Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| OTHER | |||
| 05/15/2003 | 97935 | ||
| Exhaust manifold studs breaking off. checked prior to repair by calling a local ford dealer and also on the internet, to see if there was a recall on this as it is an extensive repair and very expensive to repair. could not find an official recall from ford, but found numerous websites and complaints and concerns from owners, nationally, as well as internationally, of the 1993 mercury villager who have experienced this exact problem. | |||
| 07/02/2000 | 04/01/1998 | ||
| There is a recall already but the recall does not extend far enough those van manufactured up to 1993 may, which is when my van was manufactured. no safety defect listed. *ak | |||
| 01/30/2000 | 1 | 03/01/1994 | |
| Mercury seemed to be aware of the problem but did not contact owners. np safety defect listed. *ak | |||
| 11/07/1997 | 3 | 01/01/1994 | |
| The exhaust manifold studs(left side)broke first. we were required to fix for $170. next the exhaust manifold craicked and it was replaced. finally the right side manifold studs broke in late 1998 and we had to replace those for around $200. there are numerous complaints in your database already regarding this same problem. some involved exhaust leaking into the passenger cabin which is very dangerous. i would recommend an investigation with ford being required to fix and refund owners for this resolving this obvious defect in their exhaust system. | |||
| 09/08/1995 | 4 | 12/12/1992 | |
| There has been smoke present from the front blower assembly. tt vehicle experienced transmission leak on several occasions, dealer finally replaced the front axle, shaft, and boots and seal, transmission also slipping and jerking, lubricated front cv joint due to noises coming from front. vehicle idles too fast/rough, dealer set idle speeds, poor fuel economy, dealer repired vacuum lines, fuel shield attaching part broke, exhaust leak, dealer replaced muffler and resonator. water leak at back glass, trim missing. noise in ac and heater, dealer removed material from blower housing, dealer finally replaced blower motor. right door lock inoperable. trim loose on inner fender. missing panel under glove box. brake noise in rear, front brake pads and front rotors have been replaced. *slc | |||