Suzuki Aerio 2005
Model Aerio made in 2005 by Suzuki got 35 consumer complains there is 1 recall as well as 7 service bulletins. Consumer complaints with reference, among others things, to air bags, engine and engine cooling and exterior lighting. Technical service bulletines regarding engine and engine cooling, equipment and power train. There was one recall concerning power train . The car has one 2.3 engine.
Model 2005
| Engine [L] | Cylinders | Transmission | Drive | Estimate MPG (city/highway/combined) | Unadjusted MPG (city/highway/combined) | Fuel | Fuel cost | Class | Release date |
|---|---|---|---|---|---|---|---|---|---|
| 2.3 | 4 | Lockup/automatic, 4 gears | F | 25/31/27 | 27.8973/39.5/32.1465 | Regular | 999 | COMPACT CARS | |
| 2.3 | 4 | Manual, 5 gears | F | 25/31/27 | 27.8/39.6581/32.1222 | Regular | 999 | COMPACT CARS | |
| 2.3 | 4 | Lockup/automatic, 4 gears | 4 | 24/29/26 | 26.3996/36.6494/30.2004 | Regular | 1040 | COMPACT CARS | |
| 2.3 | 4 | Lockup/automatic, 4 gears | F | 25/30/27 | 27.5/39.1/31.737 | Regular | 999 | SMALL STATION WAGONS | |
| 2.3 | 4 | Manual, 5 gears | F | 25/31/27 | 27.8/39.6/32.105 | Regular | 999 | SMALL STATION WAGONS | |
| 2.3 | 4 | Lockup/automatic, 4 gears | 4 | 24/29/26 | 26.3996/36.6494/30.2004 | Regular | 1040 | SMALL STATION WAGONS |
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| POWER TRAIN - MANUAL TRANSMISSION | ||||||||||||||||
| 07V307000 | AMERICAN SUZUKI MOTOR CORP. | V (Vehicle) | 14251 | 08/13/2007 | MFR | AMERICAN SUZUKI MOTOR CORP. | 07/15/2007 | 07/19/2007 | ||||||||
| Defect Summary | On certain vehicles equipped with 5-speed manual transmissions, due to improper shape of the clip, the retaining clip that keeps the gear shift cable attached to the gear shift lever can contact the gear shift lever housing if excessive lateral force is applied when shifting to first gear. | |||||||||||||||
| Consequence Summary | Repeated shifting in this manner can eventually cause the retaining clip to break. if the retaining clip breaks, the shift cable can become disconnected from the shift lever, resulting in loss of the ability to change transmission gears. | |||||||||||||||
| Corrective Summary | Dealers will replace the gear shift cable retaining clip with a clip that has a different shape. the recall began on august 13, 2007. owners may contact american suzuki at 1-800-934-0934. | |||||||||||||||
| Notes | Suzuki recall no. mu.customers may also contact the national highway traffic safety administration | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 0405175 | 10015909 | Modification of main bearing oil clearance and the bearing selection procedure. 2002-2005 suzuki aero-rh420/rh423 *sc | 08/16/2005 | ||
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0903296 | 10019618 | No tachometer indication and/or mil on; dtc p0727 (engine speed input circuit no signal). *tt | 04/05/2006 | ||
| EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
| 0304145 | 10014812 | Service manual correction of alignment specifications. *eh | 05/10/2005 | ||
| POWER TRAIN - MANUAL TRANSMISSION | |||||
| TSB-05-04289 | 05/01/2009 | 10028704 | Suzuki: parts list for repairing manual transaxle 5th gear concerns such as popping out of gear while driving. worn or failed 5th gear synchronizer, 5th gear, and related parts. *pe | 05/18/2009 | |
| SUSPENSION | |||||
| 0401126R | 10019165 | Clunking noise from under the vehicle. *tt | 02/15/2006 | ||
| 0211225 | 10018529 | Abnormal rear tire wear. *tt | 01/05/2006 | ||
| TIRES | |||||
| 0211225 | 10018529 | Abnormal rear tire wear. *tt | 01/05/2006 | ||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| AIR BAGS | |||
| 11/27/2007 | 1 | 06/09/2005 | |
| Module for the airbag system located a foot away from a cup holder which if there is a spilled a module will not work. *tr | |||
| AIR BAGS - FRONTAL - DRIVER SIDE INFLATOR MODULE | |||
| 11/02/2005 | 1 | ||
