Suzuki Vl1500 2005
Model Vl1500 made in 2005 by Suzuki got 23 consumer complains, 1 investigation there is 1 recall as well as 1 service bulletin. Consumer complaints with reference, among others things, to electrical system, fuel system, gasoline and service brakes, hydraulic. Technical service bulletines regarding fuel system, gasoline. The car had one investigation (fuel system, gasoline). There was one recall concerning fuel system, gasoline .
Model 2005
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | ||||||||||||||||
06V025000 | AMERICAN SUZUKI MOTOR CORP. | from 04/01/2004 to 05/31/2005 | V (Vehicle) | 37911 | 02/03/2006 | ODI | AMERICAN SUZUKI MOTOR CORP. | 01/30/2006 | 01/31/2006 | |||||||
Defect Summary | On certain motorcycles, stress around the right front fuel tank mounting point can cause hairline fatigue cracks to form. this can result in a fuel leak. | |||||||||||||||
Consequence Summary | In the presence of an ignition source, a fuel leak can result in a fire. | |||||||||||||||
Corrective Summary | Dealers will inspect the fuel tank and install improved cushions that mount and support the fuel tank. any fuel tanks that are found to have a crack will be replaced. if a tank is found to have a crack and a replacement tank is not available, fuel tank sealant will be applied to the tank as an interim repair. when the replacement tank becomes available, the owner will be contacted and a replacement tank will be installed. the recall began on february 3, 2006. owners may contact suzuki at 1-714-572-1490. | |||||||||||||||
Notes | Suzuki recall no.2087. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
TSB-40A | 04/07/2009 | 10030069 | Suzuki motorcycle: repair instructions to be used in conjunction with the fuel tank inspection and replacement procedures. the demand for certain replacement fuel tanks has exceeded our production capacity. *pe | 07/29/2009 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | ||||||
PE05031 | AMERICAN SUZUKI MOTOR CORP. | 06/15/2005 | 02/01/2006 | FUEL LEAK | 06V025000 | |
Odi opened this pe after receiving fuel tank leak allegations from eight owners.subsequently, we met with both complaint motorcycle owners and owners of motorcycles which had not leaked fuel and inspected their motorcycles. we also discussed the matter with suzuki authorized dealership personnel, requested and reviewed information from suzuki, and discussed this matter with company representatives on 11-3-05. suzuki has decided to recall the subject motorcycles to correct the fuel leak issue.with suzuki's action, this matter is concluded and the investigation closed.a copy of suzuki's recall is attached. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
10/06/2011 | 17000 | ||
Charging system stator rectfior | |||
06/26/2011 | 18058 | ||
I was riding along and all of a sudden, my motorcycle lost power and the engine stopped. the engine would not turn over and the electric fuel pump would barely run. subsequent troubleshooting revealed that the generator stator had shorted and was no longer functioning causing the battery to become depleted. replacement of the stator, regulator/rectifier and the battery was required. i would expect these components to last longer than 18,000 miles but after doing my research on this problem for this motorcycle, i found that this is a common occurance. | |||
06/23/2005 | 1500 | 1 | |
The motorcycle (suzuki c 90 boulevard) wobbles uncontrollably on deceleration, that can cause loss of control, this started when it had only 1500 miles on it. dealer would do nothing. it has also had electrical system problems the rectifier shorts out. suzuki replaced the rectifier and stator. these problems are inherent in 2005 and 2006 suzuki c90 boulevard. in 2007 suzuki revamped the stator and rectifier. *tr | |||
ELECTRICAL SYSTEM - BATTERY | |||
05/01/2008 | 1 | 09/04/2005 | |
2005 suzuki vl 1500 with safety recall for the fuel pad. consumer states that the dealership will not order the part and let him repair the problem himself. they are saying he has to have a dealer do it. he states he doesn't trust the dealers. *kb the consumer also stated the battery died. | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
05/01/2008 | 1 | 09/04/2005 | |
2005 suzuki vl 1500 with safety recall for the fuel pad. consumer states that the dealership will not order the part and let him repair the problem himself. they are saying he has to have a dealer do it. he states he doesn't trust the dealers. *kb the consumer also stated the battery died. | |||
02/06/2006 | 1 | 10/20/2004 | |
I received a recall on my 2005 suzuki c90 related to the gas tank. the recall states not to operate the motorcycle. the dealer refuses to pick the bike up and tells me to ride it to the dealership. if it is too dangerous to ride, why aren't the dealers responsible for towing the bike? *jb | |||
08/30/2005 | 7456 | 1 | |
2005 suzuki boulevard c90 motorcycle: gas tank leak, some spot as previous years. top right corner. bad weld verified by dealership service manager. dealer ordered new gas tank. down time for customer (me) 1 week.*jb | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
06/21/2005 | 1 | 1 | 06/21/2005 |
Dt: 2005 suzuki vs1400. the consumer stated had problems with the gas tank, and/or the gas cap rattled. this was a distraction to the consumer while driving. he was concerned this could cause a gas leak. the dealership agreed there was a rattle and it vibrated against something, but the part was not defective. the manufacturer stated if it was not a defective part they could not do anything about it. this has been occurring since purchase of the vehicle.*ak | |||
SERVICE BRAKES, HYDRAULIC | |||
10/01/2005 | 4800 | 100 | 07/12/2005 |
