Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, DIESEL - STORAGE - TANK ASSEMBLY | |||||
3138 | 01/01/2004 | 10010058 | New part restriction at pqc on fuel tanks. *tc | 11/03/2004 | |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
3390A | 10017223 | Inaccurate fuel gage reading. *tt | 10/28/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
04/14/2003 | 4600 | 1 | 01/02/2003 |
Driving at approx 25 mph and the car just cut off. took car to bill estes chevrolet. and they were not able to duplicate the problem, the service record reads as follows. could not duplicate good fuel pressure good spark, no dtc's, no new pcm updates, no bulletins, test drove and could not duplicate. 2) having problems with hard start occasionally...invoice from dealer reads as follows. start up at times vehicle is hard to start seems to crank to long cause: 33 electrical all. *nlm | |||
FUEL SYSTEM, OTHER | |||
02/26/2011 | 101000 | ||
Reference investigation pe 11-014. this issue is not limited to 2005-2007 gm suvs. on 2/26/11, my 2003 oldsmobile silhouette stalled on interstate i-75. i was able to coast to the shoulder, but it was a dangerous situation in the dark, with family & kids in the car, with icy, snowy roads. the fuel level reading indicated more fuel availability than what was actually in the fuel tank. the fuel guage will showed between 1/16 and 1/8 of a tank, and there was not a low fuel warning light. i had to call for roadside assistance. after the car had been stalled for a while, the low fuel warning light activiated - so road service first tried putting fuel in the vehicle. with fuel added to the vehicle, it started right up and i was able to refuel the vehicle at the next exit. the vehicle has about 100,000 mile, and is in very good condition - this defect should not be happening at this point in the vehicle's life. a dealer service garage verified that the fule level guage is defective, and it would cost about $425 to repair. |