| Bright sunny day and i was driving and a loud pop occurred. i pulled off and discovered my side air bag had deployed without a accident of any sorts. *jb | |||
| ENGINE AND ENGINE COOLING | |||
| 12/07/2007 | 36000 | 1 | 11/16/2006 |
| Tl*the contact owns a 2005 suzuki aerio. during early morning hours, the contact's vehicle caught fire and exploded. the vehicle was thrown ten feet into the air. a police report was filed. the arson investigator stated that the fire originated in the engine compartment. the contact called suzuki, but has not received a response. the current and failure mileages were 36,000. | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 01/28/2011 | 79042 | ||
| Tl-the contact owns a 2005 suzuki aerio. while driving approximately 65 mph after purchasing the vehicle the temperature gauge began to go up and down. she stated later another indicator came on letting her know that the vehicle had overheated. she stopped and added water to the radiator. after adding water a cloud of white smoke was all over the engine area. the vehicle was towed to her residence since the dealer was closed. the dealer later towed the vehicle back to the dealership. the vehicle had not been repaired yet. the failure mileage was 79,042 and the current mileage was 79,142. vwb | |||
| EXTERIOR LIGHTING | |||
| 01/01/1901 | 2 | ||
| 2005 suzuki aerio with lighting problems. customer states that there is something wrong with the lighting in the vehicle. *kb | |||
| OTHER | |||
| 10/21/2005 | 1041 | 1 | 09/15/2005 |
| 2005 suzuki aerio stalled when going through a puddle of water. mechanic released vehicle to the consumer with a non working airbag. vehicle has yet to be repaired by the mechanic. *kb when the consumer drove through the water, it damaged the engine. *jb | |||
| POWER TRAIN | |||
| 07/11/2011 | 81970 | ||
| Tl - the contact owns a 2005 suzuki aerio. the contact stated that while attempting to make a turn both axles fractured. the contact mentioned that the failure occurred twice before. the vehicle was taken to the dealer who decided to replace the tie rod, front suspension, the drive shaft and the entire front axle system. the manufacturer was made aware of the failure who did not offer any assistance. the vehicle was not repaired. the failure mileage was 81,970 and the current mileage was 94,653. pmb | |||
| POWER TRAIN - DRIVELINE | |||
| 12/22/2008 | 80000 | ||
| Tl*the contact owns a 2005 suzuki aerio. while driving 45 mph he heard a loud jolting noise. he stopped the vehicle and observed there was a burning smell under the hood. he was able to restart the vehicle and he drove it to a repair shop. the mechanic diagnosed the vehicle and stated that there was an internal hole in the differential. the vehicle has not been repaired. the failure and current mileage was 80000. | |||
| SERVICE BRAKES, AIR - DISC - PADS | |||
| 08/07/2006 | 09/07/2005 | ||
| I bought my 2005 suzuki aerio a year ago, brand new with only 500 miles on it. in 9 months with only 21,000 miles on it, i have had to replace 3 sets of brakes on the vehicle and a whole new set of tires. | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 12/12/2005 | 10600 | 3 | 12/29/2004 |
| I purchased my aerio 2005 suzuki dec 2004, in nov 2005 tires worn prematurely on 10,503 mileage, front brakes pads and rotors has to be replaced. i took car to dealership:replaced pads, mashined rotors and aligned/replaced one tire. month later i come back to dealership with the problem to stop the car on the speed 15ml/h: push the brakes pedal to the floor, car did not stoped. mechanik drive car, check the brakes and said brakes working fine as it is has to work as abs system, but my car does not has abs system. sep.2006 i did inspection with change oil service. result of inspection the same as was in nov 2005: alignment, tires worn out, brake pads and rotors need to be replaced and it is after 7,000 ml i add after the first replacement. dealership algned and balance, replaced one tire again, about brakes declined, said is not warranty issue. my car has only 18,000 mileage and 100,000 warranty. brake system is failed and alignment cost the tires primature worn out. *nm | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 11/01/2005 | 8000 | 1 | 07/01/2005 |
