Thomas Built Buses Fs-65 2008
Model Fs-65 made in 2008 by Thomas Built Buses got 5 investigations as well as 3 recalls. The car had some investigations: electrical system and service brakes, hydraulic. There were some recalls concerningelectrical system and equipment.
Model 2008
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||||||||||||
07V544000 | FREIGHTLINER LLC | from 10/23/2000 to 01/24/2006 | V (Vehicle) | 33303 | 03/28/2008 | ODI | FREIGHTLINER LLC | 11/29/2007 | 11/29/2007 | |||||||
Defect Summary | Certain 2001 through 2008 thomas built fs-56, er, mvp er, hdx, and mvp ef school buses manufactured from october 23, 2000, through january 24, 2006, equipped with tyco pc board and type ii auto reset circuit breakers. type ii auto reset circuit breaker temperatures may exceed the rating of the tyco pc board causing the boards to melt potentially resulting in a vehicle fire. | |||||||||||||||
Consequence Summary | A vehicle fire can occur possibly resulting in a crash. | |||||||||||||||
Corrective Summary | Thomas built will notify owners and repair the buses by replacing the type ii auto reset circuit breakers with manual circuit breakers, and the jumper cable. the recall began on march 28, 2008. owners may contact thomas built customer support office at 336-889-4871. | |||||||||||||||
Notes | Freightliner recall no. fl-516.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | ||||||||||||||||
11V222000 | DAIMLER TRUCKS NORTH AMERICA | from 01/02/2006 to 01/31/2011 | V (Vehicle) | 6828 | 05/20/2011 | MFR | FREIGHTLINER LLC | 04/06/2011 | 04/06/2011 | |||||||
Defect Summary | Daimler trucks (dtna) is recalling certain model year 2006 through 2011 saf-t-liner c2, saf-t-liner hdx, mvp-ef, fs-65, and minotor school buses manufactured from january 2, 2006, through january 31, 2011, equipped with carrier genv em-1 evaporator units. due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing. | |||||||||||||||
Consequence Summary | If sufficient arcing occurs, the fuse holder may melt, and a vehicle fire may occur. | |||||||||||||||
Corrective Summary | Dtna will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. this service will be performed free of charge. the safety recall began on may 20, 2011. (see carrier's recall campaign 11e-003.) owners may contact carrier at 1-800-793-4741 or dtna at 1-800-547-0712. | |||||||||||||||
Notes | Dtna's recall campaign number is fl-604.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||||||||||||
08V087000 | DAIMLER TRUCKS NORTH AMERICA | from 01/01/1994 to 03/10/2008 | V (Vehicle) | 243435 | 08/18/2008 | ODI | FREIGHTLINER LLC | 02/26/2008 | 02/27/2008 | |||||||
Defect Summary | Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior. | |||||||||||||||
Consequence Summary | In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants. | |||||||||||||||
Corrective Summary | Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871. | |||||||||||||||
Notes | Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||
PE07029 | FREIGHTLINER LLC | 06/20/2007 | 11/29/2007 | SIDE ELECTRICAL FUSE PANEL FIRES | 07V544000 | |
The office of defects investigation (odi) opened this investigation after becoming aware of two school bus fires that started in the side mounted electrical fuse panel on a pair of thomas built school buses.thefleet owner had reported the bus interiors filled with smoke, certain electrical devices became inoperative, and the buses stalled. the two buses involved in the fire incidents have consecutive vin numbers and the fires were similar, but not identical to a previous recall (06v-136) conducted by thomas built.these buses were not included in the prior recall, which involved a defective power distribution module (pdm).after further technical evaluation, freightliner decided they would conduct a safety recall to correct deficiencies in theprevious recall and also expand the population to capture all affected buses.the corrective action freightliner plans to take will be forwarded to odi when available. accordingly, this investigation is closed. | ||||||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | ||||||
PE09004 | FREIGHTLINER LLC | 01/21/2009 | 04/16/2009 | BRAKE HOSE/TUBE ABRADING | 09V266000 | |
This investigation was opened after odi received a complaint from a fleet indicating that the brake hoses were rubbing against the transmission dipstick tube.on april 2, 2009, daimler trucks north america llc filed a safety recall to inspected and reroute the affected brake hoses and anydamaged hoses will be replaced. the recall number assigned is 09v-114.this recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. | ||||||
PE09004 | FREIGHTLINER LLC | 01/21/2009 | 04/16/2009 | BRAKE HOSE/TUBE ABRADING | 09V114000 | |
This investigation was opened after odi received a complaint from a fleet indicating that the brake hoses were rubbing against the transmission dipstick tube.on april 2, 2009, daimler trucks north america llc filed a safety recall to inspected and reroute the affected brake hoses and anydamaged hoses will be replaced. the recall number assigned is 09v-114.this recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. | ||||||
PE09004 | FREIGHTLINER LLC | 01/21/2009 | 04/16/2009 | BRAKE HOSE/TUBE ABRADING | 09V265000 | |
This investigation was opened after odi received a complaint from a fleet indicating that the brake hoses were rubbing against the transmission dipstick tube.on april 2, 2009, daimler trucks north america llc filed a safety recall to inspected and reroute the affected brake hoses and anydamaged hoses will be replaced. the recall number assigned is 09v-114.this recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. | ||||||
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||
PE07054 | FREIGHTLINER LLC | 11/09/2007 | 03/04/2008 | EMERGENCY DOOR HANDLE FAILURE | 08V087000 | |
The office of defects investigation opened this preliminary evaluationafterbecoming aware that fleets were having handle failures on the rear emergency door exit.the failure resulted in the door handle separating from thedoor latch mechanism.when the handle fails, the rear emergency exit door can not be opened from outside the bus.the failure results from corrosion of the exterior door handle around the securing roll pin and square drive latch mechanism, causing the protective finish to chip and flake.continued corrosion weakens the handle and eventually the handle may break while trying to open the exit door.odi was concerned that during an emergency, a person outside of the bus would break the door handle while trying to open the emergency exit door,potentially delaying evacuation of the bus.under the safety recall, the aluminum handles will be replaced with a more robust handle.the recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. |