Suzuki Gsx-r600 2008
Model Gsx-r600 made in 2008 by Suzuki got 10 consumer complains as well as 1 recall. Consumer complaints with reference, among others things, to electrical system and engine and engine cooling. There was one recall concerning electrical system .
Model 2008
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
11V108000 | AMERICAN SUZUKI MOTOR CORP. | from 10/01/2007 to 06/30/2008 | V (Vehicle) | 73426 | 03/02/2011 | MFR | AMERICAN SUZUKI MOTOR CORP. | 02/23/2011 | 02/23/2011 | |||||||
Defect Summary | Suzuki is recalling certain model year 2008 through 2010 motorcycles manufactured from july 2007 through september 2009, equipped with regulator/rectifier assemblies, suzuki part numbers 32800-41f11, 32800-15h10, 32800-05h11, 32800-41g10, 32800-15h00, 32800-18h00, 32800-05g10, 32800-10g10, 32800-05h20, or 32800-06g01. some regulator/rectifier assemblies were produced with insufficient adhesion between the power module (circuit board) and the rectifier case that contains a heat sink to dissipate heat. due to insufficient adhesion, heat generated on the power module circuit board can cause the circuit board to deform, and lift of the case. | |||||||||||||||
Consequence Summary | This condition causes excessive heat on the circuit board and uncontrolled electric current output, which can result in insufficient charging current being provided to the motorcycle battery. this can cause discharge of the battery and can lead to engine stalling and/or a no-start condition. engine stalling while riding can increase the risk of a crash. | |||||||||||||||
Corrective Summary | Suzuki will notify owners and suzuki distributors will replace the regulator/rectifier with an improved part free of charge. the safety recall is expected to begin during march 2011. owners may contact suzuki at 1-714-572-1490. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
07/01/2009 | 4 | ||
2008 suzuki gsx-r600. consumer states electric problem with bike. *tgw the consumer stated the bike has been to the dealer four times for problems with the starter/ voltage regulator and the bike continues to cut off. *jb | |||
ENGINE AND ENGINE COOLING | |||
06/01/2011 | 8700 | ||
Tl-the contact owned a 2008 suzuki gsx-r600. the contact stated that while driving approximately 30 mph the vehicle stalled. as a result, the vehicle tipped over and was involved in a single vehicle crash. a police report was not filed. the contact went to the hospital to treat serious injuries. the vehicle was destroyed and towed to an insurance yard. the failure was not diagnosed. the failure and current mileages were 8,700. sm. | |||
VEHICLE SPEED CONTROL | |||
10/15/2008 | 800 | 1 | |
Riding my '08 suzuki gsxr-600 per normal operation, i notice that it starts to lose power. this is a vehicle that has just over 1000 miles (barely past break-in) and is less than 6 mos old. when i try to roll on more throttle, there is 0 response from the machine. it then arbitrarily 'kicks in' which gives the same sort of response as popping the clutch. this happens only after the vehicle is warmed up to normal operating temps. once it happens, it continues to happen, somewhat intermittently but often. this behavior has caused me to almost wreck in a curve more than once. general user consensus at www.gixxer.com (foremost online bulletin board for suzuki gsxr owners and riders) is that it is the throttle position sensor that is defective. this is the same unit that is on the yamaha r series and that unit has been recalled by yamaha. *tr |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
MS | PEARL | 39208 | JACKSON MOTOR SPORTS | 601-933-1145 |