Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
610 | 10/01/2004 | 10015768 | Engine idle flare when the clutch is depressed. also low speed engine decel stall when coming to a stop. gm tech link. *tt | 08/11/2005 | |
050604002 | 01/01/2005 | 10013475 | Whistle noise on light acceleration. *eh | 04/19/2005 | |
050601003A | 08/01/2005 | 050601003B | 10013473 | Higher than expected oil consumption blue smoke on acceleration. *eh | 04/19/2005 |
11062003 | 11/06/2003 | 10013142 | Intermittent stall rough idle engine misfire. *eh | 04/08/2005 | |
030601018 | 07/01/2004 | 10012103 | New cylinder bore liner replacement procedure. this service bulletin replaces 030601018a. *eh | 02/11/2005 | |
3114 | 01/01/2004 | 10009973 | B1327 diagnostic missing. *sc | 11/02/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
071003 | 07/10/2003 | 10003815 | This vme message is a water pump replacement due to a known cam driveline. some customers may question about whine noise coming from the front engine area. *tt | 11/03/2003 | |
071503 | 07/15/2003 | 10003789 | Coolant lose, evidence fluid on the garage floor, etc., or coolant warning light coming on. *tt | 10/31/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4495C | 03/01/2011 | 10038510 | Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm | 06/16/2011 | |
PIP-4495C | 03/01/2011 | 10038510 | Ready | 06/16/2011 | |
PIC-5405 | 12/01/2010 | 10037814 | Gm: the engine will not start. the engine cranks and sounds like it's going to start but then stops cranking. *rm | 06/06/2011 | |
PIC-5405 | 12/01/2010 | 10037814 | Ready | 06/06/2011 | |
3859 | 3859A | 10020923 | Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj | 01/30/2007 | |
3709 | 10019420 | Supplement to engine replacement instructions for part number 12607031. *tt | 03/14/2006 | ||
050604026 | 05/01/2005 | 050604026A | 10017407 | Vehicle hesitates, no start, lack of power, low fuel pressure. *tt | 11/07/2005 |
3433 | 3433D | 10017032 | Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07. *kb | 10/20/2005 | |
0804 | 08/01/2004 | 10014346 | Oil life system reset procedures - cars. *nm | 04/29/2005 | |
030601022 | 01/01/2004 | 030601022A | 10011117 | Guidelines for cylinder bore liner/piston sleeve replacement on the l4 ecotec engine. *tt | 01/03/2005 |
040604063 | 09/01/2004 | 10011046 | Engine idle flair when clutch depressed or decel stall. *tt | 12/27/2004 | |
3007 | 01/01/2004 | 10008786 | 3.8l engine oil consumption. *tt | 08/23/2004 | |
3014 | 01/01/2004 | 10008776 | Stall, hesitation, stumble with no diagnostic trouble codes (dtcs). *tt | 08/23/2004 | |
040604014 | 04/01/2004 | 040604014A | 10008666 | No start or immediate stall after start. *tt | 08/13/2004 |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
01527 | 01/01/2004 | 10005464 | A whistle type noise coming from the engine. sit bulletin 1406534. *tt | 02/27/2004 | |
01528 | 01/01/2004 | 10005465 | Intermittent stall, rough idle, misfire or malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p0300. sit bulletin 1406556. *tt | 02/27/2004 | |
01525 | 01/01/2004 | 01525A | 10005461 | Engine stall hesitation stumble with no diagnostic trouble codes (dtcs). *tt | 02/27/2004 |
030604055 | 10/01/2003 | 10004317 | Service engine soon/check engine light illuminated, misfire or roughness, diagnostic trouble code (dtc) p0300 set. *tt | 12/02/2003 | |
01315 | 11/17/2003 | 10004095 | Engine misfire possible diagnostic trouble codes (dtcs) p0300 - p0304. *tt | 11/18/2003 | |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
3009 | 01/01/2004 | 3009A | 10008778 | Excessive oil consumption and/or black/blue smoke from the exhaust. *tt | 08/23/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE | |||
03/14/2012 | 125000 | ||
Won't start without holding key to on position for 10 minutes.turn signal keeps making clicking sound for up to 2 minutes after turning off signal. | |||
11/28/2012 | 119000 | ||
Tl* the contact owns a 2004 pontiac grand am. the contact stated that while he inspected the vehicle, he found that the steel brake lines were corroded and the vehicle emitted a loud noise from the engine floorboard area. the vehicle was not repaired. the manufacturer was not made aware of the failure. the vin was not available. the failure and current mileage was 119,000. | |||
11/28/2012 | 119000 | ||
Tl-the contact owns a 2004 pontiac grand am. the contact stated that while he inspected the vehicle, he found that the steel brake lines were corroded and the vehicle emitted a loud noise from the engine floorboard area. the vehicle was not repaired. the manufacturer was not made aware of the failure. the vin was not available. the failure and current mileage was 119,000. kmj | |||
11/28/2012 | 119000 | ||
Tl-the contact owns a 2004 pontiac grand am. the contact stated that while he inspected the vehicle he found the steel brake lines corroded and the vehicle emitted a loud noise in the engine floor board area. the vehicle was not repaired. the manufacturer was not made aware of the failure. the vin was not available. the failure and current mileage was 119,000. li | |||
ENGINE AND ENGINE COOLING | |||
02/22/2010 | 78000 | ||
Tl*the contact owns a 2004 pontiac grand am. the driver stated that she drove to work in her vehicle and it functioned normally. when she tried starting the vehicle later that evening, the vehicle would not start. the driver also stated that this was not the first time that the failure occurred. the driver stated that the body control module was replaced at the end of january and she is now having the same problem. the contact also stated that she contacted the dealer but they are not offering any assistance. the vin was not available. the current and failure mileages were 78,000. | |||
01/10/2009 | 101000 | ||
Tl*the contact owns a 2004 pontiac grand am. while driving at any speed, the vehicle would often stall and fail to restart. the most recent failure occurred while driving less than 55 mph. the vin was unknown. the current and failure mileages were less than 101,000. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
