Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 08089-B | 11/01/2008 | 08089-C | 10027804 | General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe | 02/09/2009 |
| 3571 | 10017152 | Power door lock inoperative. *sc | 10/25/2005 | ||
| 3042 | 3042A | 10009664 | Battery drain on vehicles equipped with power sliding doors. *tt | 10/14/2004 | |
| 02038 | 01/01/2004 | 10006946 | Diagnostic trouble code b1000. *mr | 05/20/2004 | |
| 01574 | 02/01/2009 | PI-01574A | 10005435 | Intermittent erratic instrument panel cluster (ipc) sweep with possible abs or sir lamp on. sit bulletin 1413054. *mn updated 8/12/09. *pe | 02/25/2004 |
| 030402 | 04/03/2002 | 636479 | Information regarding pilot program - electrical problems. *tt | 11/08/2002 | |
| 010604033 | 06/01/2001 | 623401 | Some customer may comment of various driveability symptoms such as malfunction indicator lamp illuminates intermittently, diagnostic trouble codes set, blown fuses. *tt | 10/29/2001 | |
| 110501 | 05/11/2001 | 619790 | Some customers may comment that the interior and / or the exterior lamps vary in intensity (flicker). *tt | 06/29/2001 | |
| 031000 | 10/03/2000 | 617683 | Subject regarding light flicker condition. *tt | 03/22/2001 | |
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| 08089-B | 11/01/2008 | 08089-C | 10027804 | General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe | 02/09/2009 |
| ELECTRICAL SYSTEM - WIRING | |||||
| 57 | 07/01/2003 | 10016464 | Wire harness may be stretched, or the pcs may not be oriented in the same position, after installing a service replacement valve body assembly. gm tech link. *tt | 09/13/2005 | |
| 01740 | 01/01/2004 | 10006270 | Cross injector wires causing misfire at steady state speed and rpm, malfunction indicator lamp (mil) illuminated, and a p0300 set. sit bulletin 1460291. *tt | 04/27/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 12/01/2005 | 95000 | ||
| Tl- the contact owns a 2001 pontiac montana. the contact stated that the fuel gauge was reading inaccurately and she was unable to determine how much fuel was actually in the vehicle. the dealer advised the contact of a remedy for the failure however, the contact was unable to identify what the remedy consisted of. the manufacturer was made aware of the failure. no repairs were performed. the current mileage was 160,000 and the approximate failure mileage was 95,000. kmj | |||
| 12/01/2005 | 95000 | ||
| Tl-the contact owns a 2001 pontiac montana. the contact stated that the gas gauge was reading inaccurately and she was unable to determine how much gas was actually in the vehicle. the dealer advised the contact of a remedy for repair; however, the contact was unable to identify what the remedy consisted of. the manufacturer was aware of the failure. no repairs were performed. the current mileage was 160,000. the approximate failure mileage was 95,000. bw | |||
| 05/24/2011 | |||
| Tl* the contact owns a 2001 pontiac montana. the contact stated that the vehicle was experiencing failures within the elextrical system, which was causing the cruise control, anti lock braking system, and speed sensor to fail. as a result, the transaction and air bag lights would illuminate on the instrument panel. the vehicle was taken to an authorized dealer and the contact was informed that the failure was related to the failure addressed in the recall associated with nhtsa campaign id number 02v329000 (air bags frontal). the contact was also informed that the check valve pin for the air bags was in the wiring harness and causing all of the failures. the vehicle was not included in the recall. the failure mileage was unknown and the current mileage was 180,000. | |||
| 05/24/2011 | |||
| Tl-the contact owns a 2001 pontiac montana. the contact stated that the vehicle was experiencing failures within the elextrical system, which was causing the cruise control, anti lock braking system, and speed sensor to fail. as a result, the transaction and air bag lights would illuminate on the instrument panel. the vehicle was taken to an authorized dealer and the contact was informed that the failure was related to the failure addressed in the recall associated with nhtsa campaign id number 02v329000 (air bags frontal). the contact was also informed that the check valve pin for the air bags was in the wiring harness and causing all of the failures. the vehicle was not included in the recall. the failure mileage was unknown and the current mileage was 180,000. sm. | |||
| 05/24/2011 | |||
| Tl- the contact owns a 2001 pontiac montana. the contact stated the vehicle is having problems with the electric system that is causing problems with the cruise control, anti-lock breaking system and the speed sensor on the vehicle. this failure causes the transaction and air bag light to illuminate on the instrument panel. the contact took the vehicle to the dealer and was told that nhtsa recall campaign id number: 02v329000 (air bags frontal) was causing the failure, but the vehicle was not included. the dealer explained that the check valve pin to the air bag is in the wiring harness and it causing the other failures on the vehicle. the failure mileage was unknown, but the current mileage was 180,000.rl | |||
| 02/03/2010 | 112438 | ||
