Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
971101776304 | 11/01/1997 | 54066 | Subject pertaining to driveability symptoms due to fuel injector deposits. *yc | 03/30/1998 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 | |
FUEL SYSTEM, OTHER | |||||
990603007C | 04/01/2001 | 990603007B | 619369 | A condition may exist in which the fuel gauge reads incorrectly / fluctuates, low fuel chime sounds prematurely. *tt | 05/24/2001 |
990603007B | 01/01/2000 | 990603007A | 609721 | Some customers may comment on the following conditions: 1) the fuel gauge reading incorrectly. 2) low fuel chime sounds prematurely. 3) fuel gauge may fluctuate from full to empty. *tt | 04/07/2000 |
990603007A | 10/01/1999 | 990603007 | 6088901 | Conditions with inaccurate fuel gauge / fluctuates, premature low fuel chime. *tt | 01/11/2000 |
990603007 | 08/01/1999 | 607586 | Some customers may comment that the fuel gauge reads incorrectly / fluctuates, and the low fuel chime sounds prematurely. *tt | 09/29/1999 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
FUEL SYSTEM, GASOLINE - DELIVERY | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
Ea02-030 is closed with gmea02-030 is closed with gm |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
05/13/2011 | 180000 | ||
The gas tank is not sealed in the the middle allowing gas and fuel vapor to leak from car! all the sway bar on the driver side has separeted due to the rack and pinion, car has no sound when turning to the right but if you try and turn the car to the left it is as if the power steering is going out and make a loud grinding noise and is getting very diffucilt to turn left, also the windsheild wiperdo not work proper and cause problems in the rain, the key get stuck in the ignition all the time,feel as if motor is twisting or moveing forward, will be contacting pontiac due to recalls and problems arriseing | |||
02/26/2007 | 243712 | 1 | 09/12/2000 |
I drove this vehicle home from work, approximately 25 miles. parked in my garage and went in the house, approximately 10-15 minutes later, my wife, daughter and i left to go out to eat, we drove 10 miles to the restaurant. we were in the restaurant no more late 10 minutes when someone commented there was a vehicle out front smoking, i realized that it was our vehicle, and went outside, i approached the car and smelled a burning smell vs. overheating smell. i lifted hood and saw the engine was on fire, i proceeded to put out the fire with nearby snow, and with a fire extinguisher. fire dept was called to make sure fire was out. i then a called tow company and the had car towed back to my home. the car has not been repaired at this time. most of fire was contained to engine area, no damage to paint, and some underhood insulation charred. *jb | |||
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
07/21/2001 | |||
Coolant system is using a lot of coolant. manifold intake has a leak that is leaking out the coolant.*ak | |||
06/01/2000 | 1 | 01/01/1998 | |
The vehicle developed an antifreeze odor during 2000. on several trips to the dealer, no problem was found. the last trip to the dealer, just before the warranty expired, is when the problem was documented (12/26/2000, 15,930 miles) the dealer indicates no leak found. we had the car serviced at a local non-dealer facility, and they indicated that they believed the intake manifold gasket was the cause of the minor leak and antifreeze smell. the dealership now indicates that the expansion plug on the engine is faulty, and refuses to address this as a warranty issue (they will pay for parts but the total labor bill is in excess of $600, with parts unlikely to amount to a fraction the labor costs). the pontiac customer relations department refuses to intervene. your site indicates a service bulletin -- service bulletin number: 010601007, bulletin sequence number: 191, date of bulletin: 0102 , nhtsa item number: sb619176 , some owners may comment on engine coolant consumption, or an engine coolant leak near or under the throttle body area ofthe upper intake manifold. *tt. can you intervene as this is an identified product issue? | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
02/02/2001 | 01/01/2001 | ||
I feel this is a real safety concern! please contact me! no safety defect listed within summary. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
03/12/2004 | 118089 | 1 | 05/19/1998 |
While driving north bound on us 31 highway on the morning of march 12, 2004, the car suddenly died in heavy traffic. with some effort, i was able to pull the car over to the side of the road. when i tried to restart the car, it would start and suddenly die again. had car towed to nearest gm dealer for repair. there was no early indication of a malfunction (ie. no warning lamps of a potential problem). root cause was determined to be a fuel pump resistor. searching this website revealed that a recall had been conducted for a certain region regarding this malfunction. my concern is that this could have been a potentially fatal incident had a different set of circumstances been in place.*ak | |||
11/29/2003 | 66349 | 1 | 06/26/2000 |
Car died when driving on interstate. when attempted to restart, would start, but then when accelerate, car would die.*ak | |||
12/23/2000 | 1 | 02/01/1999 | |
