Thomas Mvp Ef 2003
Model Mvp Ef made in 2003 by Thomas got 2 investigations there are 6 recalls as well as 2 service bulletins. Technical service bulletines regarding equipment, service brakes, air. The car had some investigations: steering, structure. There were some recalls concerningelectrical system, fuel system, diesel and other.
Model 2003
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||||||||||||
07V544000 | FREIGHTLINER LLC | from 10/23/2000 to 01/24/2006 | V (Vehicle) | 33303 | 03/28/2008 | ODI | THOMAS BUILT BUSES, INC. | 11/29/2007 | 11/29/2007 | |||||||
Defect Summary | Certain 2001 through 2008 thomas built fs-56, er, mvp er, hdx, and mvp ef school buses manufactured from october 23, 2000, through january 24, 2006, equipped with tyco pc board and type ii auto reset circuit breakers. type ii auto reset circuit breaker temperatures may exceed the rating of the tyco pc board causing the boards to melt potentially resulting in a vehicle fire. | |||||||||||||||
Consequence Summary | A vehicle fire can occur possibly resulting in a crash. | |||||||||||||||
Corrective Summary | Thomas built will notify owners and repair the buses by replacing the type ii auto reset circuit breakers with manual circuit breakers, and the jumper cable. the recall began on march 28, 2008. owners may contact thomas built customer support office at 336-889-4871. | |||||||||||||||
Notes | Freightliner recall no. fl-516.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
FUEL SYSTEM, DIESEL | ||||||||||||||||
05V205000 | FREIGHTLINER LLC | from 12/01/1997 to 12/01/2003 | V (Vehicle) | 16000 | ODI | THOMAS BUILT BUSES, INC. | 04/27/2005 | 05/06/2005 | ||||||||
Defect Summary | Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. the fuel pump could fail to transfer fuel appropriately creating an engine stall condition. | |||||||||||||||
Consequence Summary | Should the engine stall while the vehicle is in use, a possible vehicle crash could occur. | |||||||||||||||
Corrective Summary | Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. owners may contact cummins at 1-800-diesels. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
OTHER - SCHOOL BUS STOP ARM ASSEMBLY | ||||||||||||||||
05V347000 | FREIGHTLINER LLC | from 01/08/2002 to 03/08/2005 | V (Vehicle) | 5954 | 09/14/2005 | ODI | THOMAS BUILT BUSES, INC. | 08/03/2005 | 08/02/2005 | |||||||
Defect Summary | Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg 5 series stop arms originally sold in or currently registered in states other than the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. in extremely cold weather, the microswitches used internally to position the stop arm sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all. | |||||||||||||||
Consequence Summary | Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location. | |||||||||||||||
Corrective Summary | For those buses operated in or near any of the states listed above, thomas built is encouraging the bus owners to obtain the replacement switch. for those buses operated in the warmer states, dealers will replace the switch upon owner request. for those customers who request the remedy, thomas built will replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected. the recall began on september 14, 2005. owners may contact thomas built's customer support office at 336-889-4871. | |||||||||||||||
Notes | This action is deemed a safety improvement campaign and is not being conducted under the safety act.freightliner/thomas built recall no. fl-454.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
05V340000 | FREIGHTLINER LLC | from 01/08/2002 to 03/08/2005 | V (Vehicle) | 13583 | 09/14/2005 | ODI | THOMAS BUILT BUSES, INC. | 07/25/2005 | 07/28/2005 | |||||||
Defect Summary | Certain 2002-2005 my thomas built minotour, conventional, mvp-er, er, hdx, and mvp-ef model school buses manufactured between january 8, 2002, and march 8, 2005, equipped with specialty mfg 5 series stop arms originally sold in or currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. in extremely cold weather, the microswitches used internally to position the stop arm sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all. | |||||||||||||||
Consequence Summary | Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location. | |||||||||||||||
Corrective Summary | Thomas built will notify its owners and replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected free of charge. the recall began on september 14, 2005. owners may contact thomas built's customer support office at 336-889-4871. | |||||||||||||||
Notes | Freightliner/thomas built recall no. fl-454.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
