Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | |||||
9523 | 01/01/1995 | 39119 | Erratic distance-to-empty and fuel gauge readings. *tw | 03/17/1995 | |
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||||
96225 | 10/21/1996 | 50944 | Mass air flow sensor - replacement as an assembly - service tip. *tw | 06/17/1997 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
94224 | 10/01/1994 | 37748 | Moaning or hooting noise coming from the engine compartment may be coming from the idle air bypass valve. *tw | 01/06/1995 | |
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
CSP 08B04 | 05/15/2008 | 10026401 | Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe | 10/24/2008 | |
012114 | 10/29/2001 | 627791 | Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt | 02/25/2002 | |
14862 | 04/01/2001 | 619299 | Information on replacing fuel tank strap bolts. *tt | 05/23/2001 | |
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
CSP 08B04 | 05/15/2008 | 10026401 | Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe | 10/24/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - STORAGE | ||||||
SQ01014 | FORD MOTOR COMPANY | 11/27/2001 | 10/03/2002 | POST REAR END COLLISION FIRES | 02I003000 | |
Allege fuel tank can rupture following a high-energy rear collision resulting in severe fires. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
05/02/2008 | 162000 | 1 | |
I have pictures of the fuel pump i took out of my 1992 mercury grand marquis. the car had coughed to a stop and i suspected the fuel pump. there was no pressure in the fuel rail so i pulled the pump out of the tank. i checked the pump with a battery and it ran fine. then i started looking at the fuses and found the 20a pump fuse blown. obviously there was a short somewhere. as you can see by pic 2 the short occurred when the hot wire insulation was worn through on the float bracket. in order to blow a 20a fuse there must have been a spark. fortunately, it appears that the contact point was under the level of the gasoline when the short occurred and nothing else happened. if the point had been above the gasoline in the vapor area the results could have been much different. pic 3 is how i routed the wire before replacing the assembly back in the tank. btw you can see that i did use a new fuel pump. i still have the old one. i sent a message to the ford motor company through their web site but have not heard anything. as of now i am afraid to drive my 1997 grand marquis since the design is identical. i guess my next stop is the dot or better yet youtube. i never did understand putting an electric motor in the fuel tank. jerry holland *tr | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
2 | |||
Fuel leakage occurred due to the brake line rubbing against the fuel tank which also caused the gas tank to corrode. *ak dealer installed the new brake line it also hit the gas tank. *yh | |||
Consumer had a problem with the fuel line interference which cause the car to stall. tt | |||
When attempting to accelerate car will hesitate due to possible fuel line interference. tt | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
11/01/1997 | |||
Fuel lines rusted, leaked heavily, smelled gas. dealer replaced all the gas lines and pump. *ak | |||
As of a result of fuel pump blowing, vehicle wouldn't start. *ak | |||
08/13/1996 | 1 | 01/03/1992 | |
Fuel pump shorted out, causing wiring to burn. *ak | |||
10/01/1994 | 1 | ||
Fuel pump failed, causing vehicle to stall twice. *aw | |||
06/04/1993 | 2 | ||
Fuel pump replaced twice, experienced erratic operation and poor performance. tt | |||
05/05/1995 | |||
Faulty wiring in electronic fuel pump. tt | |||
04/14/1995 | 1 | ||
Wiring to fuel pump shorted out and then melted out/burned. tt | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
11/01/1997 | |||
Fuel lines rusted, leaked heavily, smelled gas. dealer replaced all the gas lines and pump. *ak | |||
04/17/1994 | 7 | ||
Routing of fuel cable caused steering column to rub hole in fuel line. *dh | |||
05/15/1995 | 1 | ||
Fuel line/pvc coupling to fuel filter snapped when struck by debris, creating a fuel leakage. tt | |||
The fuel line is rubbing on the frame causing the potential for a fire hazard. tt | |||
03/31/1995 | 1 | ||
Fuel line wore out due to corrosion, dealer replaced it. tt | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
03/30/1995 | 1 | ||
Fuel pump failed, emitting fuel fumes/odor. *ak | |||
05/21/1991 | 1 | ||
Vehicle bucks/surges upon acceleration, also fast idle. | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
11/21/1995 | |||
Fuel system malfunction, fuel injectors do not provide constant fuel to engine, causing engine to stall. tt | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
02/16/2003 | 91000 | 1 | 04/01/1992 |
The consumer was concerned that if she was involved in a rear end collision, the vehicle would catch on fire. the dealer stated a recall had been issued, but only for police vehicles. *ak the consumer is afraid to ride in the vehicle. (daughter minnie ormerod on behalf of mother rosalyn ormerod). *ph *jb | |||
06/01/1992 | |||
After filling or putting gas in tank gas fumes fill trunk and inside car. | |||
There's a hole in the gas tank which was caused by the gas tank rusting through. please explain. *ak | |||
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
03/05/1998 | 1 | ||
Fuel tank sending unit failed. |