Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| POWER TRAIN - CLUTCH ASSEMBLY | ||||||||||||||||
| 11E024000 | ZF SALES & SERVICE NORTH AMERICA, LLC | E (Equipment) | 199 | MFR | NISSAN NORTH AMERICA, INC. | 06/24/2011 | 06/24/2011 | |||||||||
| Defect Summary | Zf service is recall certain clutch kit assemblies, part number sx: k70358-01, shipped to wholesalers as service parts between september 1, 2010, and march 8, 2011. these service parts are intended for use on model year 2003-2006 nissan 350z and infinity g35 vehicles. the sx: k70358-01 clutch kit contains an oversized clutch disc. | |||||||||||||||
| Consequence Summary | An oversized clutch disc could cause the vehicle to move unintentionally on the initial start-up, if the driver does not follow the installation instructions and fails to use the service brakes while the hand brake is not applied. unintentional movement of the vehicle could result in a crash or possible injury to persons outside the vehicle. | |||||||||||||||
| Corrective Summary | Zf service notify wholesalers to return any affected clutch kit assemblies still in inventory for free replacement kits. this condition will correct itself after the first start-up and usage of the clutch kit. however, if an owner is not satisfied with its performance, zf services will reimburse the owner for the cost of the replacement clutch kit and a reasonable amount for its installation. the safety recall is expected to begin during july 2011. owners may contact zf services at 1-800-321-0784 ext. 6748. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| NTB02075 | 07/17/2002 | 633681 | Subject regarding special automatic transmission fluid requirements. *jg | 09/23/2002 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 04065A | 11/09/2005 | 04065B | 10007899 | Clicking noise from rear axles. *mr *sc | 07/14/2004 |
| POWER TRAIN - MANUAL TRANSMISSION | |||||
| 02102 | 10/09/2002 | 10000207 | Manual transmission shift knob not straight. *tt | 02/19/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 10/03/2011 | 46000 | ||
| Tl* the contact owns a 2003 nissan 350z. the contact stated that the vehicle would exhibit an abnormal grinding when changing to third gear. the vehicle was taken to the dealer who diagnosed that the transmission was defective and needed to be replaced. the manufacturer was made aware of the failure who did not offer any assistance since the vehicle was no longer under warranty. the vehicle was repaired. the failure mileage was 46,000 and the current mileage was 47,000. | |||
| 10/03/2011 | 46000 | ||
| Tl - the contact owns a 2003 nissan 350z. the contact stated that the vehicle would exhibit an abnormal grinding when changing to third gear. the vehicle was taken to the dealer who diagnosed that the transmission was defective and needed to be replaced. the manufacturer was made aware of the failure who did not offer any assistance since the vehicle was no longer under warranty. the vehicle was repaired. the failure mileage was 46,000 and the current mileage was 47,000. kmj | |||
| 10/03/2011 | 46000 | ||
| Tl - the contact owns a 2003 nissan 350z. the contact stated that the vehicle would make a grinding noise when changing to third gear. the vehicle was taken to the dealer who diagnosed that the transmission was defective and needed to be replaced. the manufacturer was made aware of the failure who did not offered any assistance since the vehicle was no longer under warranty. the vehicle was repaired. the failure mileage was 46,000 and the current mileage was 47,000. pm | |||
| 12/01/2005 | 36000 | ||
| I own a 350z bought brand new in 2003. i was one of the 1st in baltimore for i did not see another z for six months. i have had a new transmission put in at 36k due to a failing 3rd gear synco and now at 80k the 5th. i am about to put in my 5th window motor in. nissan does not care about us so don't even waste your time with 1800nissan1. they should feel privileged that we allow japanese to sell cars here in the us and should be penalized when they fail. i will never ever buy a nissan again and i go as far as getting my nissan's oil changed at toyota so i do not promote nissan any further. quite a lemon. tacoma has 90k and only oil changes. | |||
| 03/01/2008 | 80000 | ||