| Service traction light stays on. turn signal lights blinked really fast and they light up everytime i push on the break. replaced brakes. problem caused tail lamp circuit board and light bulbs to burn out and melt connectors. was unable to drive the vehicle because people on the road would not know when i was breaking and could possibly run into me. nocking sound on right wheel and steering wheel is loose. replaced stabilizers and sensors, rotated and balnced wheels. scared that i may loose control of the car because it causes the the traction to turn off and the vehicle slides which could lead to a multi-car accident. it also needs new shocks; they are leaking. vehicle is running hot and is eating up the coolant. have already put 2 gallons in the vehicle since sept. water pump is leaking. passenger window keeps getting stuck. dealership says that the door needs to be replaced because it is an electrical issue. the majority of the problems that i am having are due to electrical issues. if you google problems with this particular model, you will find that the complaints are regarding the same issues that i have stated. i am low income and cannot afford to keep spending money to hypothesize what is the cause. i need gm to find out what is wrong with this vehicle. i can't get out of my contract and this vehicle is a road hazard. i noticed the issue with the door the same that i test drove the vehicle. the dealership refused to repair it even though it was on the inspection report. still disputing issue with them. i noticed the problem with the wheel in april and have been constantly taking it back every since the first repair was done. | |||
| 03/31/2009 | 78000 | 1 | |
| Hello on 3/31/09 my 2001 pontiac montana caught on fire while driving on i-88 highway with 60 miles per hour. the smoke filled the car and fire was shooting up at the back window while driving this vehicle. apparently an electrical shortage at the windshield viper has started the fire. *tr | |||
| 04/01/2008 | 92903 | 1 | 05/20/2007 |
| The vehicle had an electrical system failure and burst into flames. the vehicle was parked at 7:30 am on march 31, 2008. at 12:50 am on april 1,2008 the horn started blaring and there were flames coming from the dash. the police and fire department said they think that a relay in the dash shorted out and caught fire. this could have happened with people in the vehicle.... *tr | |||
| 03/15/2006 | 70079 | 2 | 09/04/2004 |
| Our service engine light came on and also the change oil, light won't turn off. after, a year of seeing this on (yes, we have our oil changed.) it has become annoying seeing this on all the time. the abs light won't turn off as well. (nothing wrong) we have the mileage reading in kilometers, which we cannot change back. we're having problems with this and had this serviced by our mechanic. still the problem hasn't vanished from our panel. the thermostat temp. gauge on the panel wasn't increasing while driving or parked and still running ( on 0 ) and service engine light came on for that .had obd reading on that , it read we had to change our thermostat. several days later, the temp. began to work properly again . the service light went away. we disconnected battery four times and still having problems. is there an electrical problem? same with the window switches, too. *nm | |||
| 03/02/2006 | 6 | 06/27/2001 | |
| Power sliding doors open at any given time, whether at slow speeds, or high speeds. electrical problems with horn, and lights operating intermittently. this is happening on a 2001 pontiac montana van, purchased new in 2001. sliding door problem definitely constitutes a major liability, in as much as a person can fall out when the door opens. *jb | |||
| 06/02/2005 | 55162 | 1 | 03/29/2003 |
| The air conditioner did not work when we turned it on this summer. we took it in to be looked at and paid $72.00 for them to tell us that the condensor was shot and needed to be replaced. the cost was estimated to be $950.00 and after it was actually replaced it cost us $880.00. i am very disappointed that this part is defective and so costly. | |||
| 01/01/2005 | 1 | 10/24/2003 | |
| The vehicle's traction control light illuminated on the dash intermittently. *nm the traction control system needed to be repaired. *sc | |||
| 01/23/2001 | 500 | 4 | 06/27/2001 |
| The vehicle alarm would sound intermittently throughout the day and night. the dealer had examined the vehicle four times trying to find the problem. *jb the vehicle's headlights also came on by themselves. the consumer is concerned that the vehicle may catch on fire. the dealer installed an alarm module but the problem recurred. the consumer contacted the manufacturer but they were unable to offer any assistance. *nm | |||
| 03/05/2004 | 0 | 07/14/2002 | |
| Electrical system is malfunctioning. rear windows half open and will not close. front windows will open, but will not close. lights (internal and external) will flicker if i turn on the radio, windshield wipers, raise or lower windows. locks will engage and disengage on their own over and over again, even if the vehicle is at rest. brakes are constantly going bad. i have had to get the brakes fixed 4 times in the past 18 months. a/c is not working. no cold air comes out, only heat.*ak | |||
| 3060 | 1 | 03/01/2002 | |
