Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
10012002 | 10/01/2002 | 10014398 | Engine stalling hesitation. *eh | 05/02/2005 | |
0413011 | 04/01/2005 | 0513009 | 10010660 | Power train module reprogramming for dianostic trouble code p0125. *eh | 12/03/2004 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
TSB0112001 | 03/01/2001 | 619838 | This bulletin contains a corrected illustration for the engine oil cooler. *tt | 07/02/2001 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
0313001 | 01/01/2003 | 10001033 | Powertrain control module (pcm) reprogramming for malfunction indicator lamp (mil) (service engine soon) on with diagnostic trouble code (dtc) p0125. *tt | 04/11/2003 | |
TSB0111001 | 03/01/2001 | 619837 | This bulletin contains a refer to... page number reference which was omitted from the original manual's engine mechanical, on vehicle service section concerning valve lash adjuster bleeding. *tt | 07/02/2001 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
85 | 08/01/2002 | 636849 | Service review regarding tsb-02-11-004 - engine diesel noise at idle. *tt | 11/14/2002 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
0211004 | 07/01/2002 | 634745 | Subject regarding engine diesel noise at idle. *jg | 10/08/2002 | |
TSB0011006 | 07/01/2000 | 614010 | On some vehicles equipped with v6 engine produced before 2/9/00 (vin1j002592) , metal burrs in the front exhaust pipe could become loose and travel into the engine cylinders during engine operation. this may result in engine misire and | 09/26/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
12/24/2004 | 11000 | 20 | 12/12/2001 |
Since i purchase this vehicle (2001 mitsubishi montero limited), i always had problem with the check engine light problem. the third day i got the vehicle from the alhambra mitsubishi dealership, the light turn on. and always got the same reply make sure the gas cap is closed properly. i had 5 cars and i never had any kind of problem like exept this montero limited. my car has 63000miles right now, and the light will turn on every 2month. and now the vehicle has the light on again, and dealer will not do or care about the problem. this problem always happen when the car is going uphill or when it need power. also the brake light keep failing. *ak | |||
09/01/2004 | 70000 | 1 | |
Consumer stated that she had 70,000 miles on vehicle and the engine blew out. when driving the air would blow, then when stopping the air would stop. consumer took the vehicle to dealer, and was told that it looked as if the plastic tee in the heater line was busted. then, she was told that it may the thermostat that was sticking. the next day while driving the vehicle just stopped. had vehicle towed to the dealer, and mechanic determined that motor blew out. she had no warning, because the indicator never showed that the vehicle was running hot. *ak | |||
2 | |||
Engine stalls constantly when coming to stops.also, steering wheel locks up when turning in any direction. as a result, consumer was almost in an accident.*ak | |||
09/12/2003 | 5 | ||
When driving for over an hour vehicle stalled without warning. driver pulled off the road. had the vehicle towed to the dealer on five separate occasions, but problem still recurred.*ak | |||
11/12/2002 | |||
Without warning consumers vehicle will shut off. ts | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
01/25/2011 | 152989 | ||
Malfunction indicator lamp (mil) illuminates when towing, on steep grades, or even continuously. diagnostic trouble code (dtc) p0125 is displayed indicating insufficient coolant temperature, even though actual coolant temperature is within normal range of 200 to 215 degrees. replacement of coolant temperature sensors (2) and thermostat will not rectify this problem! this is a known computer error that mitsubishi motors north america will not address or pay for the repair of. nhtsa item number: 10001033 mmna technical service bulletin: 0313001 | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
02/05/2003 | 46500 | 1 | 11/16/2000 |
Compressor went out while driving vehicle, still under 50,000 miles. i can't use heat, or air conditioning. *jb | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
While driving the vehicle on the hwy at 65mph suddenly the vehicle dropped the speed from 65 to 30 causing rapid loss of speed, consumer pull off the road, dealer has inspected the vehicle found the radiator is broke, transmission problem as well problem with the engine. as i mentioned there are two recalls #1 nhtsa 01-v-254-001 on 7/30/2001 about brake booster #2 nhtsa 00-v-123-002 on 03/28/01 about rear view mirror. please call the manufacturer at 800-222-0037 see if your vehicle apply for those recall. ts | |||
1 | 01/01/2001 | ||
Consumer took the vehicle to the dealer regarding radiator replacement due to recall notice. consumer was told by the dealer advisor that the radiator was inspected and if its not leaking on inspection it would not be replaced. *yh | |||
10/27/2001 | |||
Radiator was broken inside and coolant went into transmission. contacted dealer, and dealer stated transmission had to be replaced.*ak | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
04/23/2008 | 95000 | ||
