Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
| 0103105 | 11/22/2005 | 10018256 | Fuel distributor insulator-removal / installation cautions-service tip. *ts | 12/19/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 09/05/2012 | 145000 | ||
| Tl* the contact owns a 2004 mazda rx8. the contact was driving approximately 10 mph and smelled gasoline fuel coming from the vehicle. the contact also stated that the check engine warning light was illuminated. the vehicle was taken to the dealer for diagnostic testing. the technician advised the contact that the oil pan, throttle body assembly, fuel pump assembly, catalytic converter and spark plugs needed to be replaced. the vehicle was taken to the dealer on several occasions for the same failure. the manufacturer was made aware of the failure and advised that the vehicle was not included in any recalls. the vehicle was not repaired. the approximate failure mileage was 145,000 and the current mileage was 146,000. the vin was unavailable. | |||
| 05/21/2010 | 72000 | ||
| Tl-the contact owns a 2004 mazda rx-8. while driving 45 miles the contact stated the that underneath the vehicle was the exhaust was located, the contact stated the exhaust began to get hot. the contact stated wires melted from underneath the vehicle causing smoke. the contact spoke with the dealer who advised there were no recalls available. the dealer had not diagnosed the vehicle. the vehicle had not been repaired. the current miles were 80,000. the failure miles were 72000. aa | |||
| 04/10/2010 | 43123 | ||
| 2004 mazda rx-8, under 45k miles. driven on a 78 degree day for 2 hour trip. stopped to refuel and 30 min shopping. get into car onto highway where i need my engine's speed to accelerate onto highway. i feels like half the power is gone. it reminds me of vapor lock, it's gasping for fuel or spark. this has been experienced many times before and nearly dangerous when in busy traffic, as had to pull over to birm. i know dealer replaced coil packs once or twice so far...along with plugs. this is the most dangerous car i ever owned. the most re-called car i've ever known of. right now it's running fine, matter of fact has power to spare as compared to it's 'whimping out syndrom . there must be a corporate solution from mazda to me. i am ready for a lawyer. | |||
| 03/10/2010 | 1 | ||
| I don't even know where to begin with the problem i have had with my 2004 mazda rx-8. i have owned it since september 2003 and it has had countless issues, parts replaced and failures. the incident i experienced last night put me over the edge and almost cost me my life. my rx-8, which was just at the dealer 2 weeks ago, had an engine malfunction while i was on a major highway in massachusetts. the speed of the vehicle went from approx 50mph to 10mph in a matter of a few seconds. luckily i was able to make my way to the breakdown lane without injuring myself or anyone else; however, this is unacceptable. every single part in my rx-8 has been replaced except for the engine mounts and engine. i have dished out thousands of dollars already and the vehicle only has 44,000 miles on it. not only is this a safety hazard to those of us driving the vehicle, but it is also a safety hazard to those around us. had the car behind me not been paying attention my vehicle could have caused a deadly car crash in the middle of rush hour on a major highway. i have contacted numerous dealerships, the bbb, and am now looking into a class action lawsuit. mazda needs to be held accountable for their actions. unfortunately because my car was purchased in 2003, bbb wouldn't have anything to do with the case, however i have 57 pages of detailed repairs that have been made to this vehicle since i owned it, which i am more than happy to send to you. tons of people online have had similar issues; just from automotive.com there are 30+ email addresses of individuals who have experienced problems similar to mine. please help us get to the bottom of this faulty engine and make mazda own up to their mistakes. people's lives are in danger and this is neither acceptable nor ethical. ps- an employee of nhtsa has been contacted prior regarding this situation. her name is cortney and her contact information is 1-888-327-4236 ext #: 1268. i received this from the automotive.com forum. *tr | |||
| 07/06/2009 | 35000 | 1 | |
| I want to go on file that i have a concern with the solution to a problem with our 2004 mazda rx 8. we purchased it used from a reputable ford dealer several months back and had an issue with starting the car. after some online research we found out the car is prone to gas flooding when not allow to run until the temperature gauge is halfway. if shut off before the engine floods with gas. i took it to cory fairbanks mazda where the vin was checked and that the car did have the recall 4206f already done and the only solution to the problem is to let the car warm up. my concern is the constant excessive flow of gas during start up, raw gas constantly flowing through the catalytic and the excessive heat created by these engines could cause a fire and injure all those in and around the vehicle. i have emailed mazda also about my concerns and feel the solution is a disaster waiting to happen. thank you. *tr | |||
