Peterbilt 385 2007
Model 385 made in 2007 by Peterbilt got 3 investigations there are 5 recalls as well as 2 service bulletins. Technical service bulletines regarding electrical system. The car had some investigations: engine and engine cooling, power train. There were some recalls concerningpower train, suspension and trailer hitches.
Model 2007
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
POWER TRAIN - AXLE ASSEMBLY | ||||||||||||||||
10V634000 | PACCAR INCORPORATED | from 02/02/2006 to 04/30/2007 | V (Vehicle) | 12873 | ODI | PACCAR INCORPORATED | 12/13/2010 | 12/21/2010 | ||||||||
Defect Summary | Paccar is recalling certain model year 2007-2008 kenworth and peterbilt vehicles manufactured from february 2, 2006 through april 30, 2007. the bearing surfaces of the extended lube universal joint that attaches the inter-axle driveline to the drive axle may become prematurely worn due to breakdown of lubrication and/or excessive heat. prematurely worn bearing surfaces may result in the u-joint becoming loose and/or binding. this condition may result in universal joint failure, allowing the inter-axle driveline to detach from the axle. | |||||||||||||||
Consequence Summary | Detachment of the driveline from the axle may cause the vehicle to lose power and become disabled in the roadway. also, the driveline could drop from the vehicle into the roadway increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Paccar is working with its supplier to remedy the vehicles free of charge. the safety recall is expected to begin during february 2011. owners may contact kenworth at 425-828-5440 and peterbilt at 940-591-4196. | |||||||||||||||
Notes | Kenworth recall no. 10kwl & peterbilt recall no. 1201f.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
07V132000 | PACCAR INCORPORATED | from 11/27/2006 to 02/28/2007 | V (Vehicle) | 245 | 05/09/2007 | MFR | PACCAR INCORPORATED | 03/22/2007 | 03/22/2007 | |||||||
Defect Summary | On certain trucks, the axle housings may have been manufactured with steel that was out of specification which could result in a fatigue failure over time. | |||||||||||||||
Consequence Summary | If a fatigue failure occurs and is left unattended, the axle may lock up or the end of the axle could come off, which may result in a vehicle crash. | |||||||||||||||
Corrective Summary | Dealers will inspect and replace the axles free of charge. the recall began on may 9, 2007. owners may contact kenworth at 425-828-5440 and peterbilt at 1-940-591-4196. | |||||||||||||||
Notes | Kenworth recall no. 07kw4 & peterbilt recall no. 107c.customers may contact the national highway traffic safety administration | |||||||||||||||
SUSPENSION | ||||||||||||||||
06V490000 | PACCAR INCORPORATED | from 08/16/2006 to 11/22/2006 | V (Vehicle) | 3246 | 01/17/2007 | MFR | PACCAR INCORPORATED | 12/21/2006 | 12/28/2006 | |||||||
Defect Summary | On some peterbilt trucks, certain parts used in the air suspensions have a high copper content causing premature failure. | |||||||||||||||
Consequence Summary | Failure could cause erratic vehicle handling which can cause a vehicle crash without warning. | |||||||||||||||
Corrective Summary | Dealers will inspect and, when necessary, replace the defective parts. the recall began on january 17, 2007. owners may contact peterbilt at 1-940-591-4196. | |||||||||||||||
Notes | Paccar/peterbilt recall no. 1206d.customers may also contact the national highway traffic safety administration | |||||||||||||||
TRAILER HITCHES | ||||||||||||||||
07V269000 | PACCAR INCORPORATED | from 05/31/2005 to 01/09/2007 | V (Vehicle) | 9571 | 09/04/2007 | MFR | PACCAR INCORPORATED | 06/26/2007 | 06/26/2007 | |||||||
Defect Summary | On certain trucks, the removable tow hitch ,when used to tow or lift a vehicle, can fail due to defective material in the tow hitch. | |||||||||||||||
Consequence Summary | If the tow hitch assembly fails while a vehicle is being towed or lifted, it may cause an accident that could result in personal injury or death. | |||||||||||||||
Corrective Summary | Dealers will replace the tow pin assembly free of charge. the recall began on september 4, 2007. owners may contact kenworth at 425-828-5440 or peterbilt at 940-591-4201. | |||||||||||||||
Notes | Peterbilt recall no.507e and kenworth recall no. 07kwa.customers may contact the national highway traffic safety administration | |||||||||||||||
08V104000 | PACCAR INCORPORATED | from 06/01/2006 to 01/31/2008 | V (Vehicle) | 318 | 04/18/2008 | MFR | PACCAR INCORPORATED | 03/10/2008 | 03/10/2008 | |||||||
Defect Summary | Paccar is recalling 318 my 2007-2009 kenworth t800, w900, and peterbilt 357, 365, 367, 378, 379, 384, 385, 386,388, and 389 trucks equipped with premier trailer hitch assemblies. the pintle hitch assemblies may have been manufactured in a manner resulting in a reduction of fatigue strength of the pivot pins. | |||||||||||||||