Tl*the contact owns a 2001 mitsubishi montero. the contact took the vehicle to a local dealer for routine maintenance. months later, he took the vehicle to a different repair shop for an oil change and was advised that the former dealer did not reinstall the heat cover. without the heat cover, there is no safeguard to the various hoses and components in the engine, which has several potential safety implications. he called the dealer again and was advised by the manager, tom wanster, that his heat cover was not left there; however, they did locate other heat covers for similar models. the manager would not provide him with any assistance. the contact filed a complaint with the federal trade commission. the failure mileage was 95,000 and current mileage was 102,268. | |||
07/10/2006 | 45000 | 15 | 01/10/2006 |
Montero under 50,000 miles. have to replace compressor, alignment bars for sun roof, and brakes. cost $2700 with labor. have owned the vehicle for 4 months. no warranty left. montero has to be jumped to turn on, bucks with defrost on, no air, no radio, and brakes are bad. dealer will not help with cost. *nm | |||
11/10/2004 | 90000 | 1 | 08/26/2003 |
2001 mitsubishi montero; engine shot on the highway (nj turnpike). there was no oil warning. this is a life threatening issue-if i had been on the inner lane, i would have been dead. vehicles on nj turnpike are traveling 60-80mph. vehicle has been serviced on timely oil changes at jiffy lube. this should not have happened. it has 90k mlies on it, bought used, i owe $15k on it, it will cost $8k to fix. 2 yrs og payments to go.*ak | |||
08/29/2004 | 72000 | 1 | |
Engine replacement at 79k miles. february 04 i noticed a knocking sound coming from under the hood of the car. the mitsubishi mechanic said it was coming from the engine but that he would just change the oil to see if that helped. the sales ticket said, no problem found. august 04 the knocking came back. on a trip the oil light came on but there was oil in the vehicle. we had the vehicle towed to mitsubishi. the mechanic then confirmed that it was the engine. the pickup tube was clocked but the engine walls were clean. the result was to replace the engine. mitsubishi would not cover the charges because it was pass the warranty mileage. no one can determine how the pickup tube was clogged with so much crud. however, mitsubishi says that it does not matter if it was a defect in the pickup tube it was past the warranty.*ak | |||
10/01/2001 | 33872 | 1 | 10/01/2001 |
Engine noise. *ak | |||
12/15/2002 | 37000 | 1 | 06/01/2000 |
The oil light indicator failed to warn that the oil in the engine was depleted until approx 30 seconds prior to the engine seizing. the rods cracked the engine and broke the head gasket mixing oil and water together. everything shut down in seconds. no warning whatsoever. dimsii ivoq entry posted after 12/12/02 cut-over to artemis-------770762. *ak *nlm | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
07/31/2001 | 4 | 05/11/2001 | |
The check engine light has illuminated on three occasions, the dealer replaced the purge control valve. nlm | |||
07/01/2001 | |||
Consumer was traveling at about 30-40 mph when tires locked up, and vehicle became undriveable. there was also an engine part that broke off. has not contacted dealer. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
06/26/2003 | 45000 | 2 | 01/02/2001 |
Pcm reprogramming for mil on/dtc po125. incorrect pcm software parameters cause the mil(service engine soon) light to come on and diagnostic trouble code po125 to test to set. to eliminate this condition, reprograming the pcm is needed.after the reprograming the pcm, oxygen sensors on 2001 models only need to be replaced and not covered by warranty.oxygen sensors need to be replaced to meet new parameters, not because the sensors are bad. mitsubishi states these modiflcations have been approved as appropriate by epa and carb. thanks in advance for your help. robert s duke. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
01/15/2006 | 3 | 02/08/2004 | |
I purchased a 2001 mitsubishi montero ltd from gibbons toyota in eynon, pa. i also purchased a warranty from them. my engine light comes on. they say sensors have to be changed. light came back on. changed another sensor, light came on. now they say it is the catalytic converter. they tell me it is covered by mitsubishi for 8 yrs. they try ertley motor world numerous times and cannot get them to respond. they are in wilkes-barre, pa. gibbons mgr then contacted domiano's in archbald. they to did not want to have anything to do with this. why is it that mitsubishi dealers will not stand behind their warranty's. this is the 4th mitsubishi i have owned, and now that i see the service, it will be the last. they are very ignorant people. they treat you like dirt. very arrogant. something should be done about this. there is an 8 yr warranty on the converter, and it should be changed with no hassle. thank you. this has been going on for the last 6 months. *jb | |||
07/26/2004 | 77000 | 3 | 01/08/2001 |
At 35000, the trunk door latch mechanism is broken. at 57000 miles check engine light lit, caused by spark plugs or spark plug wires open. replace all plugs and wires at dealership, cost $300.not covered by warranty. at 77000 miles, check engine light lit, dealership replaced catalytic converter under warranty but i pay for the oxygen sensor plus labor that goes with the catalyst.old parts not available. car driven about 3 miles home from dealeship after replacing the cat. converter, the check engine light lit again. dealership checked and said another oxygen sensor is bad. total 4 oxygen sensors in the system. cost $230 to replace one sensor. i could not believe that these sensors will go bad at the same time. is that a coinsidence or manufacturer parts defects???*ak |