Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| 040202 | 02/04/2002 | 629751 | Customer complaints of smoke in lens, water in lens, cracks in the lens, fog or moisture in the lens. *tt | 04/05/2002 | |
| 141201 | 12/14/2001 | 629625 | Subject regarding complaints of condensation inside the headlamp sealed beam. *tt | 04/04/2002 | |
| EXTERIOR LIGHTING - TAIL LIGHTS | |||||
| 191201 | 12/19/2001 | 629645 | Subject regarding reports of water accumulating inside the left side tail lamp. *tt | 04/04/2002 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EXTERIOR LIGHTING | |||
| 11 | 11/21/2001 | ||
| Problems with electrical system, clutch, pistons, dash fan and rear right molding. *mr the vehicle developed a crack in the cylinder head. saturn repaired the part but would not reimburse the consumer for repair cost due to the vehicle exceeding the warranty. at the time of the repair the vehicle had 96k plus miles. the vehicle also experienced the following: engine knocking/loss of power (8 pistons were replaced), after engine problem/repair, engine oil consumption occurred (one quart every 1300 hundred miles, bang noise in the clutch (bearing was replaced), water and haze was in the high/low beam inside the bulbs, left headlight shorted out/wire burnt (actuator was replaced), the brake pedal rubber guard had detached, the gas tether detached, there was an engine knock upon acceleration, the ignition module and camshaft position sensor experienced performance problems, the transmission shimmies when shifting under the vehicle when the clutch depressed, the headlights, rear light, dash lights, radio lights, and the interior lights would continuously flicker. *scc in cold weather the shifter failed to engage in 2nd and 4th gears. *jb | |||
| EXTERIOR LIGHTING - HEADLIGHTS | |||
| 08/30/2002 | 1 | 01/01/2002 | |
| Right headlight burned out after 7 monthes with vey little night driving so use of headlights was minimal. wouldn't have complained had i not read of many accounts of the same thing happening to others with the same car on the website ls1.com in the ws6/firehawk forum.*ak | |||
| EXTERIOR LIGHTING - HEADLIGHTS - CONCEALMENT DEVICES | |||
| 06/05/2005 | 0 | 12/22/2001 | |
| Headlight assembly did not activate when light switch was turned on. lamps lite but the assembly did not rise into position. | |||