Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 00100R | 03/09/2000 | 0100100 | 621310 | Some vehicles may exhibit a no start, rough idle and / or lack of power after a 60,000 mile timing belt replacement interval. *tt | 09/17/2001 |
| 00200 | 02/23/2000 | 609949 | Subject regarding 60,000 mile service, inspection and / or replacement of the tensioner pulley. *tt | 04/11/2000 | |
| 00198 | 02/23/1998 | 603906 | Some vehicles may experience hla noise. *yc | 03/11/1999 | |
| 00198 | 02/23/1998 | 600148 | Concerns with hla noise heard after a cold start. *yc | 04/27/1998 | |
| 013/95 | 12/01/1995 | 46704 | Cylinder head gasket modification. *sd | 04/25/1996 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 02/15/2002 | 1 | 12/01/1999 | |
| Received information on special program #ssp-33 from mazda regarding fuel fumes. took vehicle to dealership. mechanic refused to do any repairs on vehicle. *ak consumer adds while driving up hill, vehicle will only accelerate up to 10 mph, once reached lights flicker engine, brakes and steering locked up, resulting in loss of control, vehicle started smoking and steaming causing the engine and transmission to fail, on several occasions engine is overheating, coolant leaks at engine, the water pump belt broke, dealer replaced coolant hoses, water pump, timing belts, head cylinder, thermostat, radiator hose and fan clutch. *tt | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 06/13/1999 | |||
| While driving consumer noticed fuel light had come on, but gas gauge showed half a tank, consumer pulled over, opened hood, and radiator reservoir exploded, and he received burns. there was no smoke prior to that. *ak | |||
| 07/01/1999 | 2 | 03/01/1992 | |
| No summary listed for above vehicle. *ak | |||
| 04/01/1997 | 3 | ||
| Automatic transmission failure; also water pump and air conditioner malfunctioned. *ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
| 06/15/1998 | 3 | ||
| Driving at approximatly 55 mph for at least 1 mile ,oil light came on. consumer went to open hood when hot, anti-freeze came spraying out onto consumer, causing 1st and 2nd degree burns to body. delaer has changed water pump three times prior to this incident. **ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 09/18/1997 | 1 | 02/01/1993 | |
| Radiator outlet pipe ruptured. | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 08/14/1999 | |||
| Does not allow for enough oil flow in the engine lifters, causing engine failure . manufactureris aware of defect, and has redesigned part . *ak | |||
| Feed hose is too small for the oil to go through, causing the lifter to collaspe against rocker arm, resulting in a loud noise. faulty design in the engine. *ak | |||
| 04/10/1999 | 2 | 03/01/1996 | |
| Oil smoke, valve or lifter noise, rattle when vehicle not in acceleration. *ak | |||
| 10/01/1997 | 2 | ||
| Driving 35mph, heard a buzzing noise when the engine stopped for no reason. vehicle seemed to be in neutral. could not shift in to reverse or drive. had taken to dealer prior to problem & was informed nothin wrong w/transmission or engine. took it back to be checked again and transmission had to be replaced. *ak | |||
| 07/12/1996 | 2 | ||
| The engine is making a loud tkicking noise.the consumer states the engine is about to go out due to defective engine lifters. *ak piston ring, head gasketand rocker arm failed. *yh | |||
| 02/11/1997 | 1 | 07/21/1992 | |
| Engine lifters replaced. | |||
| All rocker arms and lash adjusters had to be replaced due to inconsistent direction peeling w/metal shavings and severe thumping. 3 replacements were are faulty | |||
| 08/01/1995 | |||
| Engine pistons builds up carbon, only repair available is to replaced engine. tt | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 06/15/2000 | 1 | 04/01/2093 | |
| With this van there have been numerous incidents since august of 1993. the first problem was a ticking noise in the engine. the van was out of service for 3 months while they dallied around to fix it. i had it taken to northtowne mazda and it took them a week to fix it. the second problem was a constant breakage of the little pin that shifts the gears. the thing breaks constantly and causes the gear dial letters to be off by one letter for instance the r for reverse is d for drive. the next problem was a gas leak that i took in to have fixed three times before it was finally found. i was told on two different occasions that it was just exhaust and that the problem could not be found. i drove the vehicle to memphis and liked to gas myself to death from the fumes on the way there and back. upon return to kcmo i took it directly back to the dealer. the service manager said just leave it outside and we will bring it in and check it. i made him come outside to the car. you could smell the gas from 50 feet away. when he took it in there was a rupture inthe fourth quarter panel hose that when you took a left turn it spilled gas into the passenger rear seat. the next problem that i had with this vehicle was that the calipers, rotors and brakes wore clean through after only 20,000 miles of wear on the new brakes. firestone fixed them. then i have had to replace the timing belt now 5 times. i had the first timing belt was replaced at 66,000 miles, the second at 78,000 miles, the next at 108,000, and then 138,000, now at 139,463. s memo came out from mazda to service repair shops that the spacers are defective and that when the timing belt is changed these need to be replaced also. this memo just came out in june 2002. the other problem that i have had is the transmission went out because mazda has a defectivepart that won't let enough oil in to allow the engine to run, this causes a loud ticking noise in the engine. the next problem was the sway bar. | |||
| 04/10/1999 | 03/01/1996 | ||
| Transmission had been rebuilt, under the warrenty, after i moved to ohio, for a new job, the warrenty had run out, and i needed to get the car repaired, but i never proceeded witha complaint at that time | |||
| 06/01/1997 | 2 | ||
| Mazda has a problem with the wiper arm-it quit during my commute during a hard rain. it posed a very real danger. regarding the engine: mazda knows there is a design problem and it has a very expensive fix...i now own a 2nd mpv only to have the same hla problem with this second van. now i know it's an inherent problem and the consumer is having to pay for this very expensive fix. | |||
| 07/12/1996 | 2 | ||
| The engine is making a loud tkicking noise.the consumer states the engine is about to go out due to defective engine lifters. *ak piston ring, head gasketand rocker arm failed. *yh | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 02/11/1997 | 1 | 07/21/1992 | |
| Oxygen sensor failed. | |||
| 09/23/1996 | 3 | 12/01/1992 | |
| Oxygen sensor relay defect, causing vehicle to stall when driven over water. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 142000 | |||
| There was a very strong gas odor in the cab of the vehicle. *nlm | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
| 08/26/1997 | 06/01/1992 | ||
| Broken pcv valve, emitting strong gasoline fumes. *ak | |||