Suzuki Vl800 2009
Model Vl800 made in 2009 by Suzuki got 10 consumer complains there is 1 recall as well as 1 service bulletin. Consumer complaints with reference, among others things, to unknown or other, vehicle speed control. Technical service bulletines regarding equipment. There was one recall concerning electrical system .
Model 2009
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
11V108000 | AMERICAN SUZUKI MOTOR CORP. | from 05/01/2008 to 03/31/2009 | V (Vehicle) | 73426 | 03/02/2011 | MFR | AMERICAN SUZUKI MOTOR CORP. | 02/23/2011 | 02/23/2011 | |||||||
Defect Summary | Suzuki is recalling certain model year 2008 through 2010 motorcycles manufactured from july 2007 through september 2009, equipped with regulator/rectifier assemblies, suzuki part numbers 32800-41f11, 32800-15h10, 32800-05h11, 32800-41g10, 32800-15h00, 32800-18h00, 32800-05g10, 32800-10g10, 32800-05h20, or 32800-06g01. some regulator/rectifier assemblies were produced with insufficient adhesion between the power module (circuit board) and the rectifier case that contains a heat sink to dissipate heat. due to insufficient adhesion, heat generated on the power module circuit board can cause the circuit board to deform, and lift of the case. | |||||||||||||||
Consequence Summary | This condition causes excessive heat on the circuit board and uncontrolled electric current output, which can result in insufficient charging current being provided to the motorcycle battery. this can cause discharge of the battery and can lead to engine stalling and/or a no-start condition. engine stalling while riding can increase the risk of a crash. | |||||||||||||||
Corrective Summary | Suzuki will notify owners and suzuki distributors will replace the regulator/rectifier with an improved part free of charge. the safety recall is expected to begin during march 2011. owners may contact suzuki at 1-714-572-1490. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
SB-09-24 | 10/08/2008 | 10029824 | Suzuki motorcycle: an assembly and pre-delivery service guide will not be issued for the vl800k9, because the set up procedure remains similar to the vl800k6. to set up vl800k9, please use the vl800k6 assembly and pre-delivery service guide | 07/15/2009 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
UNKNOWN OR OTHER | |||
03/18/2011 | 846 | ||
Received recall notice from american suzuki corporation. motor cycle taken to dealership, it has been there a month. i have checked every week. i am told they have gotten no response about a replacement part. can you help resolve this matter in a timely fashion? component that needs to be replaced: rectifier assemblies installed on the affected models may have a condition which can cause the internal circuit board to fail in service due to excessive heat. | |||
VEHICLE SPEED CONTROL | |||
07/02/2010 | 1 | 04/29/2010 | |
2009 suzuki vl800tk9. consumer writes in regards to repair reimbursement and recall *tgw the consumer stated she returned the bike to the dealer, because the speedometer was off by 9 mph. the dealer replaced the component, but it didn't correct the problem. the consumer was informed there wasn't anything else that could be done and it was probably a manufacturing defect. *jb |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
MI | ANN ARBOR | 48103 | NICHOLSON'S | 734-585-3300 |