08/24/2007 | 48427 | 0 | 04/07/2006 |
Hi..my name is deborah braun..i would like to report recall on my vechile. i bought 2004 pontaic grand am gt last april 7th of 2006 at kelley's northside chevrolet in evansville indiana with low mileage 30,427. i don't know how long the radiator had the problem. til now last month it appeared that the radiator got worse and can't drive in bad condition. i took my vechile to 2 different mechanic to look at the radiator. they said that i need new radiator. i can't believe that i had bad radiator because i don't drive that much in 1 year after i bought it.right now the milage on my vechile is only 48,400.. impossilble. so that why i want to file complaint report recall on my vechile..it might be from manfacture ..other reason is that i can't afford to pay for new radiator whcih i think i shouldn't pay for this..also i had warranty but will not cover the radiator just for the parts..if you reply me back soon as possible.that would be nice if you can email me or call me thur tty..i am deaf. i sure hope you can help me in any way you can..here is my email address is katdeb5658@hotmail.com my phone number is 812 937 7122 and please use relay 711 first then give my phone number..thanks deborah braun | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
11/17/2010 | 120000 | ||
Tl-the contact owns a 2004 pontiac grand am. the vehicle engine will not start causing the battery to be drained. the vehicle was not taken to the dealer. the manufacturer was contacted and informed her to take the vehicle to the dealer for the repairs. the failure mileage was 120,000...mw | |||
03/20/2010 | 67600 | ||
Tl*the contact owns a 2004 pontiac grand am. the contact stated that the vehicle stalled when she attempted to start the ignition. it took ten minutes for the vehicle to finally start up. the vehicle was taken to an authorized dealership twice, on the second visit the contact was informed that the fuel pump needed to be replaced . the contact took the vehicle to an independent mechanic who replaced the fuel pump. however, the vehicle still stalled. the failure mileage was approximately 67,600. the current mileage was approximately 67,700. | |||
02/16/2009 | 55598 | 1 | |
Was driving normally down road on way to work. approached intersection and depressed clutch to down shift and apply brake to stop vehicle. however with clutch depressed, the vehicle began to rev up on its own without the accelerator pedal depressed, until it reached the red line. after pumping accelerator about five or six times vehicle stopped revving up. however several miles down the road the vehicle began to rev up again when clutch was depressed to shift gears. this is an ongoing issue, vehicle has been seen by gm dealerships and gm rep but they claim issue cannot be replicated. multiple parts have been replaced but issue continues. will a major accident or death be required for this issue to be addressed? i realize that this is probably not sticking out as a major issue because of low numbers of reports of this same problem, but i would imagine that since this is probably isolated to models with manual transmission which is a very small minority of vehicles. if thought about in the fact that their are few vehicles configured with a manual transmission, the fact of the number of reports of this issue makes it more significant since it would equal a higher percentage of vehicles when compared to the total number of vehicles configured with a manual transmission. *tr | |||
05/21/2007 | 9300 | 1 | |
Tl*the contact owns a 2004 pontiac grand am. while making a turn, the engine surged and lost power. the contact was able to pull off the road and stop the vehicle by applying the emergency brake. the vehicle was able to be restarted and driven. the vehicle is currently being diagnosed. the engine size, # of cylinders, and purchase date were unknown. the current and failure mileages were 9,300. | |||
03/13/2006 | 14930 | 1 | 08/01/2004 |
Dt*: the contact stated while driving at various speeds the engine revs. the vehicle was taken to the dealership for inspection. they replaced the computer module which did not remedy the problem. | |||
04/15/2004 | 400 | 100 | 02/16/2004 |
Dt: while driving in rainy weather it sounded from the right front corner of the car under the hood like something was grinding or abrasion. it sounded like two bearings rubbing against each other. took the car to the dealer, and they were not able to hear it. the dealer took it for a test drive, lifted it up onto the lift and was not able to hear any noise.*ak updated 8/14/2006 - the right front tire warped. the brake calipers warped shortly after the vehicle was purchased. both front rotors had to be replaced due to warpage. the consumer heard noise on the driver's side front end. the dealer replaced the upper strut mount, bearing plate and aligned the front end. the vehicle would lose power while driving. the dealer reprogrammed the engine control module. the master cylinder leaked and had to be replaced. power steering pump leaked and was replaced. the tramsmission was slipping. *nm | |||
02/18/2005 | 8 | 06/19/2004 | |
2004 pontiac grand prix shuts down while driving and the power steering and braking ability are lost.*mr *nm | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
11/29/2006 | 15 | 06/13/2006 | |
I have a 2004 grand am. i bought it from a dealership used with approx. 36,000 miles on it. i have had it for only 4 months and have already replaced the ignition sensor, and have been told to replace the o2 sensor as well. now the car randomly loses all power when driving at low speeds. this annoyance is accompanied with the car also not even turning over on some occasions. the car cannot be counted on. i'm taking it in for testing. *jb |