Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
709 | 09/01/2005 | 10018126 | Oil life system reset procedures - cars. gm tech link. *tt | 12/15/2005 | |
610 | 10/01/2004 | 10015768 | Engine idle flare when the clutch is depressed. also low speed engine decel stall when coming to a stop. gm tech link. *tt | 08/11/2005 | |
04092 | 11/01/2004 | 10014004 | Accelerator control system. *eh | 04/27/2005 | |
050604002 | 01/01/2005 | 10013475 | Whistle noise on light acceleration. *eh | 04/19/2005 | |
030601018 | 07/01/2004 | 10012103 | New cylinder bore liner replacement procedure. this service bulletin replaces 030601018a. *eh | 02/11/2005 | |
3114 | 01/01/2004 | 10009973 | B1327 diagnostic missing. *sc | 11/02/2004 | |
030601010 | 03/01/2003 | 10001282 | Engine oil or coolant leak. *tt | 04/25/2003 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
071003 | 07/10/2003 | 10003815 | This vme message is a water pump replacement due to a known cam driveline. some customers may question about whine noise coming from the front engine area. *tt | 11/03/2003 | |
071503 | 07/15/2003 | 10003789 | Coolant lose, evidence fluid on the garage floor, etc., or coolant warning light coming on. *tt | 10/31/2003 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
031203 | 03/12/2003 | 10001909 | Buffeting or rotational type tick noise from hvac blower motor area. *tt *jb | 07/25/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4495C | 03/01/2011 | 10038510 | Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm | 06/16/2011 | |
PIP-4495C | 03/01/2011 | 10038510 | Ready | 06/16/2011 | |
PIC-5405 | 12/01/2010 | 10037814 | Ready | 06/06/2011 | |
PIC-5405 | 12/01/2010 | 10037814 | Gm: the engine will not start. the engine cranks and sounds like it's going to start but then stops cranking. *rm | 06/06/2011 | |
3859 | 3859A | 10020923 | Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj | 01/30/2007 | |
3709 | 10019420 | Supplement to engine replacement instructions for part number 12607031. *tt | 03/14/2006 | ||
050604026 | 05/01/2005 | 050604026A | 10017407 | Vehicle hesitates, no start, lack of power, low fuel pressure. *tt | 11/07/2005 |
3433 | 3433D | 10017032 | Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07. *kb | 10/20/2005 | |
0804 | 08/01/2004 | 10014346 | Oil life system reset procedures - cars. *nm | 04/29/2005 | |
030601022 | 01/01/2004 | 030601022A | 10011117 | Guidelines for cylinder bore liner/piston sleeve replacement on the l4 ecotec engine. *tt | 01/03/2005 |
040604063 | 09/01/2004 | 10011046 | Engine idle flair when clutch depressed or decel stall. *tt | 12/27/2004 | |
3014 | 01/01/2004 | 10008776 | Stall, hesitation, stumble with no diagnostic trouble codes (dtcs). *tt | 08/23/2004 | |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
00434 | 01/01/2004 | 00434A | 10007528 | Engine will crank but not start, also makes noise while cranking. 2.2 l61 engine. *tt | 06/30/2004 |
01995 | 01/01/2004 | 10007055 | Replacing a 02 or 03 2.2l l61 with a 04 2.2l l61 engine replacement.*mr | 05/25/2004 | |
03064 | 12/01/2003 | 10005744 | On-board diagnostic system software upgrade - obd system improvements. *tt | 03/12/2004 | |
01527 | 01/01/2004 | 10005464 | A whistle type noise coming from the engine. sit bulletin 1406534. *tt | 02/27/2004 | |
01525 | 01/01/2004 | 01525A | 10005461 | Engine stall hesitation stumble with no diagnostic trouble codes (dtcs). *tt | 02/27/2004 |
01556 | 01/01/2004 | 01556A | 10005396 | Engine cranks but does not run. *tt | 02/24/2004 |
03-06-01-010 | 04/01/2008 | 030601010C | 10004768 | Engine oil or coolant leak. *tt gm reminder. *tt install new lower intake manifold gasket. updated 7/18/08 *pe | 01/06/2004 |
071103 | 07/11/2003 | 10003816 | This vme message concerns a cylinder boreliner tool now available for the l61 2.2 liter engine. the tool is referenced in service bulletin 030601018. the purpose of the tool is to extend the total service life of the block. *tt | 11/03/2003 | |
052203 | 05/22/2003 | 10003658 | Complaints of intermittent vehicle shutting off while driving with no multiple codes set. the vehicle would immediately restart. the actual cause of this condition was that over bumps the mass and weight of the customer's key ring forces | 10/27/2003 | |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
030601018 | 06/01/2003 | 10002130 | New cylinder bore liner replacement procedure. *tt | 08/13/2003 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
02/09/2012 | 96000 | ||
Tl- the contact owns a 2003 oldsmobile alero. while traveling 65 mph, the vehicle stalled without warning. the vehicle was taken to the dealer where the fuel injector pump and cylinder were replaced however, the failure was not corrected. the current and failure mileages were 96,000. kmj | |||
02/09/2012 | 96000 | ||
Tl- the contact owns a 2003 oldsmobile alero. while traveling 65 mph the contact noticed that the vehicle had suddenly shut off without warning. the vehicle was taken to the dealership where the fuel injector pump and cylinder was replaced, however the contact is still experiencing the failure. the current and failure mileages were 96000. bml | |||
01/31/2011 | 3 | ||
2003 oldsmobile alero. consumer states vehicle stalled twice on the road while trying to make left turn. *tgw the consumer stated the second time the vehicle stalled, the steering wheel locked up and the vehicle would not restart. the dealer was unable to diagnose the problem on both occasions. | |||
06/27/2009 | 80000 | 1 | |
