Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 0100206 | 01/26/2006 | 10019253 | Engine misfire diagnostic procedures - service tip. *tt | 02/22/2006 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| SB-01-028-10 | 08/20/2010 | 10034634 | Mazda: variable valve timing (vvt) noise when starting engine. when engine is first started, some vehicles may exhibit a loud ticking noise from the variable valve timing (vvt) (a). this is caused by the lock pin of the variable valve tim | 12/13/2010 | |
| SB-01-007-09 | 02/11/2009 | 10028524 | Mazda: vehicles may exhibit a concern of unstable idling or, in some rare cases, stalling, just after the vehicle stops with no dtcs detected. problem is due to the accumulation of carbon deposits inside the throttle body causing air flow | 05/06/2009 | |
| 01-003-08 | 07/30/2008 | 10026025 | Mazda: engine stalls when driving at low speed. *pe | 09/24/2008 | |
| 0100803 | 12/23/2004 | 0104604 | 10002275 | Oil filter cartridge removal. *tt engine oil filter cartridge housing cover damage. *tt | 08/20/2003 |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 0101805 | 06/24/2005 | 10015470 | Unusual noise from drive belt auto tensioner. *tt | 07/25/2005 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 00204 | 10/26/2004 | 00204 | 10010540 | Evaporative emmissions and reciver adapters. *eh | 11/30/2004 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 08/03/2011 | 40000 | ||
| Incident 2005 mazda 6 broke down along side road. engine only had 40,000 miles on it. called mazda service manager, bob, and he told me to have it towed there and he'd take care of me. i was later told the engine blew but as his crew looked at it they verified that the engine and oil was clean. he said he'd call regional and see what he could do for me to get the engine repaired/replaced. damage resulting after several weeks of run around i was finally told it was going to cost $90 for the service team to have looked at the engine. i was then informed that he could put a salvaged engine in for $4000. i about freaked out. $4000 for a used engine that came with a mere 90 day warranty. i called mazda headquarters and was told i should've bought an extended warranty. i told her she was crazy that no car costing over $20,000 should blowing engines with a mere 40,000. i then asked if mazda would help out by paying for service or the engine or at least half so that i could get the car back working. she told me that bob offered me a great deal and i had refused him. i told her what he offered and $4000 for a used engine plus other parts as needed didn't sound like a good deal to me at all. i asked her if it was her car if she would not expect mazda to stand behind their product and assist? she told me that mazda stands behind their products and i should've purchased the extended warranty. after reviewing the internet i see mazda 6 engines seem to have alot of loss of oil/blow out problems. always thought mazda was a good company...but i know i'll never purchase another and i'll make sure everyone i speak with hears first hand of my experience with the vehicle, the dealers run around and the arrogance at mazda hq in california. | |||
| 10/01/2011 | 96000 | ||
| I think the mazda line of vehicles should be looked into. i have a 2005 mazda 6 i sedan that from the very begining had issues. at 5000 miles i complained to the nhtsa because the car shut off on me on the highway. i took it to the dealership and the dealership could not duplicate the problem. the problem with the car shutting off has happened a few other times over the years and i've always had it investigated however the dealership could never find an issue. finally it is 2011 and the car has 96000 miles on it and is completely shut down. as it turns out despite getting every piece of maintenance done on time and in order by the manufacturer cylinder #2 and #3 misfire and ultimately need retrhreading? . i wonder if this was a problem on the car to begin with. i have talked to a few other mazda 6 owners who have had a similar experience as i did. | |||
| 02/22/2010 | 57000 | ||
| Tl*the contact owns a 2005 mazda6. the contact stated that while at a traffic light, the vehicle began to hesitate as if it were going to stall. the contact had to apply pressure to the accelerator pedal in order to keep the engine running. the contact took the vehicle to the dealer and was told that two engine coils needed to be replaced; however, when that did not correct the failure, the contact was told that the catalytic converter needed to be replaced. the failure continued to occur and the contact was told that the engine needed to be replaced. the contact was concerned that the failure was a manufacturers defect that was never repaired under warranty. the failure mileage was 57,000 and the current mileage was 66,000. | |||
| 02/22/2010 | 57000 | ||
| Tl- the contact owns a 2005 mazda6. the contact stated while sitting at a light, the vehicle started to feel like it was going to stall. the contact had to keep their foot on the gas to keep the engine running. the contact took the vehicle to the dealer and was first told that two engine coils needed to be replaced. when that failed, the contact was told the catalytic converter needed to be replaced. when that failed the contact was told the engine needed to be replaced. the contact feels this is a manufacturer defect that was never repaired under warranty. the failure mileage was 57,000 and the current mileage was 66,000.rl | |||
