Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STEERING | ||||||||||||||||
09E005000 | DORMAN PRODUCTS, INC. | E (Equipment) | 979 | 02/23/2009 | MFR | GENERAL MOTORS CORP. | 02/17/2009 | 02/17/2009 | ||||||||
Defect Summary | Dorman is recalling 979 steering knuckles, dorman p/nos. 697-902 and 697-903, sold under dorman's oe solutionstm brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. a potential material or design defect could result in the steering knuckle breaking in the hub area. | |||||||||||||||
Consequence Summary | A broken steering knuckle could result in loss of steering control and a possible crash without warning. | |||||||||||||||
Corrective Summary | Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. the recall began on february 23, 2009. owners may contact dorman's toll-free hotline at 1-800-523-2492. | |||||||||||||||
Notes | This recall only pertains to aftermarket dorman steering knuckles and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STEERING | |||||
050232003 | 06/01/2005 | 10017515 | Revised outer tie rod end nut tightening specification/tie rod end jam nut tightening specification added. *tt | 11/09/2005 | |
040232001 | 08/01/2007 | 040232001C | 10012694 | Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07. *nj | 03/10/2005 |
040235004D | 11/01/2005 | 040235004C | 10008657 | Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt *nm | 08/13/2004 |
010232001C | 09/01/2003 | 010232001B | 10004280 | Some customers may comment on a clunk type noise coming from the front of the vehicle during a turning maneuver. *tt | 12/01/2003 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
01/12/2007 | 87000 | 1 | 07/12/2006 |
Tl* - the contact stated that while driving the 2003 pontiac grand prix on a sunny day at 35 mph a deer ran out in front of the vehicle he swerved in order not to hit the deer and ran into a tree. the air bag deployed, the car caught on fire and was consumed by the fire. he had a hard time getting out the driver's side door, it would not open. he had to crawl out through the back window. the failure mileage was 87000 miles.*ak |