| Gas leaking under the driver seat and under the hood. also, gas was pouring out from the motor. *la the window failed to open, the consumer is currently waiting on a new motor. the rear brakes were leaking, the tie rods had to be replaced because they were loose, the left rear stuck became stuck, when the gear was taken out of park and placed into drive and the consumer proceeded to accelerate the vehicle jerked, the engine light illuminated, the dealer determined the emission system was dragging, the driver side mirror vibrated, the bumper cover was loose. when the consumer attempted to turn the key in the ignition, the vehicle did not start, the dealer was unable to duplicate the consumer's concern. the fuel pressure regulator was leaking and the fuel filter was replaced. the vehicle would not go over 10 mph, the vehicle shifted and then returned to normal speed. the plastic on the drivers seat was loose. *jb | |||
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
| 09/01/2000 | |||
| While driving at night headlights and interior lights would occasionaly dim. dealer has advised consumer that defect was due to generator that dropped power from control module, but did not have a remedy. *ak | |||
| ELECTRICAL SYSTEM - BATTERY | |||
| 07/20/2001 | 1 | ||
| Vehicle was rented from a national car rental agency. engine stalled while accelerating just after decelerating at red light changing to green. battery charging system light was illuminated. resulted in accelerator and brake failure. vehicle was brought to a stop using emergency foot brake. no accident or injury. car restarted and functioned normally several minutes later. *ak | |||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||
| 02/01/2001 | 20 | 01/01/2001 | |
| Consumer stated left side brake light failed. found that the circuit board malfunctioned and burned out. consumer took the vehicle to the dealer. consumer was waiting for parts for the vehicle.*ak ordered brake light circuit board on feb. 25th as of april 12th the part has not come in. *bf *nm | |||
| 07/06/2001 | 1 | 03/13/2001 | |
| June 16, 2001 while driving in parking lot vehicle shutoff and did not restart. vehicle was towed to dealer. dealer wrote on invoice wiring starting relay to pcm/and fuses were bad. on july 3 same defect occurred in parking lot, vehicle shut off. towed to dealer . *ak *slc | |||
| 09/01/2000 | |||
| While driving at night headlights and interior lights would occasionaly dim. dealer has advised consumer that defect was due to generator that dropped power from control module, but did not have a remedy. *ak | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 07/15/2003 | 20000 | 1 | 06/30/2001 |
| I was coming back from pennsylvania to north carolina in july from a trip and when i arrived at my destination. i shut the car off and took the key out of the ignition, and i could not get out the car, did not unlock on its own. when i did get the car door open the radio was still playing, the windows were going up and down, and the on star was still on it was like that for 2 hours. when i finally got home from my friends house the same thing happened... we did hit a huge rain storm the whole way down. i have taking it to the dealership (brian pontiac), and they can not reproduce the problem. *ak | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| 50 | 09/01/2000 | ||
| Horn sounds on its own while driving, with no input from driver. also, alarm sounds (usually only 4 times) for no reason even when no one is near vehicle if key is used to lock the doors, as if it was susceptible to electrical interference. dealer can not find cause of problem. dt | |||
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
| 50 | 09/01/2000 | ||
| Horn sounds on its own while driving, with no input from driver. also, alarm sounds (usually only 4 times) for no reason even when no one is near vehicle if key is used to lock the doors, as if it was susceptible to electrical interference. dealer can not find cause of problem. dt | |||
| 08/28/2002 | 1 | 07/01/2001 | |
| I think there must be some electrical malfunction in my van's wiring. i would like to know if other's have reported such trouble. this first started with my turn signals. they would come on by themselves while i was driving. either the right or left or sometimes both would just start blinking, or nothing would show on the dash column but you could hear the clicking. that was 02/02. on august 28,2002 i had just started the van and pulled away from my daughter's school when a small stream of smoke begin to leak from the odometer area of the dash. the dealer is just across the highway so i decided to try and make it. i had not even gone a block before white smoke had filled the front cabin area and was filling the van. i pulled over shut off the ignition, got my 2 children out and called the dealer for help. they think when i turned off the switch the fire went out. i waited 30 minutes for them to come across the street to get me but no one showed. the man at the body shop where i stopped took us over to the dealer. they now say the cluster shorted out and has been replaced with a new one. they also say they have sprayed to help the smoke smell. they insist the van is safe but i do not feel like taking a chance with my children in the van. i would like to know if you have had any similar reports because pontiac says this is the first they have heard of such. please give me your opinion on my van's safety. i am very worried about the van's long term life.*ak | |||