Pierce Impel 2007

Model Impel made in 2007 by Pierce got 7 recalls as well as 6 service bulletins. Technical service bulletines regarding electrical system and equipment. There were some recalls concerningair bags and electrical system.

Model 2007

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
AIR BAGS - ROLL PROTECTION
09V341000PIERCE MANUFACTURINGfrom 12/05/2007 to 07/15/2009V (Vehicle)2808/31/2009MFRPIERCE MANUFACTURING08/31/200908/31/2009
Defect SummaryPierce is recalling certain model year 2007 through 2009 fire trucks equipped with side-roll protection systems. the sensor designed to detect vehicle roll can malfunction resulting in an inadvertent deployment of the protection system.
Consequence SummaryInadvertent deployment of the side-roll protection system could result in a vehicle crash or injury to an out of position occupant.
Corrective SummaryPierce will notify owners and the vehicles will be repaired free of charge. the safety recall is expected to begin during september 2009. owners may contact pierce toll-free at 1-888-974-3723.
NotesPierce's recall campaign number 39-0139830.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
ELECTRICAL SYSTEM - BATTERY
09V105000PIERCE MANUFACTURINGfrom 04/11/2007 to 02/14/2008V (Vehicle)16704/07/2009MFRPIERCE MANUFACTURING04/01/200904/01/2009
Defect SummaryPierce is recalling 167 my 2007-2008 velocity and impel fire trucks. a battery box is positioned on both sides of the chassis frame directly under the cab. cab interference may occur with the positive battery post and the aluminum cab floor substructure.
Consequence SummaryIf metal-to-metal contact were to happen, an electrical arcing between the cab and battery could occur increasing the risk of electrical short circuit and a fire.
Corrective SummaryOwners will receive a remedy kit along with instructions and should inspect the positive battery posts to make sure the protective caps have not worn away, if contact with the cab has occurred, replace the battery post protective caps. this remedy will be free of charge. the recall began on april 6, 2009. owners may contact pierce at 1-888-974-3723.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
LATCHES/LOCKS/LINKAGES
13V062000Pierce Manufacturingfrom 06/06/2007 to 10/30/2010V (Vehicle)1237MFRPierce Manufacturing02/25/201302/26/2013
Defect SummaryPierce is recalling certain model year 2007-2010 velocity and impel fire trucks manufactured from june 6, 2007, through october 30, 2010. the springs inside the inner door handles may allow the door to open inadvertently.
Consequence SummaryIf the door inadvertently opens while the vehicle is in motion, the occupants may fall out and suffer personal injury.
Corrective SummaryPierce will notify owners, and dealers will replace the inner door handles, free of charge. the manufacturer has not yet provided a notification schedule. owners may contact pierce at 1-920-832-3000.
NotesPierce's campaign recall number is 74b237.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
SERVICE BRAKES, AIR - DISC - CALIPER
08V598000PIERCE MANUFACTURINGfrom 04/17/2007 to 04/25/2008V (Vehicle)1511/10/2008MFRPIERCE MANUFACTURING11/18/200811/18/2008
Defect SummaryPierce is recalling 15 my 2007-2008 dash, enforcer, impel, quantum and velocity fire trucks equipped with arvinmeritor rear disc brakes and hendrickson firemaax suspension. interference with the brake caliper adjuster bolt sleeve and the suspension beam may occur. this interference may occur if the right hand and left hand brake components were assembled on the wrong side of the axle. the adjuster bolt is designed to rotate as the brake pads wear. if the sleeve becomes damaged, the sleeve may prevent the adjuster from rotating.
Consequence SummaryIf the adjuster can not rotate, brake performance may be compromised and a crash may occur.
Corrective SummaryDealers will adjust the bolt sleeve and the proper components free of charge. all owners have been notified by arvinmeritor.
NotesCustomers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
STEERING
10V423000PIERCE MANUFACTURINGfrom 05/30/1998 to 11/25/2008V (Vehicle)265210/12/2010MFRPIERCE MANUFACTURING09/21/201009/22/2010
Defect SummaryPierce is recalling certain model year 1998 through 2008 arrow xt, lance, velocity, enforcer, impel, and dash custom fire apparatus vehicles manufactured from may 30, 1998 through november 25, 2008. the steering gear bracket may fracture and break. if this occurs the steering gear may detach from the vehicle.