| 02/07/2007 | 3000 | 5 | 08/15/2005 |
| In august of 2005 i purchased a mazda 6 (automatic transmission). after 2 - 3 weeks of ownership my mazda died on me one day while driving on the highway. i immediately took it to the dealership yet no problem was identified. 4 - 5 months later my car stalled while sitting at a light. a couple of months after that, my mazda stalled again. a couple of days ago while backing out of the driveway my car just turned off. it's so annoying because i always take it to the dealership immediately after the stalling occurs and they can never identify a problem; they try to recreate the conditions and put miles on my car but it doesn't stall for them. when it stalls there is no warning (i.e no lights, engine noise,etc). it turns right back on immediately; i notice the lights and the fact that my engine is no longer on. i simply put the car in park and turn the ignition and the car runs fine. this stalling occurs every 5 - 7 months. i've complained and complained to every mazda dealership i've been to and have sent multiple emails and made multiple phone calls to the corporate office about this issue. because the problem can't be identified the mazda technicians can offer no remedy. *jb | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 04/01/2006 | 24827 | 1 | |
| Engine failure, 2005 mazda 6 4 cly | |||
| 05/09/2007 | 22200 | 1 | |
| Tl*the contact owns a 2005 mazda 6. the contact attempted to accelerate from a stop, but the vehicle failed to move. the engine automatically shut off and the vehicle appeared to switch to accessory mode. the lights on the instrument panel illuminated, but the engine was not running. the vehicle was shut completely off and restarted. the vehicle began to operate normally, but the contact stated that the transmission delayed and shifted roughly when turning corners. the vehicle has previously experienced transmission failure, but it never shut off while driving. the current and failure mileages were 22,200. | |||
| 04/23/2007 | 61200 | 1 | 08/26/2005 |
| 2005 mazda 6 6 cylinder with 61000 miles , needs new engine. the only sign was a screech noise a few times , took it to an auto shop, where they checked the belts ,and we could not reproduce the sound. started a minor oil leak ,and less than 4 days later engine failure, and the dealer says it needs a new engine. just out of warranty. mazda dealership says the oil looks black and indirectly told me that i probably did not do regular oil services, which is untrue . i just did not use the dealership. contact the mazda corporate, and they said they will investigate this problem , but have not received any response. i am totally disappointed in this vehicle, who i nursed and mostly did longer distance driving. the dealership repeatedly said that the car has a lot of miles on the odometer for its two years old. never had any vehicle who disappointed me like this! expensive lesson for me and mazda have not been helpful at all. every communication have been really vague and every person which i talked to made sure that i that i know that the car have not been maintained by the dealership and stressing the fact that the car does not have any warranty. not any real help from the mazda dealership except giving me the expensive quotation for a new engine. did not offer to take up the issue with mazda corporate even though the car is fairly new and well taken care off. the warrant just expired a 1000 miles ago. any one with a similar experience of engine failure in a relatively new car? *ak | |||
| 06/13/2006 | 15655 | 5 | 10/09/2004 |
| 2005 grand touring gets stuck in gear while driving. *ts the vehicle became stuck in gear three time while driving on the freeway. the consumer took her foot off the accelerator yet the vehicle continued to move at 60 mph. the consumer pressed the brake pedal but the vehicle continued at 60 mph. the consumer put the car in manual 6 speed and the vehicle bucked then worked normally. as soon as the vehicle was put back into automatic mode the gears became stuck. the vehicle was taken to the dealer but they were unable to duplicate the problem. the consumer noticed condensation on the inside bottom of the windshield. the check engine light illuminated due to failed throttle body. the radio experienced problems. the left rear wheel was bent and caused vibration while driving. *nm | |||
| 02/04/2005 | 2224 | 1 | 02/13/2004 |
| I purchased what i believed to be a brand new car on december 13, 2004 the car i purchased is a 2005 mazda 6 i did not no at the time that the car i believed to be new had 1,610 miles on it, i believe he sold me a demo which is also a part of my complaint, on 2-4-05 my brand new mazda broke down, and now needs a new motor, it was towed on 2-4-05 and taken to white plains mazda, white plains ny on 2-8-05 where as of this 2-17-05 it is still in the shop awaiting a new motor, to which i have every intention on taking said vehicle when it is repaired back to place of purchase, i believe that maybe they might have even turned back the odometer, i wish for this to be noted so therefore maybe mazda down on hillside avenue , in jamaica queens will not do this to anyone else. also how does a brand new vehicle purchased in december break down the first week in february. *jb | |||