Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STEERING | ||||||||||||||||
08E063000 | DORMAN PRODUCTS, INC. | E (Equipment) | 3855 | 10/16/2008 | MFR | GENERAL MOTORS CORP. | 10/17/2008 | 10/20/2008 | ||||||||
Defect Summary | Dorman products is recalling 3,900 intermediate steering shafts dorman part nos. 425-151, 425-152, and 425-153, (sold under dorman's oe solutions brand name), balkamp #'s 7-3057, 7-3058, 7-3059 (sold under the napa brand name), and platinum parts #'s 2425151, 2425152, and 2425153 manufactured during the month of september 2007. these replacement steering shafts can be used on the vehicles listed above. the weld connecting the inner tube to the outer tube may be defective. | |||||||||||||||
Consequence Summary | If the weld fails, loss of steering could result, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Dorman will notify owners and replace the steering shafts free of charge. the recall began on october 16, 2008. owners may contact dorman toll free at 1-800-523-2492. | |||||||||||||||
Notes | This recall only pertains to dorman's oe solutions brand name, balkamp's napa brand, and the platinum brand steering shafts and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STEERING | |||||
010232001F | 02/01/2006 | 10019516 | Clunk felt/noise heard from steering column, steering gear and/or front of vehicle during turning maneuver and/or steering wheel rotation. *tt | 03/21/2006 | |
040235004D | 11/01/2005 | 040235004C | 10008657 | Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt *nm | 08/13/2004 |
010232001C | 09/01/2003 | 010232001B | 10004280 | Some customers may comment on a clunk type noise coming from the front of the vehicle during a turning maneuver. *tt | 12/01/2003 |
020232012A | 06/01/2003 | 020232012 | 10002834 | Rattle/knock noise when turning while driving over rough roads. *tt | 09/26/2003 |
020232012 | 10/01/2002 | 10000176 | Rattle / knock noise when turning while driving over rough roads. *tt | 02/14/2003 | |
010232001B | 07/01/2002 | 010203001A | 634803 | Some customers may comment on a clunk type noise coming from the front of the vehicle during a turning maneuver. *tt | 10/09/2002 |
051101 | 11/05/2001 | 628094 | Some vehicles may exhibit a clunk type noise especially felt in the steering wheel while turning. *tt | 03/05/2002 | |
150900 | 09/15/2000 | 619039 | This message concerns vehicles exhibiting a clunk noise coming from the front of the vehicle. customers may state that a clunk noise is heard when turning the steering wheel. *tt | 05/11/2001 | |
180101 | 01/18/2001 | 618179 | Information on diagnosing clunk or bump noise usually heard when turning emitting from the front of the vehicle. this condition may also be felt through the steering wheel of vehicle with the car in park or moving slowly and the steering | 04/06/2001 | |
020601 | 02/06/2001 | 618119 | Customers may complain of a clunk noise from front end of the vehicle during turning maneuvers or steering wheel rotation. *jb | 04/04/2001 | |
01-02-32-001 | 04/01/2008 | 010232001O | 618086 | Concerns with clunk noise from front of vehicle turning maneuver / steering wheel rotation.*jb (lubricate or replace intermediate shaft as appropriate). updated 10/05/07. *nj updated 4/1/08. *nj updated 7/1/2008 *pe | 04/03/2001 |
STEERING - COLUMN | |||||
070232006 | 08/01/2007 | 10022926 | Clunk felt/noise heard from steering column, steering gear and/or front of vehicle during turning maneuver and/or steering wheel rotation (lubricate intermediate shaft [i-shaft]). *nj | 10/05/2007 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STEERING | |||
04/15/2004 | 1 | ||
While driving it was hard to turn left/right. dealership was notified, but did not resolve the problem. *ak | |||
STEERING - COLUMN LOCKING - ANTI-THEFT DEVICE | |||
06/11/2004 | 1 | ||
Daughter was traveling down interstate and steering wheel locked up. she was unable to control car so she pulled and jerked the wheel. in doing so when the steering unfroze her car rolled over twice. car was totaled. we advised gm, who told us they would investigate. at this time they are admiting to finding no problem.*ak | |||
STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
10/29/2001 | 26 | 01/16/2001 | |
Exhaust system was replaced due to it getting hot melting the carpet and paint inside trunk, fumes filled interior of vehicle at this time exhaust system is running just as hot again, dealer stated factory representative instructed him not to do anything about the exhaust system, there was nothing that could be done.*ak consumer states the vehicle has bad gas mileage, starter motor seized and failed, power steering fluid was leaking, coolant was leaking from left front and back of the vehicle, replaced radiator, heater blows cold air at idle, trunk leaks, head lamp is out of adjustment, glove box will not close, muffler fell off, key comes out of ignition with vehicle running, transmission has no reverse, there was brake pulsation at high speed or when stopping, brake pedal goes to floor, speakers inoperative, seat spring failed, suspected motor oil smell and replaced thermostat, horn was inoperative, power and grounds distribution replaced, window will not go down all the way, found window regulator failed, hazard lamps and turn signal were inoperative, replaced blown fuse, cigarette lighter inoperative, replaced blown fuse, traction control inoperative, engine light comes on, a/c hose leaking, replaced evaporator, hard to start and rough idle, engine make rattling noise and quit running, replaced head cylinder and 02 sensor, vehicle pulls to the left, overflow bottle melted and 42 goodyear tires blew out, also the hvac was inoperative. *yd | |||
STEERING - RACK AND PINION | |||
10/01/2000 | 2 | 02/01/2000 | |
No summary listed for above vehicle. *ak | |||
STEERING - WHEEL AND HANDLE BAR | |||
08/24/2002 | |||
The leather is separating on steering wheel, exposing internalt materials. please describe details. *ak | |||
10/29/2001 | 26 | 01/16/2001 | |
Exhaust system was replaced due to it getting hot melting the carpet and paint inside trunk, fumes filled interior of vehicle at this time exhaust system is running just as hot again, dealer stated factory representative instructed him not to do anything about the exhaust system, there was nothing that could be done.*ak consumer states the vehicle has bad gas mileage, starter motor seized and failed, power steering fluid was leaking, coolant was leaking from left front and back of the vehicle, replaced radiator, heater blows cold air at idle, trunk leaks, head lamp is out of adjustment, glove box will not close, muffler fell off, key comes out of ignition with vehicle running, transmission has no reverse, there was brake pulsation at high speed or when stopping, brake pedal goes to floor, speakers inoperative, seat spring failed, suspected motor oil smell and replaced thermostat, horn was inoperative, power and grounds distribution replaced, window will not go down all the way, found window regulator failed, hazard lamps and turn signal were inoperative, replaced blown fuse, cigarette lighter inoperative, replaced blown fuse, traction control inoperative, engine light comes on, a/c hose leaking, replaced evaporator, hard to start and rough idle, engine make rattling noise and quit running, replaced head cylinder and 02 sensor, vehicle pulls to the left, overflow bottle melted and 42 goodyear tires blew out, also the hvac was inoperative. *yd |