| Dt: the contact stated there was excessive brake wear at very low mileage. he took the vehicle to the dealer for evaluation and repair. the dealer could not determine the cause of the problem. the dealer suggested a replacement of the front brakes. he contacted the manufacturer, and they offered no repair cost assistance. this repair was not covered under warranty. no repairs were done at this time due to excessive expense. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
| 05/17/2005 | 6013 | 1 | 12/09/2004 |
| Dt: in middle of nigh,t no weather problems, and without warning the brakes failed. had to stand on brakes, and had to pull emergency brake to stop. and when he got out he saw the front drivers side wheel well was glowing and smoking. both manufacturer and dealer said it was not a defect. caller followed maintenance routine. dealer found the brake pads were bad.*ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
| 05/17/2005 | 6013 | 1 | 12/09/2004 |
| Dt: in middle of nigh,t no weather problems, and without warning the brakes failed. had to stand on brakes, and had to pull emergency brake to stop. and when he got out he saw the front drivers side wheel well was glowing and smoking. both manufacturer and dealer said it was not a defect. caller followed maintenance routine. dealer found the brake pads were bad.*ak | |||
| SUSPENSION | |||
| 01/12/2007 | 11295 | 2 | 09/24/2005 |
| When my vehicle had 11,295 miles on it i had to replace the tires as they had excessive wear. the viscous coupling was replaced and the alignment was changed per my work order as recommended by the ts bulletin 11225. now my car has 30,000 miles on it and i have to replace my tires again. obviously there is something wrong with the manufacturing of the vehicle itself as to cause two set of tires to be worn bare after only 30,000 miles. dealership worked with me on first set, they are unsure about whether they will help with the second set, although the vehicle is still under its 36,000 mile warranty. i am very worried about keeping the vehicle if i will have to get new tires every 10-20,000 miles and the car manufacturer is not willing to fix the vehicles. i do not feel safe driving my vehicle knowing that the tires are wearing down excessively and no one seems to know the cause. *nm | |||
| 03/10/2006 | 900 | 1 | 01/14/2006 |
| Dt*: the contact stated while driving the vehicle shakes. it was taken to the dealership where they determined the stabilizer bushing, bracket and mount stabilizer needed to be replaced. updated 4/11/2006 - *nm | |||
| 02/01/2006 | 9700 | 1 | 10/17/2005 |
| Dt*: the contact stated both rear tires had excessive wear and flat spots completely around the tires. the vehicle was taken to the local dealership for inspection. the dealership personnel determined the tire wear was contributed by the couplers on the rear struts. the couplers were defective when manufactured. however, no repairs were made because parts were not available. | |||
| SUSPENSION - FRONT | |||
| 09/10/2010 | 70235 | ||
| Tl- the contact owns a 2005 suzuki aerio. while the contact attempted to park the vehicle the front axle universal joint broke causing extensive damage to the vehicle front end. the vehicle was towed to the garage diagnosed located a defected designed that caused the axle to fail. the manufacturer took a report 2-236606323. the manufacturer wasn't sure if the repair will be covered under the warranty. the vehicle wasn't repaired. the failure and the current mileage were 70,235. li | |||
| 02/07/2008 | 39105 | 2 | 01/06/2004 |
| Front suspension is shot and vehicle is inoperable 1 month after 3-year warranty expired (recommended not safe for travel by service manager). only 39,000 miles on vehicle. service requires new complete strut assemblies for both front-left and front-right struts, and 6 new tires over course of three years. *tr | |||