| 05/30/2008 | 105000 | 1 | |
| The 2004 rx8 has internal seals fail prematurely. this causes the engine to blow by a loss of compression in one of the two rotor chambers. the problem being the car with still run with half power. i continued to drive to find help off the highway. the rotor that is not working is dumping gas into the catalytic converter. by the time i parked, i could smell burning fiber and plastic and the exhaust shot out several large chunks of red hot ceramic material. the catalytic converter was bright orange and the entire underside of my car is melted. looking on internet under 2004 rx 8 engine failure i have seen several other stories with similar results but worse. is it possible that the fuel tank could explode with such heat so near if you continued to drive. this happens anywhere from 12,000 miles to 100,000 miles and beyond. mazda knows of the engine defect and has extended the warranty on the motor as of may 2008. my car is at hancock mazda in dallas. they said damage amounted to $9,500.00 from heat. *tr | |||
| 02/15/2008 | 1 | 02/10/2007 | |
| My mazda rx-8 has stalled many times while at a traffic light and while going on trips on the interstate and all of a sudden it would lose power and stalls and i would have to pull over and start it again which it would take a few minutes before it would start. i have had my mazda towed from my house to the dealer bec it would not start and i was told that it was flooded. now it won't start again and it is really frustrating and starting to worry me how dangerous it is driving my mazda. i have had my mazda for a year now and the only time i drive it is when i go on a long trip or to go shopping and mostly on weekends or after i get off from work. i would like to have this resolve so that i won't get hurt or somebody else will get hurt bec of this. i understand that mazda rx-8 had a recall on fuel system i just wonder if this was taken care of for this car. the dealer told me the car is fine and to make sure to warm it up before you shut the engine down ,i have done that and now my mazda will not start again. *tr | |||
| 01/29/2006 | 8 | 01/01/2004 | |
| I am currently in the process of trying to resolve an on-going engine startup /vehicle stall problems with my 2004 rx-8. this car has only 15,000+ miles and has been driven for short, daily runs to work and recreational drives. the rotary engine has a required engine warm-up procedure before shutting it off. a deflooding procedure is also required if engine fails to start in the manufacturers manual. mazda has already had a recall on the fuel system computer with update software. the car had to be towed from my garage to the dealer to have this done because of a nonstart situation. the problem seemed to be corrected by them although a stalling while a red lights or no startup after refueling at gas stations problems recurred. the car again had to be towed from my garage to the dealer to be checked for the nonstart-up issue. a replacement of battery, altenator and spark plugs were done. the problem seemingly cleared for half the day until a trip for fuel caused another nonstart incidence(stuck at the pump) in a $34,000 car! it finally restarted after 10 min and was driven back to the dealer the next afternoon where the problem then recurred in their garage. the dealer has now told me i must wait longer after the manufacturer's required engine warm-up time to shut off the car and not to restart engine in short periods of time. is this insane or what! this explanation didn't fly with me, so the car has been now rechecked and ok'd to drive again by their technicians with no changes made. they wished me good luck! *nm | |||
| FUEL SYSTEM, OTHER | |||
| 02/28/2009 | 1 | ||
| 2004 mazda rx8 was repaired on 2/27/09 at hernando mistubishi the service department for gulfview motors, due to the fuel gauge reading incorrectly and the vehicle running out of gasoline on a reading of a 1/2 of tank. on 2/28/09, after vehicle was supposedly repaired , the 2004 mazda broke down due to in accurate fuel reading, a day after the vehicle was serviced for this problem. the check engine light also came back on and has consistently stayed on. john morris and linda sanford were both aware that this was a major problem that clearly fails the required nys motor vehicle inspection. the vehicle needs to be repaired at mazda and it is the responsibility of gulf view motors. i have driven to syracuse, n.y. out of my way and paying for gasoline to speak with mr. paul corey, service manager for mazda. *tr | |||