While driving on the ohio turnpike, in heavy traffic, the car suddenly lost all power. i managed to maneuver the car to the side of the highway. when i attempted to restart the vehicle, it would turnover, but then immediately lose all power. we had the car towed to a garage. the problem was a failed fuel pump resistor, which was corroded due to its location as designed (in the passenger-side wheel well). apparently, in canada, owners have been contacted by gm and offered a free retrofit to the firewall. i believe it is a regional recall. shouldn't gm do the same in the states, i.e. at least states that exhibit similar weather patterns? the loss of power at high speeds seems to be a safety concern. less experienced drivers may not be able to avoid accidents at higher speeds.. *ak | |||
07/31/2001 | 2 | 06/20/1998 | |
On two occasions 3.8 v6 engine shut off while traveling at highway speed of 65 mph. vehicle was taken to dealer on two occasions, and was unable to duplicate problem. *ak the fuel pump fuse is blowing, but dealer does not know what is causing the fuse to blow and therefore can not fix this problem. | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
02/07/2008 | 260000 | 1 | 02/23/2007 |
2 days ago we had a huge snow storm. i was trying to get my car unstuck. the car was idling and i was outside digging out the car, and my girlfriend was sitting in the car, she said it was smokey inside. i just thought it was overheating, and it got worse and worse. i finally thought, ok this just isn't overheating, so i shut the car off and popped the hood. the whole rear of the engine was on fire. i got the fire out and managed to save the car. about 6 months ago i had a engine light come on and the code said small evap leak. he said it was my cold air intake and my gas cap. so i replaced the gas cap and drove around with the engine light on, not knowing that there was a actual evap leak. so it was coincidental that the engine light came on 2 days after i put my intake on. and also it was coincidental that it happened on the day with all the snow. so my mechanic said, that i did have a pinhole leak, and that the sparks from the alternator ignited the vapors. also the foam underneath the engine cover acted like a sponge sucking in the all fumes and then boom. *tr | |||
02/14/2007 | 132727 | 1 | 09/22/2004 |
I went to the store, drove about 40 feet and got stuck in snow. realized i was bottomed out in snow when i opened my door. i didn't try to get unstuck. i shut off engine and went into house. several minutes later, i heard a noise and looked out and saw flames shooting from under hood. i immediately called 911 and fire department was there within 5 minutes and truck was there within 10. they immediately asked me if the car was left running at the time the fire started. i said,no, i was inside at least 20 minutes before i heard this noise and looked out. the engine and front end of car is a complete loss. cracked windshield, melted lower left hand corner of windshield and front of instrument panel. their were no flames that reached the inside thru the firewall. unfortunately i am not insured and wife and i are disabled, the car being our only source of transportation. throughout the websites i researched, i saw several dozen people with the same circumstances as i had with their grand prix gtp's. fireman said cause was unknown, but looks like it may have been electrical or maybe fuel related. *jb | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
08/15/1999 | 2 | 01/01/1999 | |
Already had to replace 2 fuel injectors after having car only eight months; child safety locks broke when purchased; motor in driver's power window control panel burnt out | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
02/14/2001 | 1 | 07/02/1998 | |
The fuel injector is inoperative. nlm | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
1 | 09/17/1997 | ||
The fuel tank is suppose to hold 18 gallon of fuel but it hold 14.7 gallons. yh | |||
FUEL SYSTEM, OTHER | |||
07/15/2009 | 114900 | 1 | |
The fuel pump resistor went out on my 1998 pontiac grand prix gtp. after researching the issue, this seems to be a common occurrence on 1997-98 grand prixs and buick regals with the l67 supercharged motor. the resistor goes out without warning, causing the engine to kill seconds after starting. this part was recalled in areas of canada per gm customer satisfaction campaign #01033. *tr | |||
06/17/1998 | 6 | 02/07/1998 | |
Consumer experiencing ongoing problem with vehicle running out of fuel before the tank is empty. dealer/mfr. notified. *ak consumer states that the vehicle has an 18 gallon tank and runs out of fuel after using 14-15 gallons of fuel. *yh | |||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - FILLING/CHARGING | |||
06/22/1998 | 1 | 06/01/1998 | |
Fuel sensor failed. yh | |||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | |||
04/18/2008 | 1 | ||
I received a recall letter,then i moved to a new residents 2wks. later i parked my car in the driveway went into the house maybe 2-3 min i noticed flames coming out of the hood. i ran and got the water hose and put it out. i called the dealer they weren't aware of a recall i had to show proof letter. i faxed it then they towed the car to the dealers gmc was called they called the dealer .04-25-08 i called gmc stated since the car caught on fire they need to send fire investigator out. he came to the dealers took pictures and report and fedex it to gmc mich. then they gave me another adjuster darlene clemens. on may 2nd i called gmc again i was given another adjuster why she wouldn't tell me just gave me the persons name jemeia price since then i been playing phone tag no one can help me i am without a car no loaner or any concern since my car is paid off. since then i found out about other recall the dealer said no not on gmc list or website the recall#for the car is #07035 and my other concerns were recall# 02v286000 or 02049 and#07e021000 im worried i could died or more damage to my car i keep go care of my car gmc doesn't care i need help *tr |