| 09/01/2006 | 17598 | 1 | 06/23/2005 |
| Dt*: the contact stated the vehicle's front end vibrated and pulled to the left at various speeds, although the problem was more noticeable while driving 55 mph. the problem may have caused the bald spot of the outside of the front tire. the service dealer and manufacturer were notified. | |||
| SUSPENSION - FRONT - MACPHERSON STRUT | |||
| 02/01/2006 | 9700 | 1 | 10/17/2005 |
| Dt*: the contact stated both rear tires had excessive wear and flat spots completely around the tires. the vehicle was taken to the local dealership for inspection. the dealership personnel determined the tire wear was contributed by the couplers on the rear struts. the couplers were defective when manufactured. however, no repairs were made because parts were not available. | |||
| SUSPENSION - REAR | |||
| 05/30/2007 | 29850 | 1 | 12/22/2004 |
| After i bought my car (in late december 2004), i noticed that the rear-end twitched (very slight swings to the left & right that quickly re-grabbed the road after losing traction). this occurred every time the roads were wet or slippery, and i used it as a signal to slow down. this twitching got worse as the tires wore down, and i had replaced the rear-tires 8 months ago, and got an alignment as well. i was driving southbound on minnesota highway 77, approaching the minnesota river bridge (mile marker 7). a rainstorm had gone by earlier, so the road was wet. i had slowed down, because the car's rear-end was twitching again, and it stopped twitching, and it wasn't twitching around when i got to the bridge. as i crossed the bridge, the rear-end let go, and the car (and i) crashed into the bridges safety median, nose first. the car didn't do any twitching for the 3 minutes prior to getting onto the bridge. as a result of the rear-end letting, the car is totaled, and i was injured. *tr | |||
| TIRES | |||
| 09/09/2006 | 1 | ||
| I had to replace all four tires when the car only had slightly more that 20,000 km. *jb | |||
| 08/07/2006 | 09/07/2005 | ||
| I bought my 2005 suzuki aerio a year ago, brand new with only 500 miles on it. in 9 months with only 21,000 miles on it, i have had to replace 3 sets of brakes on the vehicle and a whole new set of tires. | |||
| UNKNOWN OR OTHER | |||
| 08/22/2010 | |||
| 2005 suzuki aerio sx, unit 1 tire blew out. unit 1 moved into right lane striking unit 2. unit 1 drove off the left side striking the median barrier bounced off that into the right side striking the guardrail. *bf | |||
| VEHICLE SPEED CONTROL | |||
| 04/05/2010 | 0 | ||
| Tl* the contact owns a 2005 suzuki aerio. the contact stated that while driving at approximately 65 mph, the vehicle accelerated to 80 mph. the contact then applied the brake and the vehicle decelerated and caught fire. the contact stated that it was an engine compartment fire, but flames came from the rear end of the vehicle. the vehicle was towed by the owners insurance company. the vehicle has not been to the dealer for diagnostic and testing. the contact stated that the weather was not a factor. the approximate failure mileage was unknown. the current mileage was unknown. | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| CA | RIVERSIDE | SUKUKI OF RIVERSIDE | ||
| FL | FORT LAUDERDALE | AUTO MALL | ||
| FL | JACKSONVILLE | 32225 | CITY SUZUKI | |
| GA | DULUTH | 30096 | GWINNETT SUZUKI | 770-817-3333 |
| IL | OAK LAWN | WEBB SUZUKI | ||
| MN | DULUTH | DULUTH DODGE/SUZUKI/MITSUBISHI | 218-720-6123 | |
| MN | ROCHESTER | 55901 | KUEHN MOTOR COMPANY | 5072827700 |
| MS | OLIVE BRANCH | 38654 | HENSLEY SUZUKI | |
| NE | OMAHA | 68137 | EDWARD ARCHER | 402 891 1100 |
| NE | OMAHA | 68137 | EDWARDS ARCHER SUZUKI | 877-789-8541 |
| PR | MAYAGUEZ | 00680 | AUTOLAND | 787-652-4000 |
| PW | PHILADELPHIA | 19135 | DESIMONE SUZUKI | 215-744-6400 |