I used my horn to let someone know that they were in my lane, and all of a sudden my horn was stuck. the window clips on my car broke off, as i have read of these same complaints of other 2003 oldsmobile alero owners. i believe that there are serious defects of these two parts, and gm will not issue a recall to fix these problems. due to that fact, i am unable to pass inspection because my car has to have a working horn and my window must be able to move up and down. also a third complaint, there is now coolant that is starting to leak into my oil, which from what i understand could cause a fire!! *tr | |||
07/26/2003 | 20000 | 10 | 07/26/2003 |
The vehicle dies. while cruising at any speed, the hydraulic brakes & steering failed due to the engine dying. there is no set pattern, it might stall 6 times in one day, then twice the next day. then go 4 days with no ocurrence, then it will stall once a day for 3 days. then go a week with no ocurrence, then stall 4 times a day for 5 days, etc., etc. in every ocurrence, it takes approximately 10 minutes before it will start back up. at high speeds, it is extremely too dangerous to drive. we've taken it to the dealer, under extended warranty, the required 4 times under the lemon law process. the dealer cannot ascertain, nor fix the problem. it happened to the dealer at least once when we took it in. i doubt they will admit it, however, my wife was witness. the car is a 2003. even though i bought it in july 2003, it was considered a used car. gm has denied our claim since the lemon law does not apply to used cars. the car has been permanently parked since november 2003. we were forced to buy another car. the dealer would not trade. this has resulted in a badluck situation for us. we cannot afford 2 car payments / 2 insurance premiums, nor can we afford $300.00 per hour to sue gm. i stopped making payments in december 2003. i have kept the finance company abreast of the situation. they have not repossed as of yet. they want me to try to sell it. can you help ?*ak | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
05/10/2007 | 75000 | 1 | 10/31/2003 |
Our 2003 olds alero gl 4-dr with 3.4l v-6 and 75,000 miles had a blown intake gasket. we were having to add coolant to the car once every 2 months, but thought nothing of it and figured we had some kind of a leak in the reservoir. it began to make a rattling noise, which was when we took it to our car dealer. we were told that coolant has been leaking into the engine ,and will now have to spend $1300 to replace the gasket. there was no guarantee that this will fix the problem. *ak | |||
05/10/2003 | 750 | 3 | 02/28/2003 |
Automatic transmission failure at 750 miles. atained speed of 65mph for a few seconds then acted as if it slipped into neutral, i manually downshifted to 3rd gear at 45mph and proceeded to next safest place to stop. after stopped i shifted to d and then took off and it would not shift out of first gear. i stopped again and waited a few second then took off and it begain to shift normally again. i went directly to the dealer, they did a dianogstic test and it said nothing was wrong. problem has not happened since. at about 24,000 miles i noticed a pool of antifreeze on my garage floor and evidence of it leaking onto my front right drive shaft. i took it to the dealer they filled my antifreeze level back up and did a test and said they could not find a leak, they said it might of came out of the drain hole where it would normally leak when the bearing in the water pump goes out.... have not noticed any more leaks, sometimes smell burnt antifreeze. also at about 25,000 miles the numbers and letters on the buttons on the radio were becoming wore off, which seems way too early for that to happen.*ak | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
07/03/2009 | 43000 | 1 | |
Oldsmobile alero died while driving down the road. this has happened on several occasions. *tr | |||
08/19/2005 | 42925 | 1 | 01/25/2003 |
2003 alero ignition shorted causing consumer not be able to start vehicle, also found a leak in intake manifold gasket. *ts the passlock sensor in the ignition cylinder shorted and as a result the vehicle would not start. the intake gaskets and oil drive o-ring leaked. the dealer replaced the lower intake manifold gasket, rocker cover gaskets and oil pump driveshaft cover seal. the air bag cover warped. the top of the dash was wrinkled and the instrument panel pan was peeling from it's backing. the dealer replaced the instrument panel assembly and transferred all components. *nm | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
09/26/2008 | 58000 | ||
Tl*the contact owns a 2003 oldsmobile alero. the contact took the vehicle to a dealer for a tire rotation and was informed that coolant was leaking into the oil. the intake gasket and seals in the vehicle were replaced. the contact spoke with the manufacturer, who issued a case number. they stated that they could not assist. the current mileage was 58,184 and failure mileage was approximately 58,000. | |||
05/16/2005 | 04/08/2004 | ||
I was never told about this recall at all. i was on my computer and found out about the information. my son and i are co-owner of this car, and we have never been told about any recalls for the car. i use my car to take my grandchildren to school and i would like the problem fix. please help me | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
04/01/2008 | 95000 | 1 | 09/01/2004 |
My lower intake manifold is leaking just as is popular on these types of engines. also my turn signal is working off and on. i have sent letters to gm with no response or success. *tr |