| Tl*the contact owns a 2003 nissan 350z. while driving 40 mph, the vehicle loses speed whenever he shifts gears to accelerate. the engine revs, but the vehicle does not accelerate. the contact took the vehicle to the dealer numerous times, but they were unable to diagnose the cause of the failure. they have changed numerous sensors, the engine computer, and even the water pump of the vehicle. through online research, he discovered nhtsa campaign id number 03v455000 (engine and engine cooling); however, nissan stated that his vin was not included in the recall. he has been unable to drive the vehicle due to the lack of acceleration. the failure mileage was 80,000 and current mileage was approximately 81,000. | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 04/06/2006 | 73000 | 1 | 02/09/2006 |
| Bought a 2003 nissan 350z used from keyes nissan of woodland hills,ca. tiptronic (auto/semi-manual) transmission needed to be replaced within 45 days. now a whining noise that is still not fixed as well as excessive heat from shifter area that causes passengers to sweat & scalding hot to touch. car hasn't seemed to run right since. seems every 350z owner has the same atypical problems-tire feathering, transmissions replaced,rear axles, power window motors fail(the last 2 are my next trip to the dealer). nissan needs to fix our nightmare. nissan support is nonexistent as well,which makes your ordeal all the more miserable. *nm | |||
| 07/19/2005 | 3 | 10/30/2002 | |
| Dt: consumer owned a nissan 350z track version 2003. he took vehicle to dealer for recall repair about a year ago. consumer stated it was a recall, however, could not find recall on nhtsa web site. ntb03-046 was the number identifying the recall that consumer had. repair work was done on 6-11-04. then, on july 19, 2005 consumer took vehicle to gardena nissan in california, and they told him that the problem involved front tires wearing out on the inside during repair work they replaced the right front compression rod. consumer contacted nissan, and they told him that after recall and warranty repair work was only good for 10,000 miles. consumer believed that recall repairs did not fix problem, per gardena nissan. six months after consumer bought vehicle when shifting up or down at any speed periodically it will not go into gear. nissan was aware of the situation, and they did not want to do anything about it.*ak | |||
| 02/12/2004 | 2000 | 8 | 09/14/2002 |
| While driving automatic transmission doesn't shift properly from the third to the second gear. dealer inspected vehicle several times, and was not to duplicate but not correct the problem. *ak consumer began to notice inability to engage 2nd gear from 4th, and 3rd gear to 2nd regardless of the speed of the vehicle. it sometimes take consumer two or three attempts to engage transmission properly. *la | |||
| 05/07/2003 | 1 | ||
| While driving, the transmission failed. *jb | |||
| POWER TRAIN - CLUTCH ASSEMBLY | |||
| 04/30/2004 | 9000 | 1 | 08/27/2003 |
| I have had my car for 9000 miles and the clutch gave out. it was replaced by the dealer and the same problem happened a few months later.*ak | |||
| 12/13/2003 | 13800 | 2 | 05/16/2003 |
| The clutch failed. when this occurred vehicle was undriverable. upon inspection of the clutch by the dealership they noticed that it disintegrated. the clutch was replaced but problem recurred within months. *ak *nm | |||
| 02/12/2004 | 6500 | 2 | 12/14/2002 |
| Nissan 350z clutch failure, 2nd time in first year of ownership. after much haggling, nissan replaced the clutch at 6000 miles and it has just failed again at 13,000 miles. this is my third nissan, loyal customer. i have driven a manual transmission for 14 years and never replaced a clutch or transmission. this is a product defect that nissan is reluctant to acknowledge. there are hundreds of similar complaints on the internet.*ak | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 09/27/2010 | 51000 | ||
| Transmission grind going in and out of 3rd gear. read all the reviews too late or never would have bought it. car is dangerous this way and with the hundreds of complaints nissan should be recalling and replacing the transmission. | |||
| 01/03/2010 | 70000 | ||