Front brake fails to stop vehicle. front brake lever travel is excessive and often touches the throttle grip without providing any significant deceleration. dealer recently bled brakes at the 4000 mile service. almost had an accident on oct 1, 2005 when the motorcycle was unable to stop in an emergency situation. had to change lanes to aviod a rear end collision. this problem has occurred with other vs1400 suzuki intruders. *nm | |||
STEERING | |||
06/23/2005 | 1500 | 1 | |
The motorcycle (suzuki c 90 boulevard) wobbles uncontrollably on deceleration, that can cause loss of control, this started when it had only 1500 miles on it. dealer would do nothing. it has also had electrical system problems the rectifier shorts out. suzuki replaced the rectifier and stator. these problems are inherent in 2005 and 2006 suzuki c90 boulevard. in 2007 suzuki revamped the stator and rectifier. *tr | |||
STRUCTURE - MOTORCYCLE KICKSTAND/CENTERSTAND | |||
05/01/2007 | 3 | 04/01/2007 | |
2005 vl1500 boulevard has fallen from the kick stand. consumer states that he was informed by a mechanic that the kick stand does not go forward enough to hold the bike on an incline. *kb the consumer stated the motorcycle has fallen three times this year, in which he suffered a minor muscle pull. *jb | |||
06/01/2005 | 100 | 1 | 04/15/2005 |
Dt: suzuki 2005 blvd. c90t -touring motorcycle. the problem is with the kick stand. when the consumer put the kick stand down it will not lock and the bike will fall over. *jb | |||
SUSPENSION - FRONT - HUB | |||
08/25/2005 | 1 | 02/12/1998 | |
Dt: owner has a motorcylce. while driving on the highway at 70 mph the ball bearnings fell out of the front wheel. this caused the vehicle not to have any front brakes. then, the owner leaned to the right and let the motorcycle roll to a stop. the front wheel was wobbling. there was a front wheel bearing problem about a year and a half ago. it was making a clicking noise and had to be replaced at 9,000 miles. the front wheel bearnings fell off last wednesday. the motorcyle was towed. the owner took it to dealership and they repaired it. the dealership advised the owner that the wheel bearnings were dervied from three different sources. they indicated the bearning that failed was called a kachi bearing. the owner called suzuki and made a complaint with them. the mechanic replaced the bearing with a koyo. the owner had to replace the kachi bearnigs twice within 15000 miles. the owner was concerned this product could cause death or injury to rider or other motorists. *ak | |||
SUSPENSION - FRONT - WHEEL BEARING | |||
08/25/2005 | 1 | 02/12/1998 | |
Dt: owner has a motorcylce. while driving on the highway at 70 mph the ball bearnings fell out of the front wheel. this caused the vehicle not to have any front brakes. then, the owner leaned to the right and let the motorcycle roll to a stop. the front wheel was wobbling. there was a front wheel bearing problem about a year and a half ago. it was making a clicking noise and had to be replaced at 9,000 miles. the front wheel bearnings fell off last wednesday. the motorcyle was towed. the owner took it to dealership and they repaired it. the dealership advised the owner that the wheel bearnings were dervied from three different sources. they indicated the bearning that failed was called a kachi bearing. the owner called suzuki and made a complaint with them. the mechanic replaced the bearing with a koyo. the owner had to replace the kachi bearnigs twice within 15000 miles. the owner was concerned this product could cause death or injury to rider or other motorists. *ak | |||
VEHICLE SPEED CONTROL | |||
08/05/2005 | 1 | 1 | 08/05/2005 |
Note: vehicle is not a vl1500, it is a suzuki burgman 650 motorscooter which was not a choice on your dropdown models. speedometer is completely inaccurate on my brand new 2005 suzuki burgman 650 motorscooter. while driving my motorscooter, i cannot get an accurate reading on whether i'm going too fast or too slow. sometimes this speedometer is at least 20 mph faster than what i am traveling. i have taken the bike back to the dealership and i am being told by both the dealer and suzuki that a 10% margin of error is acceptible by suzuki as being accurate enough to drive on the american highways. i checked with the local police and highway patrols and was informed that when a speed limit is posted that is what you should be driving - not 10% plus or minus. i am also being instructed by suzuki that i should be able to mentally calculate the maximum 10% difference on the speedometer while driving in mountain conditions and crowded highways creating a serious safety factor. i would like to have this fixed. there are 2 suzuki brugman 650's that were purchased from the same dealership within the same week, both are now in the shop for the same repairs. both owners have been instructed that they will not be fixed and they must be ridden in this unsafe condition. i would appreciate nhtsa help in resolving this serious safety violation. | |||
WHEELS | |||
06/04/2005 | 04/25/2005 | ||
Dt: a 2005 suzuki vl800. consumer states that the rear wheel has spokes, and where the spokes tie into the metal of the wheels it is cracking. the dealership has conflicting responses, one says it is dangerous, and another says it is not a problem. the motorcycle has only 823 miles on it.*ak |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
CA | FRESNO | 93710 | CLASON HONDA | |
FL | SARASOTA | 34233 | SUZUKI OF SARASOTA | 941-925-0376 |
MS | OLIVE BRANCH | OLIVE BRANCH SUZUKI YAMAHA | ||
NC | STATESVILLE | M AND H SUZUKI | ||
NE | OMAHA | 68005 | POWER SPORTSPRO | |
OR | BEND | 97702 | CENTRAL OREGON WORKENSPORT | 541-382-0860 |
VA | LEESBURG | 20175 | LOUDOUN MOTORSPORTS | 703-777-1652 |
WI | LACROSSE | 54601 | STEIGER KAWASAKI-SUZUKI-ATV POLARIS ARTI | 608-788-4514 |