Neoplan An440 1996
Model An440 made in 1996 by Neoplan got 1 consumer complain there is 1 investigation as well as 1 recall. Consumer complaints with reference to engine and engine cooling. . The car had one investigation (vehicle speed control). There was one recall concerning fuel system, other .
Model 1996
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
98V298000 | NEOPLAN USA CORP. | from 05/18/1995 to 11/06/1997 | V (Vehicle) | 594 | 11/30/1998 | ODI | NEOPLAN USA CORPORATION | 11/19/1998 | 11/24/1998 | |||||||
Defect Summary | Vehicle description: transit coaches equipped with cummins l-10 engines and nelson catalysts and sold to los angeles, california transit authority. the catalyst can experience high temperatures, which could be caused from unburned methane igniting inside the catalyst brick. | |||||||||||||||
Consequence Summary | This condition can result in extreme overheating of the catalyst and could cause ignition of surrounding combustibles in close proximity to the catalyst. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicles for proper installation and positioning; increase the size of the fiberglass hole surrounding the tail pipe, remove a rubber air inlet boot that was too close to the catalyst; replace the flex pipe in the exhaust system; and add a blanket around the catalyst to provide added insulation. | |||||||||||||||
Notes | Owner notification has began. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact neoplan at 1-719-336-3256.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
VEHICLE SPEED CONTROL - LINKAGES | ||||||
PE96054 | NEOPLAN USA CORPORATION | 09/03/1996 | 09/26/1996 | CNG FUEL TANK EXPLOSION | 96V183000 | |
Nhtsa received calls from both neoplan and the federal transit administration reporting the explosion of a fuel tank on a cng powered transit bus.no fire or injuries were reported. the explosion occurred during refueling.the fuel tanks used on the subject buses are carbon composite graphite, manufactured by edo canada, ltd.the los angeles mta has grounded it fleet until the cause of the problem can be determined and corrected. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
12/01/1997 | 1 | 08/01/1996 | |
Extreme exothermic reaction in exhaust catalyst generated sufficient localized temperature to ignite surrounding material, resulting in fire and damage to the rear portion of the transit bus. |