vehicle leaks oil which requires a valve cover gasket to remedy the problem. dealerr is aware of the problem, problem still exists. provide further information. *ak | |||
| 07/31/1996 | 2 | 07/18/1994 | |
| Motor mounts failed. | |||
| 09/01/1994 | |||
| Valve cover seal fails, causing oil to reach plugs and evenutally fouling the plugs. | |||
| Purchase car new the transmission was replaced the engine light keeps coming on the computer system was replaced please describe the problem . tt | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| Vehicle intermittently stalls. *ak | |||
| 08/02/2001 | 20 | 05/01/1998 | |
| While driving vehicle will stall and cut off, and will not restart, after engaging clutch and attempting to cross intersection while still in first gear, engine cuts off again, consumer states this has happened at least 20 to 30 times.*jb | |||
| 03/01/2001 | 5 | 05/01/1994 | |
| While driving at any speed without no prior warning, vehicle cut off. consumer noted problem occurred more often upon acceleration. consumer has yet to contact the dealer. *ak *slc | |||
| Vehicle will stall out intermittently and without warning usually in cold weather . cause is unknown. *ak | |||
| 12/26/2000 | 1 | 11/01/1993 | |
| Many of this problems have been well documented for this vehicle. why hasn't the manufacturer been forced to address them?no safety defect mentioned in summary. *ak | |||
| While driving at highway speed of 65-70 mph engine shut off. also, while at a stop, engine will shut off. owner has been to the dealership several times for this problem. the dealer was not able to correct the problem. please provide any further information. *ak | |||
| 03/03/1999 | 3 | 06/01/1994 | |
| No summary | |||
| 03/03/1995 | |||
| While driving, at any speed, any time, the vehicle shuts down for no apparent reason without warning. the dealer is not able to detect a problem with vehicle. the battery was replaced twice 3/95 & 7/96. the car has been tuned up (3) times, 12/95, last year and 4/97. problem still exists. *ak | |||
| 11/04/1995 | 1 | 03/22/1994 | |
| Consumer came home cut off car it caught on fire . tt | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 12/26/2000 | 1 | 11/01/1993 | |
| Many of this problems have been well documented for this vehicle. why hasn't the manufacturer been forced to address them?no safety defect mentioned in summary. *ak | |||
| 05/08/1999 | 1 | 02/01/1998 | |
| The hold light started blinking on and off. the car also started jerking. i was miles from a residence almost didn't make it to a repair shop had to have it towed to a dealer to have a new transmission put in, and a new air flow meter installed. cost a couple of thousands dollars to have a new transmission put in now they tell me that it could happen again and my car has less thatn 50000 miles on it. | |||
| Whole emission system has gone out. the catalytic converter does not work. also, distributor/ water pump and thermostat failed. dealer has been contacted*ak. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 05/17/1999 | 1 | 01/01/1998 | |
| Exhaust failure...fire under car, car stopped running, catalytic converters melted, entire system replaced, covered by california warranty. transmission failure, no reverse, no neutral gears. only have 1st and 3 rd gears. transmission oil read okay till this happened, now it is gone and dealer says the fluid is fried. looking at $3000. for automatic transmission replaced. *ak | |||
| Whole emission system has gone out. the catalytic converter does not work. also, distributor/ water pump and thermostat failed. dealer has been contacted*ak. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 05/30/2001 | 3 | 04/01/1997 | |
| I've had to replace both sets of oxygen sensors three separate times. the engine light comes on then the fuel mixture is thrown off causing the car to burn very rich. each time the oxygen sensor was to blame. estimated life of each replacement was less than 10000 miles. *ak | |||
| 09/01/1995 | |||
| Vehicle has an exhaust pipe leak causing occupants to feel sick, driver experienced carbon monoxide poisoning. tt | |||