New Flyer C30lf 2001

Model C30lf made in 2001 by New Flyer got 2 recalls as well as 1 service bulletin. Technical service bulletines regarding power train. There were some recalls concerningengine and engine cooling and exterior lighting.

Model 2001

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ENGINE AND ENGINE COOLING - ENGINE - DIESEL
03V182000NEW FLYER INDUSTRIES LIMITEDfrom 01/01/2001 to 05/16/2003V (Vehicle)497MFRNEW FLYER OF AMERICA, INC.05/16/200305/21/2003
Defect SummaryOn certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.
Consequence SummaryIf this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.
Corrective SummaryDealers will replace the electronic control module calibration free of charge. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center at 1-800-343-7357 or new flyer at 204-934-4882.
NotesAlso, customers can contact the national highway traffic safety administration
EXTERIOR LIGHTING
07V068000NEW FLYER INDUSTRIES LTDfrom 01/01/2001 to 12/31/2002V (Vehicle)170703/17/2007MFRNEW FLYER INDUSTRIES LTD02/23/200702/27/2007571108
Defect SummaryCertain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps reflective devices, and associated equipment. the flashing deceleration lamps were an optional item for some of these buses.
Consequence SummaryThe standard requires that the deceleration lamp is a solid light rather than a flashing light.
Corrective SummaryDealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. the recall began on march 5, 2007. owners may contact new flyer at 204-934-4874.
NotesCustomers may contact the national highway traffic safety administration1s vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
POWER TRAIN - MANUAL TRANSMISSION
SMB-11109/16/201110041671New flyer: service manual regarding changes of installation on output yoke of allison transmission. *pe10/24/2011