National Rv Dolphin 2003

Model Dolphin made in 2003 by National Rv got 17 consumer complains as well as 1 recall. Consumer complaints with reference, among others things, to electrical system and fuel system, other. There was one recall concerning equipment .

Model 2003

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
EQUIPMENT - RECREATIONAL VEHICLE
07V230000NATIONAL RV, INC.from 01/01/1996 to 12/31/2003V (Vehicle)2132601/17/2008MFRNATIONAL RV, INC.06/04/200706/07/2007
Defect SummaryCertain motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence SummaryRelease of coolant under certain conditions could ignite and result in a fire.
Corrective SummaryNational rv will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist owners in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or national rv at 1-800-999-7260, ext. 4335. the national highway traffic safety administration (nhtsa), an agency of the united states department of transportation, has been notified that national rv, inc. and its holding company, national rv holdings, inc., have filed for bankruptcy. nhtsa has been advised that owners who wish to pursue claims related to safety recall repair work on their national rv vehicles may file a proof of claim with the united states bankruptcy court for the central district of california, riverside division. the case number assigned to this matter is 07-17941. the proof of claim form and instructions are available online at the court's website www.cacb.uscourts.gov. additional information about the bankruptcy and its proceedings may also be found at www.omnimgt.com/nationalrv. national rv's phone number is (951) 943-6007. information about safety recalls on national rv's products may be found at www.safercar.gov. the nhtsa wishes to advise owners of recalled products that, in the interests of their safety and the safety of the motoring public, all safety recall work should be performed on motor vehicles and items of equipment.
NotesCustomers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Consumer Complaints


Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM - WIRING
03/03/2003587311/30/2002
 The pcm/tcm fuse blew when accelerating at low speeds. this caused engine failure, which resulted in the vehicle stalling while driving. dealership replaced the fuse 3 times, but the problem continued. the cause of the failure was undetermined. *ak incident was traced to a chaffed wire on a metal clamp within engine compartment. *ph *jb
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD
04/23/20033070102/13/2003
 While driving 40 mph consumer noticed smoke coming from engine compartment. the fire was put out by consumer. the amount of damage and cause had not been determined. *ak *jb
FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS
01/15/2007370001
 Tl* - the contact stated that the fuel line on the 2003 dolphin lx motor home started leaking gas above the fuel tank. the contact has the fuel tank and the repair invoices. the contact also had the fuel tank with the cracks in it. *ak updated 02/22/07.*jb
POWER TRAIN - AUTOMATIC TRANSMISSION
04/23/20033073102/13/2003
 While traveling at highway speed without any indication vehicle caught on fire. *ak the vehicle was nine weeks old when the vehicle caught on fire. the source of the fire was a flammable fluid. there was a liquid trail about one foot wide and 100 yards long on the road which lead up to the motorhome. it was difficult to determine the exact cause of the fire. the failure was narrowed down to either the transmission or the brake line. *scc *nlm
SERVICE BRAKES, AIR
07/01/200515000207/01/2003
 Tl*the contact owns a 2003 national rv dolphin. while driving 35 mph, the vehicle pulled to the right. the dealer stated that the passenger side front brake was not releasing. both front brakes were replaced. while driving 50 mph, the brake pedal extended to the floor when depressed. the emergency brake was applied to stop the vehicle. the dealer replaced the rear brakes because the calipers overheated and became stuck. the brakes were less than 20% worn. the failure mileage was 15,000 and current mileage was 32,000.
SERVICE BRAKES, HYDRAULIC
05/18/201040000
 Tl-the contact owns a 2003 national dolphin motor home. the contact was having problems with his brakes and he took the vehicle to a mechanic shop who repaired the brake rotors, the brake pads and the seals at a cost to him. he received a recall notice on the caliper from workhorse but the brake rotors, brake pads and the seals have failed again. the dealer only wants to repair the caliper but not the brake system he was told he has to pay to repair the failure again. the dealer contacted workhorse and is waiting on an answer on how to proceed. the manufacturer was not notified. the failure mileage was 40,000...mw
07/12/200515000
 Tl*the contact owns a 2003 national dolphin rv. the vehicle has been experiencing brake failure ever since it was purchased. the dealer repaired the front brakes under warranty. the rear brakes were also repaired. the contact received a recall notice for the brakes, but the dealer stated that his vehicle was excluded from the recall repair since the repairs were previously performed. the nhtsa campaign id number was unknown. the failure mileage was 15,000 and current mileage was 50,000.
08/14/2007236401
 Mileage: 23640 brakes on my rv (workhorse w22 2003 chasis) locked up, overheated, and dash abs warning light came on. replaced left front and rear wheel sensors. mileage: 23765 date:11-7-07 - brakes again locked up, overheated, and abs warning light came on. replaced abs control module, wheel sensors, front hub seals, front brake pads, flush brake system, add new fluid, & bleed system. mileage:31990 date:10-15-08 - front brakes dragging, overheated, abs warning light came on. replace front rotors, calipers, hub seals, pads, wheel sensors, flush, replace fluid, and bleed brake system. mileage:33052 date: 10-30-08 - front brakes dragging, overheating, abs warning light came on. front brakes checked & had no damage. replaced wheel sensor, cleared code, checked system,etc. *tr
SERVICE BRAKES, HYDRAULIC - ANTILOCK
01/05/20043
 While driving at any speed brakes overheated, and it took longer to stop. dealer replaced brake pads/speedometer, and windshield wiper motor.*ak
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS
01/05/20043
 While driving at any speed brakes overheated, and it took longer to stop. dealer replaced brake pads/speedometer, and windshield wiper motor.*ak
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS
04/23/20033073102/13/2003
 While traveling at highway speed without any indication vehicle caught on fire. *ak the vehicle was nine weeks old when the vehicle caught on fire. the source of the fire was a flammable fluid. there was a liquid trail about one foot wide and 100 yards long on the road which lead up to the motorhome. it was difficult to determine the exact cause of the fire. the failure was narrowed down to either the transmission or the brake line. *scc *nlm
STRUCTURE
06/17/20032364506/17/2003
 The consumer indicated that due to the angle of the front windshield, sun light reflected on the windshield which caused a glare in the exterior rear view mirror. this resulted in poor or no visibility. *ak *sc *jb
VEHICLE SPEED CONTROL
01/05/20043
 While driving at any speed brakes overheated, and it took longer to stop. dealer replaced brake pads/speedometer, and windshield wiper motor.*ak
VISIBILITY - WINDSHIELD WIPER/WASHER - MOTOR
01/05/20043
 While driving at any speed brakes overheated, and it took longer to stop. dealer replaced brake pads/speedometer, and windshield wiper motor.*ak

Car dealers selling


StateCityZipNamePhone
CACORONA92880GIANT INLAND EMPIRE CENTER
CASAN BERNADINO92324GIANT RV
FLSEFFNER33584LAZY DAY RV813 246 4555
FLSEFFNER33584LAZY DAYS800-626-7800
FLSEFFNER33584LAZY DAY'S RV CENTER, INC