Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | ||||||||||||||||
06E088000 | TI GROUP AUTOMOTIVE SYSTEMS, LLC | E (Equipment) | 39243 | 10/06/2006 | MFR | CHRYSLER GROUP LLC | 10/23/2006 | 10/26/2006 | ||||||||
Defect Summary | Certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module. | |||||||||||||||
Consequence Summary | Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-877-461-1834. | |||||||||||||||
Notes | This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY | |||
11/14/2005 | 1 | 05/22/1999 | |
I brought my vehicle to my dealer to get an oil change done, and i was informed that my gasket that controls my gas was cracked, and it had to be replaced. i was charged $460.00, and i was never shown the old part. i don't even know if there really was a problem considering the fact that every time i bring my car to get an oil change, a problem usually occurs, according to them, but no part is ever shown to me. *jb | |||
04/15/2006 | 58002 | 2 | 05/12/2003 |
My plymouth breeze completely shut down as i was driving it. my daughter was in the car with me and we both could have gotten seriously hurt. also, i just spent $700 on a blown head gasket. something really needs to be done about these vehicles. *nm | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
11/16/2002 | 69000 | 8 | 04/01/1999 |
Fuel pump failed.ts *tt *jb. *ak | |||
08/01/2002 | 1 | 08/01/2001 | |
The oem fuel pump fits into the gas tank. the positive wire leading into the tank shorted out melting the wire insulation on the outside of the gas tank melting the plastic into causing gas to leak out through the hole it created. this gas flowed over the bare wire. the same wire continues into the inside of the gas tank and it continued to short in there causing the plastic inside of the gas tank to turn brown from the heat. my concern is a spark would have been created perticularly if the tank was partially full the fumes would have ignited causing a serious explosion. the dealership where i bought the replacement part said there are no recalls and the same holds true with the data on your site. the concern should be there are thousands of this model type out there that may have the same dangerous condition.*ak | |||
02/09/2001 | |||
Electrical wires in through fuel tank shorted out, and fuel pump would shut down. took to dealership, and informed by mechanic nothing to worry about. way system was designed.*ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
10/01/1999 | |||
Consumer smelled fuel while driving. dealer replaced o-rings where fuel was leaking. at this time o-rings need to be replaced again. *ak |