Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
TSB9711002 | 02/01/1997 | 52060 | New valve lash adjuster noise checking and troubleshooting procedures. *jd | 07/17/1997 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
TSB9613021 | 11/01/1996 | 50610 | Revised heated oxygen sensor heater resistance - service manual revision. *tw | 05/27/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
1 | |||
Engine temperature gauge failed. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
08/08/2005 | 1 | 04/24/1996 | |
Pursuant to the ball joint recall for my 1994 mitsubishi galant, i took my car to ourisman mitsubishi in 2004 who then inspected the boot, noticed the boot was broken yet the serviceman resealed the boot and informed me that the car was checked and the lower control arms were intact. in august 2005, while i was having my car service for a water pump problem, the mechanic indicated that the lower ball joint was defective and that i needed to have it replaced. *jb | |||
04/20/2004 | 1 | ||
While driving at any speed vehicle overheated, dealership urged consumer to call nhtsa to report the problem. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
06/25/2003 | 1 | 10/20/2001 | |
The harmonic balancer suddendly broke one day as i was driving to work.the mitsubishi dealer said that it seemed to be a very commom occurance and complaint and therefore had many parts in stock. seems to me that if they have to stock a lot of these parts then maybe a better look at the manufacturing of them should be taken. | |||
04/12/2002 | 3 | 01/01/2096 | |
This is the 3rd time the harmonic balancer has broken and caused the lower pulley to become disengaged from the engine causing a loss of engine power. dealers & service stations identify this as a common problem but the manufacturer does not identify it and has no record of how many times this has occured. the manufacturer refuses to cover the cost of repair. *ak | |||
07/10/2001 | 1 | 07/01/1996 | |
Consumer was traveling on highway, and vehicle shutdown without prior warning. vehicle was towed to dealership. *ak timing crank sensor original part was larger than should have been. which caused damaged to the crankshaft.*yd | |||
07/17/2000 | |||
Consumer was pulling out of driveway and heard a poppying noise/ smelled smoke. her husband looked underneath vehicle and noticed that belt had popped out. she drove vehicle to dealership, and mechanic told her that pulley/crankshaft came apart. they replaced the part, then one week later the same problem happened again. currently, she heared a pingging noise.*ak | |||
Engine pulley: crankshaft;the outer ring which holds the alternator and air conditioner belt has separated, causing the belt to come off, resulting in ring flying around freely, and causing a very loud noise. consumer has contacted dealer. please provide any further details. *ak | |||
07/18/1999 | 2 | 02/01/1996 | |
When driving about 30-35 mph, lower engine pulley came loose, causing the belt to come off. vehicle became very tough to steer at this time. the problem is being corrected by dealership at owner's expense. owner expereinced the same problem in july of 1996. *ak *ml | |||
09/28/1998 | 5 | 06/01/1993 | |
Main engine rear seal failed/driver's seat belt does not lock/all lights dim or get brighter due to electrical failure/front end suspension bushing failed/when using keyless entry system, all doors will unlock and the relock by themselves. | |||
12/31/1994 | 1 | ||
Tension pulley failed. *sd | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
10/08/2002 | 1 | 11/01/2001 | |
While driving the vehicle stalled, the dealer replaced the cap, rotor, plug wires and dist seal. *yh | |||
05/20/1997 | 1 | 10/01/1993 | |
Engine overheated. yh | |||
07/10/1998 | 1 | ||
Engine failure causing fire. ohio state police report. | |||
04/14/1996 | 4 | ||
Engine stalls. *dsh | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
08/01/1999 | 70000 | 12 | 12/01/1998 |
I bought my 94 mitsubishi galant in december of 1998. the first time my alternator belt broke was august of 1999. since then my belt has been replaced 12 times (7 times the belt was replaced by a mechanic). most of the time, my husband or myself have been driving when the belt brakes leaving us stranded on the side of the road. the belt also squeaks really bad. i've tried to get this problem fixed, but no one seems to know what is causing it to squeak. i've had alternator's replaced, belts replaced, and the pulley adjusted. none of it worked, but i still had to pay for it. please help me.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
Electrical panel on the driver door is inoperable due to a malfunction within the assembly, also a continuous smell of smoke occurs while the vehicle is being driven. please give any further details.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
12/16/1995 | 6 | ||
Egr valve failed. |