Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| STEERING | ||||||||||||||||
| 09E005000 | DORMAN PRODUCTS, INC. | E (Equipment) | 979 | 02/23/2009 | MFR | GENERAL MOTORS CORP. | 02/17/2009 | 02/17/2009 | ||||||||
| Defect Summary | Dorman is recalling 979 steering knuckles, dorman p/nos. 697-902 and 697-903, sold under dorman's oe solutionstm brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. a potential material or design defect could result in the steering knuckle breaking in the hub area. | |||||||||||||||
| Consequence Summary | A broken steering knuckle could result in loss of steering control and a possible crash without warning. | |||||||||||||||
| Corrective Summary | Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. the recall began on february 23, 2009. owners may contact dorman's toll-free hotline at 1-800-523-2492. | |||||||||||||||
| Notes | This recall only pertains to aftermarket dorman steering knuckles and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STEERING - LINKAGES - TIE ROD ASSEMBLY | |||||
| 030232049 | 11/01/2003 | 10004765 | Release of new outer tie rod ends for service. *tt | 01/06/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||
| 08/01/1998 | |||
| When trying to turn steering wheel it will bind up, making it hard to turn. took vehicle to dealer, and they put a new power steering pump.*ak | |||
| STEERING - LINKAGES - TIE ROD ASSEMBLY | |||
| 5 | |||
| The 2 outer tie rods, reported of a lot of noise in the front end from 5k to 23k+ miles. consumer/mechanic thought that this noise could be from a loose bumper, therefore clips were added, but the rattle noise is still there. *scc | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 12/14/2001 | 1 | ||
| While driving at highway speeds, driver lost control of the vehicle due to a defective steering shaft. dealer has replaced steering shaft. *ak consumer had no steering, however was able to get the vehicle off of the road safely into a ditch. *slc | |||