| Tl*the contact owns a 2003 nissan 350z. the contact stated that while the vehicle was in third gear, he experienced manual transmission failure. it only failed when the vehicle was shifted into third gear or when shifted down to second gear. the vehicle was taken to an authorized dealership at the time of the complaint. the failure mileage was approximately 70,000. the current mileage was approximately 80,000. | |||
| 05/25/2009 | 99300 | 1 | |
| I am wondering, why is there not a recall on the 2003 nissan 350z transmission? there has been more than enough complaints on this years transmission. it is very dangerous to drive, because the transmission locks out of gear. i cannot even put it into 1st gear on a dead stop and sometimes while driving it won't even shift into gear. i feel very uncomfortable being on the road and feel for my safety and other drivers on the road. i have done some research on this 2003 nissan 350z year and model; and multiple complaints, and i feel more than enough to get a recall. people just don't know where to go to report this problem. i just stumbled upon this myself. this is the only car i have to drive to work and school, and everytime i get in it, i feel unsafe and ask myself when is it going to lock up on me again? for a $30,000.00 +, i feel nissan owes us the right to have a car that is safe and drivable for many years to come. please help me, what can i do to help you guys help all the owners of the 2003 350z 's feel that they have a reliable, dependable and especially safe car. today, i was heading to the store to grocery shop, i could not shift into first or second gear at a light, and had multiple cars behind me. i started to panic, because they were all honking, so i turned off the car. the cars that went around me threw the bird at me and some belittled me with some curse words. it was shameful and embarrassing. so i told myself i had to do something about this, so i called friends for support, and they told me that this was an ongoing problem for the 2003 nissan 350z. the transmission is a big problem. either grinding going into gear or locking out of gear. so then i ask myself, who do i turn to? and i found you guys after hours of researching. i need your help. we need this years transmission to be recalled, because it is dangerous for us as the driver, and all the other people on the roads. nissan needs to step up to the plate and fix this problem,they know its there. *tr | |||
| 02/28/2008 | 40000 | 1 | |
| Grinding getting into 2nd and 3rd from 3k rpm to 6k rpm. no problem if under 3k rpm but i was under the impression i was purchasing a sports car. i've had the car for 15k miles bough used with 40k on it but after warranty had expired. i am waiting to save for the cd009 transmission so i can replace with the upgrade and do the clutch all at once. thanks nissan! *tr | |||
| 01/15/2009 | 38000 | 1 | |
| Shifting from 2nd gear - 3rd gear there is always a grind and i've searched on the internet and this needs to be a recall due to all the complaints that have been said on various websites. *tr | |||
| 08/01/2008 | 98000 | 1 | |
| Transmission problems-grinding between 3rd and 4th gear sometimes in 5th when clutch fully engaged. dealership stated to change flywheel and clutch. after about $1300 repairs, grinding still exists and nissan unwilling to replace transmission. *tr | |||
| 06/17/2007 | 35000 | 1 | |
| The 3rd gear was grinding then second started to grind too therefore i had the transmission rebuilt at my expense and other transmission problems persist and also have the tire feathering/tire growl issue which i've took the car varies times to the alignment shop. *tr | |||
| 11/15/2007 | 1 | ||
| Manual transmission makes loud grinding noise when shifting between 2nd gear and 3rd gear. *tr | |||
| 09/29/2008 | 17000 | 1 | 11/14/2002 |
| Tl*the contact owns a 2003 nissan 350z. the contact purchased the vehicle only for long distance driving. as soon as she began driving the vehicle, she smelled rubber inside the passenger compartment. the dealer stated that the smell would dissipate and was present because the vehicle was new; however, the odor remained. while driving 60 mph, the vehicle would not shift from second into third gear. the failure occurred without warning. the vehicle coasted to the side of the road and was towed to the dealer. the dealer stated that the clutch and the fly wheel were burnt. the contact called nissan customer service to assist with the cost because it was no longer under warranty; however, they denied her claim. she wants nissan to assist with the $2,300 repair cost. the failure mileage was 17,000. updated 11/7/08 *cn updated 11/13/08. *jb | |||
