Pierce Fire Truck 2000
Model Fire Truck made in 2000 by Pierce got 1 investigation there are 3 recalls as well as 2 service bulletins. Technical service bulletines regarding electrical system, engine and engine cooling. The car had one investigation (steering). There were some recalls concerningelectrical system, fuel system, gasoline and suspension.
Model 2000
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
| 03V043000 | PIERCE MANUFACTURING,INC. | V (Vehicle) | 13 | 02/24/2003 | MFR | PIERCE MANUFACTURING | 02/12/2003 | 02/12/2003 | ||||||||
| Defect Summary | On certain fire chassis equipped with harrison hydra-gen generators. the tubing connecting the soft start to the generator pump can break away from the fitting and spray hydraulic fluid onto the exhaust. | |||||||||||||||
| Consequence Summary | This can cause a fire that could endanger people in the vicinity, the vehicle itself, and nearby property. | |||||||||||||||
| Corrective Summary | Dealers will remove two pieces of steel tubing and replace them with high pressure hose. owner notification is expected to begin during february 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact pierce at 1-888-974-3723. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - MOUNTING | ||||||||||||||||
| 01V151000 | PIERCE MANUFACTURING,INC. | from 01/01/1996 to 12/31/2000 | V (Vehicle) | 800 | 05/31/2001 | MFR | PIERCE MANUFACTURING | 05/09/2001 | 05/18/2001 | |||||||
| Defect Summary | Vehicle description: fire apparatus on certain commercial chassis with options for fuel tank step covers. certain vehicles were built without drain holes in the aluminum step located below the fuel fill opening. | |||||||||||||||
| Consequence Summary | Spilled fuel on the fuel tank steps can create a slip hazard. | |||||||||||||||
| Corrective Summary | Dealers will drill holes in the step. the holes will help drain any fuel that is accidentally spilled on the step. owner notification began may 31, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact pierce at 1-888-974-3723. | |||||||||||||||
| Notes | Pierce recall number 74b23.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| SUSPENSION - MULTIPLE AXLE | ||||||||||||||||
| 01V113000 | PIERCE MANUFACTURING,INC. | V (Vehicle) | 147 | 01/30/2001 | ODI | PIERCE MANUFACTURING | 04/02/2001 | 04/09/2001 | ||||||||
| Defect Summary | Vehicle description: fire trucks equipped with oshkosh all-steer all-wheel steering system. the rear wheels of a fire engine can turn unintentionally if the all-wheel steering system key is on and moisture penetrates to the wire that connects the steering sensor to the electronic control unit (ecu). it was discovered that the insulation covering the wires between the sensor and the ecu had been nicked during time of assembly. over time, the nick in the insulation allowed moisture to penetrate to the actual wire. | |||||||||||||||
| Consequence Summary | Under these conditions, the driver can experience unintended turning of a single or a tandum rear axle, possibly leading to a vehicle crash or injury or death to a pedestrian or fire fighter. | |||||||||||||||
| Corrective Summary | Dealers will inspect for nicked wires and replace the wire harness. this recall campaign is 100% complete. | |||||||||||||||
| Notes | ||||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| SL-6387-00 | 08/18/2010 | 10036912 | Caterpillar: see document search button for owner letter. new software needs to be installed on certain c9 engines installed in pierce fire trucks that are equipped with a two stage water pump. the existing software could cause the engine | 04/18/2011 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| SL-6387-00 | 08/18/2010 | 10036912 | Caterpillar: see document search button for owner letter. new software needs to be installed on certain c9 engines installed in pierce fire trucks that are equipped with a two stage water pump. the existing software could cause the engine | 04/18/2011 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| STEERING | ||||||
| SQ01006 | PIERCE MANUFACTURING | 03/15/2001 | 04/06/2001 | ALL WHEEL STEERING MALFUNCTION | 01V113000 | |
| A | ||||||