Consequence Summary | This reduction of fatigue strength could cause the pivot pin to crack and eventually break, causing the trailer to detach from the truck while in motion, which could cause a crash that could result in personal injury or death. | |||||||||||||||
Corrective Summary | Dealers will replace the potentially defective pivot pin free of charge. the recall began on april 18, 2008. owners may contact kenworth at 1-425-828-5440 or peterbilt at 1-940-591-4196. | |||||||||||||||
Notes | Kenworth recall no. 08kw4 and peterbilt recall no.208d.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
FRN-808-1 | 10/17/2008 | 10027645 | Peterbilt trucks: the electrical system may shut down due to a power surge. when this occurs, the green light on the comfortclass control panel turns to red. *pe | 01/27/2009 | |
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||||
FRN-808-1 | 10/17/2008 | 10027645 | Peterbilt trucks: the electrical system may shut down due to a power surge. when this occurs, the green light on the comfortclass control panel turns to red. *pe | 01/27/2009 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||
EA09008 | PACCAR INCORPORATED | 05/29/2009 | 08/27/2010 | Horton Fan Hub Failures | ||
Paccar is conducting an owner notification program (onp) for select vehicles within the subject and peer populations.the onp are attached to the closing report and can be found in the nhtsa technical service bulletin (tsb) database. (tsb: 10033585, 10033584)see closing report for investigation details. | ||||||
EA09008 | PACCAR INCORPORATED | 05/29/2009 | HORTON FAN FAILURES | |||
During the pe odi learned that the subject vehicles are being disabled when the horton fan hub fails, due to the fan striking the radiator.apparently, warning signs of the impending failure are not always sufficient to give the driver time to pull off the highway.thus, when the failure occcurs, in some cases the vehicle is stranded and must be towed. odi has examined data which indicates that class vii and viii trucks are over represented in crashes when stranded on the highway or shoulder, as contrasted to light vehicles.further, crashes involving disabled heavy trucks being struck by light vehicles are more likely to have serious consequences. nhtsa has upgraded pe09-002 to an ea to further investigate this matter.odi will examine the warning symptoms and assess the risk of a crash in the event of a breakdown on the highway. | ||||||
POWER TRAIN - DRIVELINE - DRIVESHAFT | ||||||
PE10029 | PACCAR INCORPORATED | 08/02/2010 | 12/23/2010 | Driveshaft separates from tractor | 10V634000 | |
Summaryon july 13, 2010, the office of defects investigations (odi) opened an investigation on model year (my) 2007-2009 peterbilt tractors equipped with the (spl170xl extended lube inter-axle driveline).odi opened this investigation based on one vehicle owners questionnaire (voq) and certain peterbilt field reports.during the course of the investigation, odi reviewed paccar's ir (october 22, 2010) response with associated data related to warranty and complaint information, mined field data, interviewed customers and visited local dealers within the washington metropolitan area.paccarconducted testing regarding torsional loading and identified various causative factors contributed to this safety defect finding.the defect is a consequence of the bearing surfaces of the spl170xl extended lube universal joint that attaches the inter-axle driveline to the drive axle becoming prematurely worn due to a breakdown of lubrication and/or excessive heat.prematurely worn bearing surfaces may result in the u-joint becoming loose and/or binding.this condition may result in universal joint failure, allowing the inter-axle driveline to detach from the axle, which may cause the drive axle to separate from the vehicle, increasing the risk of personal injury or property damage hazard.odi learned that the affected population of the alleged defect extended to peer models within paccar.in summary, the following vehicles are being recalled: my 2007 and 2008 kenworth trucks, models t600, t660, t2000, t800 and w900 and my 2007/2008 peterbilt trucks, models357, 378, 379, 385, 386, 387, 388, and 389 allequipped with extended lube inter-axle drivelines manufactured by dana corporation.the recall affects vehicles manufactured between february 2, 2006 and april 30, 2007.at this time paccar has not yet identified a fix for the inner-axle safety defect and is currently conducting testing with the intent to provide a solution to the failure.odi will monitor the development of paccars testing and ensure a timely repair for the consumer.this investigation is closed. |