Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
| 07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
| Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
| Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
| Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
| Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, DIESEL - STORAGE - TANK ASSEMBLY | |||||
| 3138 | 01/01/2004 | 10010058 | New part restriction at pqc on fuel tanks. *tc | 11/03/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 11/18/2010 | 130000 | ||
| Gas gauge not working, registers full even when not full. low fuel light will come on if you idle for a few minutes. at the same time this started the abs light service traction system came on. this has also occurred with our 2002 buck century at approximately the same # of miles and again both the gas gauge reads inaccurately and the abs light came on.*** | |||
| 03/01/2005 | 64442 | 4 | |
| Awd disable and abs lights illuminated. left rear wheel bearing and hub assembly failed and were replaced (four times).*ak the evap solenoid, fuel sender and pump assembly were replaced. the heating element for the front driver's seat failed twice. the right rear seat belt failed. the right power sliding door actuator module failed. rear wiper failed intermittently. a/c condenser failed. engine failed. *nm | |||
| Very strong raw gas fumes are entering the compartment after initial start first thing in the morning. the dealership has looked at the van (3) times with some modifications performed but the problem still persist. please describe details. ts | |||
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
| 01/01/2002 | 76000 | 5 | |
| 1. no event, just failed. windows, fuel sensor and a/c. 2 . front window on 1995 olds silhouette van, failed and was replaced. both front windows have now failed. consequences are we are unable to roll windows up in inclement weather. window on front passenger side,2002 silhouette van has failed, will roll down but not up., for from 1 hour to several hours.. motor will have to be replaced in all, dealer says. consequences are we can't roll window up in inclement weather. 2. fuel sensor has failed, gas gauge does not work, stuck in construction zone when on trip and we showed full tank of gas but then alarm went off and showed empty. 10 miles from station. very nerve wracking as we would have been stuck. mechanic put a tester on it, although the alarm went off as he was doing this, the tank had 3/4 full..it also showed it had two times capacity of fuel in it. mechanic was puzzled by it also.. said it was sensor and has to be replaced. the gauge shows full until it is empty then drops to empty and alarm sounds. gauge goes to empty when it is shut off but then shows full when you start van. 3. motor was replaced on 1995 van by a dealer, then both windows failed. on 2002 van, we will have to replace window motor on drivers side. bad part is getting snowed and rained on when window sticks and won't go up. and before we had a/c fixed we couldn't use windows for air. have to replace fuel sensor on 2002. ad dealer replace front ac compressor/condenser on 2002 van for front, back is still not working. dealer says something is in rear of van that has to be fixed as it don't switch from hot to cold, stays on hot. and it is expensive. *ak | |||