STEERING - LINKAGES - TIE ROD ASSEMBLY | ||||||||||||||||
05V137000 | FREIGHTLINER LLC | from 09/24/2000 to 03/04/2004 | V (Vehicle) | 4819 | 09/06/2005 | MFR | THOMAS BUILT BUSES, INC. | 04/01/2005 | 04/07/2005 | |||||||
Defect Summary | Certain 2001-2004 my thomas built mvp-ef, er transit, mvp-er, hd, and hdx school buses manufactured between september 24, 2000, and march 4, 2004. the tie rod assembly can fracture and fail, possibly resulting in complete separation. | |||||||||||||||
Consequence Summary | Tie rod failure can possibly result in complete wheel separation and a vehicle crash could occur. | |||||||||||||||
Corrective Summary | Thomas built will notify its customers and will replace the tie rod assembly free of charge. the recall began september 6, 2005. owners may contact thomas built at (we do not yet have a telephone number). | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||||||||||||
08V087000 | DAIMLER TRUCKS NORTH AMERICA | from 01/01/1994 to 03/10/2008 | V (Vehicle) | 243435 | 08/18/2008 | ODI | THOMAS BUILT BUSES, INC. | 02/26/2008 | 02/27/2008 | |||||||
Defect Summary | Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior. | |||||||||||||||
Consequence Summary | In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants. | |||||||||||||||
Corrective Summary | Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871. | |||||||||||||||
Notes | Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
PSD-302B | 07/30/2008 | 10034604 | Thomas built: it has been determined that certain model buses, er-hd, hdx and mvp-ef units, have the von #70 s-cam brackets that could develop cracks in the lower portion. *pe | 12/10/2010 | |
SERVICE BRAKES, AIR | |||||
PSD-302B | 07/30/2008 | 10034604 | Thomas built: it has been determined that certain model buses, er-hd, hdx and mvp-ef units, have the von #70 s-cam brackets that could develop cracks in the lower portion. *pe | 12/10/2010 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
STEERING - LINKAGES - TIE ROD ASSEMBLY | ||||||
PE04062 | THOMAS BUILT BUSES, INC. | 09/03/2004 | 02/02/2005 | TIE ROD TUBE FAILURE | 05E004000 | |
This investigation was prompted by complaints from two separate school busfleets.both fleets alleged that while maneuvering in a parking area, the tie-rod tube disconnected from one of the tie-rods.dana, freightliner and thomas built buses recently completed extensive tesing and determined that a crack may initiate on the internal thread root of the tie rod.this condition is due to inadequate dampening in the chassis system to account for normal brake-induced vibration.these cracks may lead to separation of the tie rod from the assembly.approximately 5,839 dana steer axles equipped with a certain trw tie rod assembly utilizing a cut thread design are involved:a.1320 axle applications, thomas part number 61110702 and 61110705 installed on thomas buses with 6 brakes and 30 air chambers;b.1460 axle applications, thomas bus part number 61110707 and 61110708 installed with 6 brakes and 30 air chambers. thomas built bus will replace the existing tie rod assemblies which contain the cut thread design with a new tie rod assembly that utilizes a rolled thread design.a rolled thread provides less stress on the critical area of the tie rod. a copy of the defect report is attached. this action resolves the issues raised by this investigation.accordingly,this investigation is closed. | ||||||
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||
PE07054 | THOMAS BUILT BUSES, INC. | 11/09/2007 | 03/04/2008 | EMERGENCY DOOR HANDLE FAILURE | 08V087000 | |
The office of defects investigation opened this preliminary evaluationafterbecoming aware that fleets were having handle failures on the rear emergency door exit.the failure resulted in the door handle separating from thedoor latch mechanism.when the handle fails, the rear emergency exit door can not be opened from outside the bus.the failure results from corrosion of the exterior door handle around the securing roll pin and square drive latch mechanism, causing the protective finish to chip and flake.continued corrosion weakens the handle and eventually the handle may break while trying to open the exit door.odi was concerned that during an emergency, a person outside of the bus would break the door handle while trying to open the emergency exit door,potentially delaying evacuation of the bus.under the safety recall, the aluminum handles will be replaced with a more robust handle.the recall action resolves the issues raised by this investigation. accordingly, this investigation is closed. |