Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
97610 | 03/17/1997 | 51990 | Blower motor- chirping or squeaking from blower motor at low speeds. *jd | 07/17/1997 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
11528 | 04/01/1998 | 613792 | Some vehicles may exhibit a surge under certain deceleration conditions, engine stalling during transmission engagement, or an excessive sulfur-type odor from the exhaust at times. *tt | 08/03/2000 | |
983105 | 02/24/1998 | 607399 | Information regarding engines being added to the fqr (ford quality renewal) assembly program. *tt | 09/22/1999 | |
99816 | 05/03/1999 | 606420 | Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt | 08/19/1999 | |
97050110615 | 05/01/1997 | 52894 | Engineering is investigating oil leaks on 1997 villagers. *tw | 10/30/1997 | |
BC2223970501 | 05/01/1997 | 52767 | Engineering is investigating oil leaks on 1997 villagers. *tw | 09/12/1997 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
982010 | 10/12/1998 | 603695 | Experiencing a buzzing or rattling noise from the exhaust system. *yc | 03/02/1999 | |
9864 | 03/30/1998 | 601312 | Information on a buzzing or rattle noise from the exhaust system. *tt | 07/21/1998 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
BC0040961101 | 11/01/1996 | 50813 | Damage to front and/or rear 02 sensors for 96-97 villagers. *tw | 06/17/1997 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
98-4816 | 09/01/1998 | 607227 | Concerns with egr flow malfunction. *tt | 09/15/1999 | |
996018 | 05/01/1999 | 606946 | Brief information regarding exhaust gas recirculation (egr) system diagnosis. *tt | 09/09/1999 | |
99103 | 06/01/1999 | 606476 | On some vehicles the check engine warning lamp may illuminate and diagnostic trouble codes 32, 35, p0400, p0402, p1400, p1401, p1402 or malfunction indicator lamp 0302, 0305, 0306, 0514, 1005 may be stored indicating a malfunction in the ex | 08/25/1999 | |
12623 | 03/01/1999 | 605342 | Information regarding exhaust gas recirculation valve (egr) system diagnosis. *tt | 06/08/1999 | |
BC2304970501 | 05/01/1997 | 52800 | Egr function testing. *tw | 09/12/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
01/01/1901 | 1 | ||
Check engine light kept illuminating. *ph when the vehicle was purchased the consumer noticed that the check engine light was on. the dealer reset it but it kept coming back on. it was later determined that the problem was with the speed sensor. *nm | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
02/09/2002 | 04/01/2000 | ||
No summary listed for above vehicle. *ak | |||
08/01/2001 | 0 | ||
Consumer was traveling about 65mph on highway, and without prior warning, vehicle shut off. lost power brakes and steering. dealership was aware of the problem. she paid to have vehicle put on a machine, but problem couldn't double itself.*ak | |||
03/15/2001 | 12 | 09/18/1997 | |
Since september 1997 consumer kept taking vehicle to dealer for hesitation, engine light coming on , stalling, bad gas milage and sputtering. dealer kept telling consumer it was due to reformulated gasoline. to dealer at least 12 times. currently, vehicle is out of warranty, and dealer finds all fuel injectors need to be replaced, at cost of $1700.*ak *slc | |||
1 | 05/21/1999 | ||
While traveling doors lock and unlock out of control. also while vehicle is turned off. *ak power lock system is defective while vehicle is running or shut down, consumer states locks are inoperable, dealer refuses to replace system and they have not been able to repair it. consumer states vehicle had engine problems two days after purchase. *slc | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
02/21/2001 | 2 | 12/01/1997 | |
Please refer to voq odi number 741337 from feb/01 this was when the front exhaust manifold stud bolts broke. i made a mistake please release this information to flm. thank you this new incident report is for the rear manifold. *ak | |||
01/01/2001 | 1 | 12/01/1997 | |
No summary listed for above vehicle. *ak | |||
02/02/1997 | |||
Gasoline fumes are filling up the inside of the vehicle at any given time without any warning. vehicle has been repaired 4 times for the same gas leak. dealer has been notified. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
01/01/2002 | |||
Nhtsa recall 00-v-419-002/ manufacturer's recall 00s59 vehicle didn't start having problems until repairs were performed. fuel leaks from fuel pump, which would normally receive the connection to flow of gas. consumer has gone to two dealer to confirm the problem.*ak | |||
02/25/2001 | |||
Consumer received notification for recall 00v419002, and has been informed repeatedly that part was unavailable to repair the defect. please provide any additional information/attachments.*ak | |||
03/06/2001 | |||
Consumer had contacted t white & clark lincoln mercury dealer twice for an appointment, and each time parts haven't been available. recall 00v419002 manufacturer's recall 00s59. *ak | |||
11/01/2000 | 04/01/1997 | ||
Vent hose on tank leaks. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
06/21/2004 | 81000 | 1 | 04/09/2001 |
I am one of tons of people with the notorious exhaust manifold studs breaking issue! which causes the check engine like to come on, and dangerous fumes to enter the vehicle. with 4 children, this is not a good thing...and the price is more then a family of 4 children can afford at $1500-3000 depending on the damage and now i cannot have my vehicle safely inspected due to this issue. please have them issue a recall on this and protect our families. | |||
1 | 08/01/1999 | ||
There were problems with the exhaust manifold bolts. the manufacturer was not contacted at the time of this call. *ak *scc *jb | |||
09/01/2097 | |||
Design of exhaust manifold is defective. *ak | |||
04/28/2001 | 1 | 06/01/2000 | |
Exhaust manifold bolts broken off in engine causing a serious exhaust leak. was quoted $1,100 min. to fix it at manteca ford. later found out that there is a hidden manufactuers warranty on this defective part and neither manteca ford or ford motor will acknowledge this or help with the liablity of the repairs that were done. i have contacted others who have had the same problem and they were taken care of or ignored like i was. i think there should be a recall on these bolts and all engines should be repaired. these are family vehicles that alot of us work hard and rely on these vans to get our children around and ourselves to work. what happened to truth and honesty?*ak |