Consequence SummaryDetachment of the steering gear will result in a loss of steering control that could cause a crash.
Corrective SummaryPierce will notify owners and dealers will install a new steering gear mounting bracket free of charge. the safety recall began on october 12, 2010. owners are being instructed to inspect the steering gear bracket prior to each trip. the remedy to repair this defect is expected to begin no earlier the january 31, 2011. owners may contact pierce at 1-888-974-3723.
NotesPierce safety recall no. 74b207.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
STEERING - GEAR BOX - SHAFT PITMAN
08V020000PIERCE MANUFACTURINGfrom 09/29/2007 to 11/29/2007V (Vehicle)2201/11/2008ODIPIERCE MANUFACTURING01/15/200801/15/2008
Defect SummaryOn certain fire trucks equipped with trw steering gears, models tas85 and rcs85, these steering gears contain potentially defective sector shafts with an incorrect gear tooth which may interfere with the rack-piston teeth, resulting in a stick or bind condition.
Consequence SummaryThis condition has the potential to cause the steering gear to stall and restrict the steering turning angle of the vehicle which could result in a vehicle crash.
Corrective SummaryPierce is working with trw to replace the defective steering gear (please see 07e101). the recall began on january 11, 2008. owners ontact trw at 765-429-1768 or pierce at 920-832-3249.
NotesCustomers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
STRUCTURE - BODY - BUMPERS
10V300000PIERCE MANUFACTURINGfrom 02/20/2003 to 03/27/2009V (Vehicle)2509/30/2010MFRPIERCE MANUFACTURING06/28/201006/30/2010
Defect SummaryPierce is recalling certain model year 2003 through 2009 custom contender, dash, enforcer, impel, lance saber, and velocity fire trucks manufactured from february 20, 2003, through march 27, 2009. these trucks may be equipped with drop-down fire hose trays mounted under the front bumper. the hose tray latch may accidentally open while the vehicle is in motion.
Consequence SummaryIf this occurs the fire hose may drop to the roadway without warning. potential injury to people and property may occur. the sudden hose deployment may also distract drivers trying to avoid the hose and a crash may occur.
Corrective SummaryA new and improved latch design has been developed and a new hose box incorporating the new latch will be installed free of charge. the safety recall is expected to begin during september 2010. owner may contact pierce at 1-920-832-3000.
NotesPierce safety recall no. 39-0139830.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ELECTRICAL SYSTEM
TSB-74B17502/10/200910029186Pierce mfg: multiple units have experienced moisture collecting within the roto molded evaporator housing. model years unknown. proper cycling of air condition system. updated electric harness. lower battery box due to positive post.06/24/2009
ELECTRICAL SYSTEM - BATTERY
TSB-74B17502/10/200910029186Pierce mfg: multiple units have experienced moisture collecting within the roto molded evaporator housing. model years unknown. proper cycling of air condition system. updated electric harness. lower battery box due to positive post.06/24/2009
EQUIPMENT - ELECTRICAL - AIR CONDITIONER
TSB-74B17502/10/200910029186Pierce mfg: multiple units have experienced moisture collecting within the roto molded evaporator housing. model years unknown. proper cycling of air condition system. updated electric harness. lower battery box due to positive post.06/24/2009
LATCHES/LOCKS/LINKAGES
SB-74B17802/01/200810029185Pierce mfgr: a change in the manufacturing process of certain cab door latches may have affected proper performance of the latching mechanism. model years unknown. *pe06/24/2009
LATCHES/LOCKS/LINKAGES - DOORS - LATCH
SB-74B17802/01/200810029185Pierce mfgr: a change in the manufacturing process of certain cab door latches may have affected proper performance of the latching mechanism. model years unknown. *pe06/24/2009
STRUCTURE - BODY
TSB-74B17502/10/200910029186Pierce mfg: multiple units have experienced moisture collecting within the roto molded evaporator housing. model years unknown. proper cycling of air condition system. updated electric harness. lower battery box due to positive post.06/24/2009