| 04/06/2006 | 73000 | 1 | 02/09/2006 |
| Bought a 2003 nissan 350z used from keyes nissan of woodland hills,ca. tiptronic (auto/semi-manual) transmission needed to be replaced within 45 days. now a whining noise that is still not fixed as well as excessive heat from shifter area that causes passengers to sweat & scalding hot to touch. car hasn't seemed to run right since. seems every 350z owner has the same atypical problems-tire feathering, transmissions replaced,rear axles, power window motors fail(the last 2 are my next trip to the dealer). nissan needs to fix our nightmare. nissan support is nonexistent as well,which makes your ordeal all the more miserable. *nm | |||
| 08/02/2006 | 19000 | 1 | 08/22/2005 |
| I have a 2003 nissan 350z and i'm having problems with grinding when i shift into 3rd gear(manual) i have only 20k miles on my stock car no major modifications done. i have taken it to nissan and they tried to duplicate the problem but nothing was found and when they told me to drive it i found my car shifting like butter i was amazed on how smooth it was. after a few days the problem is back like it was temporarily fixed or something because it gradually started getting to where it was before i took it in. now i don't know if i should take it back or am i stuck. i have done some talking with other z owners on a well known message board and over the years hundreds have got their transmission replaced and hundreds haven't depending on dealerships. *nm | |||
| 02/12/2006 | 45000 | 30 | 01/05/2005 |
| When up shifting to 5th gear the transmission will grind at higher rpm's. also have some issues with the transmission catching as shifting in other gears, have to press hard to get it into gear at times. *jb | |||
| 12/06/2004 | 21995 | 2 | |
| Purchased a brand new 2003 350z clutch blew at 9000 miles 11000 miles later clutch go's again this is not just the clutch its the transmission which makes this a horrible problem which means this is probally a lemon i recommend no 1 to purchase a 350z manual u must get automatic | |||
| 12/04/2004 | 20000 | 2 | |
| The consumer experienced transmission problems. when driving in 5th gear, he was unable to change gears. approximately 500 miles ago, the vehicles third gear blew out while driving. *jb | |||
| 10/08/2003 | 8000 | 1 | 10/07/2003 |
| 350z manual transmission howls when the car is first started. the car displays the condition when it has sat overnight and when it idles out of gear without the clutch depressed. *la | |||
| 11/04/2003 | 4 | ||
| Various things gone wrong with this car: -rack and pinion / steering pump failed at 4000 miles. car refused to steer when at idle. very dangerous. replaced under warranty after 2 weeks. -two transmission replacements. second transmission replacement requires new flywheel, clutch disc, and pressure plate. both under warranty. -uneven tire wear. dealer told me that i'm a young speed racer and that i need to slow down. denied my appeal for new tires, i bought new, wider rims and tires, alignment, and problem went away. tire sizes are 245/40/18 and 275/40/18. bridgestone potenza s03. no feathering after 11000 miles. unfortunately, this car is not very safe... and nissan service / customer service is very uncourteous and rude in their approach to the situation at hand. *la | |||
| 08/27/2003 | 1 | 03/13/2003 | |
| Transmission problem with my 2003 nissan 350z. 3rd gear synchronizers are defective. did a research and found hundred of other brand new 350z's having the same problem. recall must be done.*ak | |||
| 4000 | 2 | ||
| There is a hesitation when shifting into third gear, and when it goes into gear, there is a grinding noise. dealership replaced the manual transmission, but the problem recurred 5000 miles later,and needed to be replaced again.*ak | |||
| 06/27/2003 | 10000 | 1 | 12/24/2002 |
| 3rd gear grinds and transmission noises. i have spoken with over 200 people with the same problem. dealer refuses to warranty problem due to aftermarket parts.*ak | |||
| 07/03/2003 | 4400 | 1 | 01/07/2003 |
| Transmission grind when going from 2nd to 3rd. *ak | |||