Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
02V121000 | GENERAL MOTORS CORP. | from 09/01/2001 to 02/28/2002 | V (Vehicle) | 136511 | 09/20/2002 | ODI | GENERAL MOTORS CORP. | 08/23/2002 | 08/29/2002 | |||||||
Defect Summary | On certain sport utility vehicles, a fuel filter fitting can become disconnected. if this were to occur while attempting to start the engine, a no-start condition would result and fuel would be pumped out the fuel filter onto the ground. | |||||||||||||||
Consequence Summary | If the fitting becomes disconnected while the vehicle is in motion, the engine would stop due to inadequate fuel supply and cause a loss of power steering assist. if an ignition source were present, fuel leakage from a disconnected fuel filter fitting could result in a fire. | |||||||||||||||
Corrective Summary | Dealers will replace the fuel filter quick connect retainers. owner notification began september 20, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020. gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||||
02016 | 05/08/2002 | 636624 | Product safety recall 02016 regarding a condition where a fuel filter fitting may become disconnected. *tt | 11/10/2002 | |
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
07076 | 10/01/2008 | 07076A | 10026522 | Gm: special coverage adjustment - fuel tank modular reservoir assembly corrosion. csc letter was received. updated 11/6/08. *pe updated 5/5/09. csc letter was received. *pe | 11/04/2008 |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
PIT-3046E | 08/01/2008 | 10026704 | Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe | 12/04/2008 | |
3208 | 10/13/2006 | 3208C | 10010607 | 4wd inoperative and or erratic fuel gauge and or diagnostic trouble code's. *eh | 12/02/2004 |
3046A | 3046B | 10009382 | Fuel gauge fluctuation in park or neutral. *tt | 09/27/2004 | |
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
07076 | 10/01/2008 | 07076A | 10026522 | Gm: special coverage adjustment - fuel tank modular reservoir assembly corrosion. csc letter was received. updated 11/6/08. *pe updated 5/5/09. csc letter was received. *pe | 11/04/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | ||||||
EA07009 | GENERAL MOTORS CORP. | 07/10/2007 | 08/28/2008 | FUEL PUMP MODULE LEAKS GASOLINE | ||
During the course of this ea investigation, odi observed that the majority of the complaints (88%) and warranty claims (94%) were reported for vehicles that are registered for use in the salt belt region of the us.this area includes 20 states in the northeast, mid atlantic and the midwest regions and the district of columbia.consumers in the salt belt region reported to odi that they could smell fuel vapors in their vehicles while driving.upon further examination of their vehicles, they discovered that fuel vapors were coming out of the top of the fuel tank. this condition is caused by corrosion of the return and sender lines of the fuel pump module.water and road salt collect on top of the fuel pump leading to small pinholes appearing on the fuel lines.fuel may leak and collect on top of the module and/or spill onto the ground.the data evaluated under this investigation reflect a relatively low frequency of occurrence that largely arises in salt belt states.gm has extended the warranty on the subject component to ten years or 120,000 miles.further use of agency resources does not appear to be warranted at this time; accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.for additional information select document search. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
04/13/2007 | 71025 | 1 | 04/21/2001 |
Strong fuel odor inside vehicle after refuling, and after decelerating when climate control is on. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
10/17/2007 | 82365 | 1 | 11/14/2002 |
Fuel pump failure and gas leak. *tr | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
3 | |||
Suv failed to start. suv has been towed to dealership at least three times. at first. dealer wasn't able to find the problem. secondly, dealer found a cause which wasn't the actual problem, and thirdly, didn't perform any corrective actions. returned suv to owner. gmc representative stated they were only responsible for the suv while under warranty. please describe details. *ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
09/21/2009 | 71000 | ||
Tl* the contact owns a 2002 oldsmobile bravada. the gas tank leaks at the top of the sending unit because of corrosion. a technician from the dealer stated that the medal filling at the top of the sending unit was corroded. he then added that he was ineligible for a free remedy. the failure mileage was 71,000. | |||
FUEL SYSTEM, OTHER | |||
When driving fuel gauge reads that there is gas in vehicle, when in fact vehicle has no gas in it. took to dealer. problem has not resolved. please provide any further information. *ak |