Neoplan An440 1995
Model An440 made in 1995 by Neoplan got 3 consumer complains as well as 4 recalls. Consumer complaints with reference to engine and engine cooling. . There was one recall concerning fuel system, other .
Model 1995
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
98V298000 | NEOPLAN USA CORP. | from 05/18/1995 to 11/06/1997 | V (Vehicle) | 594 | 11/30/1998 | ODI | NEOPLAN USA CORPORATION | 11/19/1998 | 11/24/1998 | |||||||
Defect Summary | Vehicle description: transit coaches equipped with cummins l-10 engines and nelson catalysts and sold to los angeles, california transit authority. the catalyst can experience high temperatures, which could be caused from unburned methane igniting inside the catalyst brick. | |||||||||||||||
Consequence Summary | This condition can result in extreme overheating of the catalyst and could cause ignition of surrounding combustibles in close proximity to the catalyst. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicles for proper installation and positioning; increase the size of the fiberglass hole surrounding the tail pipe, remove a rubber air inlet boot that was too close to the catalyst; replace the flex pipe in the exhaust system; and add a blanket around the catalyst to provide added insulation. | |||||||||||||||
Notes | Owner notification has began. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact neoplan at 1-719-336-3256.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | ||||||||||||||||
96V183000 | NEOPLAN USA CORP. | V (Vehicle) | 235 | 09/19/1996 | ODI | NEOPLAN USA CORPORATION | 09/23/1996 | 10/01/1996 | ||||||||
Defect Summary | The type 4 compressed natural gas (cng) fuel tank supplied by edo canada can rupture during fueling. | |||||||||||||||
Consequence Summary | Rupture of a cng fuel tank can cause cng leakage increasing the risk of a fire or explosion. | |||||||||||||||
Corrective Summary | Each tank is being visually inspected, assisted by dye penetrant and resonance tested. a detection shield is placed under each pair of tanks, under the bus, to provide ease of inspection for any damage. any damaged tank will be replaced. | |||||||||||||||
Notes | Owner notification:owner notification has already begun. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact neoplan at 1-719-336-3256.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
96V182000 | NEOPLAN USA CORP. | V (Vehicle) | 202 | 09/30/1996 | ODI | NEOPLAN USA CORPORATION | 09/23/1996 | 10/01/1996 | ||||||||
Defect Summary | These buses are equipped with compressed natural gas fuel tanks supplied by edo canada. the fuel cylinder straps expand when tanks are pressurized causing brackets to break the mounting hardware. | |||||||||||||||
Consequence Summary | This condition can cause the cylinder to fall increasing the risk of explosion or fire. | |||||||||||||||
Corrective Summary | A new strap with elastomeric springs that will allow the strap to expand with the tank has been designed and will be installed on these buses. | |||||||||||||||
Notes | Owner notification:owner notification has been started.only los angeles and massport transit systems are involved.note:owners who do not receive the newly designed straps within a reasonable time free of charge should contact edo canada at .................. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
95V188001 | NEOPLAN USA CORP. | from 06/01/1992 to 07/01/1994 | V (Vehicle) | 101 | 12/15/1995 | ODI | NEOPLAN USA CORPORATION | 08/30/1995 | 04/19/1996 | |||||||
Defect Summary | Some temperature sensitive triggers were not x-rayed. these triggers could contain internal voids that would make the triggers susceptible to advanced creep causing false activation and venting of the cng. | |||||||||||||||
Consequence Summary | Venting of the cng could result in a fire. | |||||||||||||||
Corrective Summary | Neoplan will replace the prd with the newer design generation 2.5 pressure relief device. | |||||||||||||||
Notes | System: fuel; cng; pressure relief valves/devices (prd).vehicle description: compressed natural gas powered transit buses equipped with lincoln composite cng fuel containers which incorporate mirada type iiipressure relief valves. (see mirada campaign 95e025 and lincoln composite campaign 95e025003).note: if the valves have not been replaced within a reasonable time free of charge, please contact neoplan at 1-719-336-3256.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
08/01/1996 | 1 | 12/01/1995 | |
Extreme exothermic reaction in exhaust catalyst generated sufficient localized temperatures to ignite surrounding material, resulting in fire and damage to rear portion of transit bus. | |||
1 | 05/01/1995 | ||
Extreme exothermic reaction in exhaust catalyst generated suficient lacalized temperatures to ignite surrounding material, resulting in fire and damage to rear portion of transit bus. |