Suzuki Sfv650
Model Sfv650 made by Suzuki got 11 consumer complains as well as 1 recall. Consumer complaints with reference to electrical system. . There was one recall concerning electrical system .
Model 2009
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
11V108000 | AMERICAN SUZUKI MOTOR CORP. | from 12/01/2008 to 04/30/2009 | V (Vehicle) | 73426 | 03/02/2011 | MFR | AMERICAN SUZUKI MOTOR CORP. | 02/23/2011 | 02/23/2011 | |||||||
Defect Summary | Suzuki is recalling certain model year 2008 through 2010 motorcycles manufactured from july 2007 through september 2009, equipped with regulator/rectifier assemblies, suzuki part numbers 32800-41f11, 32800-15h10, 32800-05h11, 32800-41g10, 32800-15h00, 32800-18h00, 32800-05g10, 32800-10g10, 32800-05h20, or 32800-06g01. some regulator/rectifier assemblies were produced with insufficient adhesion between the power module (circuit board) and the rectifier case that contains a heat sink to dissipate heat. due to insufficient adhesion, heat generated on the power module circuit board can cause the circuit board to deform, and lift of the case. | |||||||||||||||
Consequence Summary | This condition causes excessive heat on the circuit board and uncontrolled electric current output, which can result in insufficient charging current being provided to the motorcycle battery. this can cause discharge of the battery and can lead to engine stalling and/or a no-start condition. engine stalling while riding can increase the risk of a crash. | |||||||||||||||
Corrective Summary | Suzuki will notify owners and suzuki distributors will replace the regulator/rectifier with an improved part free of charge. the safety recall is expected to begin during march 2011. owners may contact suzuki at 1-714-572-1490. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
03/02/2011 | 1304 | ||
Tl* the contact owns a 2009 suzuki sfv650 motorcycle. the contact received notification of nhtsa recall campaign id number: 11v108000 (electrical system:alternator/generator/regulator). the dealer was contacted and advised that the voltage regulator that was needed for the repair was not readily available and would be ordered. one month later, the contact was still awaiting the arrival of parts and stated that the recall remedy has extended beyond a reasonable amount of time. the dealer had yet to contact him in regards to the part becoming available and the vehicle was not yet repaired. the failure mileage was 1,304. | |||
10/20/2010 | 95 | ||
Motorcycle unsafe to ride | |||
03/02/2011 | 1304 | ||
Tl. the contact owns a 2009 suzuki sfv650. the contact recevied a nhtsa recall notice 11v108000 (electrical system:alternator/generator/regulator). the contact called the dealer to set up a appointment and the dealer placed a order for a voltage regulator. the contact has not had the vehicle remedied at this time due to the part not being available. the contact has been waiting for the part of over a month but has not received a response from the dealer. the contact stated this recall should have been repaired in a reasonable time since the vehicle can cause a crash. the failure mileage was 1,304. jo |