Thomas Mvp Er 1999
Model Mvp Er made in 1999 by Thomas got 2 investigations as well as 9 recalls. The car had some investigations: engine and engine cooling and structure. There were some recalls concerningengine and engine cooling and fuel system, diesel.
Model 1999
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
08V356000 | DAIMLER TRUCKS NORTH AMERICA | from 06/08/1995 to 02/16/2001 | V (Vehicle) | 3773 | 02/27/2009 | MFR | THOMAS BUILT BUSES, INC. | 07/30/2008 | 07/30/2008 | |||||||
Defect Summary | Daimler trucks is recalling 3,773 my 1996 through 2002 thomas built mvp er school buses manufactured from june 8, 1995 through february 16, 2001, equipped with caterpillar 3116 and 3126 engines. un-fused power cables were tie-wrapped to a wire braid engine fuel return hose. over time these cables may chafe, wearing through the wire loom and eventually through the cable insulation and fuel line covering in an area not easily detectable during normal maintenance without removing the tie wraps and opening the wire loom. un-fused and un-switched power cables which wear through and contact the fuel line wire braid may short circuit. | |||||||||||||||
Consequence Summary | In the event of a short circuit, a vehicle fire can occur. | |||||||||||||||
Corrective Summary | Thomas built will notify owners and inspect and replace the cables as necessary free of charge. the recall is expected to begin on or about november 28, 2008. owners may contact thomas built at 1-336-889-4871. | |||||||||||||||
Notes | Daimler trucks' recall no. fl-534.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||||||||||||
02V085000 | FREIGHTLINER CORPORATION | from 05/13/1995 to 03/20/2001 | V (Vehicle) | 4800 | 06/10/2002 | ODI | THOMAS BUILT BUSES, INC. | 03/20/2002 | 03/26/2002 | |||||||
Defect Summary | On certain school buses, misalignment of the fan drive system components can cause premature belt and pulley bearing wear. | |||||||||||||||
Consequence Summary | If the school bus is disabled by a cooling system failure and is stalled on the side of the road, an increased risk of a crash resulting in injury to a school bus occupant could occur. | |||||||||||||||
Corrective Summary | Dealers will replace the fan belt, idler pulley, and belt tensioner and the pulley's laser will be aligned. owner notification began june 10, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
FUEL SYSTEM, DIESEL | ||||||||||||||||
05V205000 | FREIGHTLINER LLC | from 12/01/1997 to 01/31/2003 | V (Vehicle) | 16000 | ODI | THOMAS BUILT BUSES, INC. | 04/27/2005 | 05/06/2005 | ||||||||
Defect Summary | Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. the fuel pump could fail to transfer fuel appropriately creating an engine stall condition. | |||||||||||||||
Consequence Summary | Should the engine stall while the vehicle is in use, a possible vehicle crash could occur. | |||||||||||||||
Corrective Summary | Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. owners may contact cummins at 1-800-diesels. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
SEATS | ||||||||||||||||
00V362000 | THOMAS BUILT BUSES, INC. | from 04/01/1996 to 09/30/2000 | V (Vehicle) | 6500 | 02/09/2001 | MFR | THOMAS BUILT BUSES, INC. | 11/03/2000 | 11/06/2000 | |||||||
Defect Summary | Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. a bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. this bracket is located at the top of the height adjuster. | |||||||||||||||
Consequence Summary | If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the seat base and add reinforcement to the seat assembly | |||||||||||||||
Notes | Owner notification began february 9, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built atalso contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SERVICE BRAKES, AIR - ANTILOCK | ||||||||||||||||
00V232002 | FREIGHTLINER CORPORATION | from 02/13/1998 to 08/03/2000 | V (Vehicle) | 35405 | 08/29/2000 | MFR | THOMAS BUILT BUSES, INC. | 08/07/2000 | 08/09/2000 | |||||||
Defect Summary | Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal. | |||||||||||||||
Consequence Summary | This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash. | |||||||||||||||
Corrective Summary | Dealers will replace the abs ecu. | |||||||||||||||
Notes | Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
00V232011 | THOMAS BUILT BUSES, INC. | from 02/13/1998 to 08/03/2000 | V (Vehicle) | 4780 | 08/29/2000 | MFR | THOMAS BUILT BUSES, INC. | 08/07/2000 | 11/29/2000 | |||||||
Defect Summary | Vehicle description: school bus chassis and emergency vehicles built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal. | |||||||||||||||
Consequence Summary | This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash. | |||||||||||||||
Corrective Summary | Dealers will replace the abs ecu. | |||||||||||||||
Notes | Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
STEERING - LINKAGES - TIE ROD ASSEMBLY | ||||||||||||||||
01V044002 | FREIGHTLINER CORPORATION | from 07/15/1999 to 12/21/1999 | V (Vehicle) | 16000 | 05/22/2001 | MFR | THOMAS BUILT BUSES, INC. | 02/21/2001 | 02/28/2001 | |||||||
Defect Summary | Vehicle description: trucks, school bus and motor home chassis, and transit buses equipped with tie rod assemblies manufactured by trw. the suspect tie rods contain 24-dl model ball sockets. certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket. | |||||||||||||||
Consequence Summary | If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the defective ball sockets and/or drag links. owner notification began may 22, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712 or trw customer service at 1-866-280-3287. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | ||||||||||||||||
08V087000 | DAIMLER TRUCKS NORTH AMERICA | from 01/01/1994 to 03/10/2008 | V (Vehicle) | 243435 | 08/18/2008 | ODI | THOMAS BUILT BUSES, INC. | 02/26/2008 | 02/27/2008 | |||||||
Defect Summary | Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior. | |||||||||||||||
Consequence Summary | In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants. | |||||||||||||||
Corrective Summary | Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871. | |||||||||||||||
Notes | Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
WHEELS - LUGS/NUTS/BOLTS | ||||||||||||||||
02V221000 | FREIGHTLINER CORPORATION | from 06/01/1999 to 03/07/2002 | V (Vehicle) | 15 | 02/28/2003 | MFR | THOMAS BUILT BUSES, INC. | 08/06/2002 | 08/14/2002 | |||||||
Defect Summary | On certain school and transit buses, the wheel lug nut may not tighten completely. | |||||||||||||||
Consequence Summary | The wheel could loosen increasing the risk of loss of control of the vehicle. | |||||||||||||||
Corrective Summary | Dealers will install new wheel studs. owner notification began february 28, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
PE02023 | THOMAS BUILT BUSES, INC. | 02/12/2002 | 03/25/2002 | FAN DRIVE UPDATE | 02V085000 | |
Allege that the fan drive belt fails.this can result in engine overheating and cause the bus engine to stall | ||||||
STRUCTURE | ||||||
SQ99008 | THOMAS BUILT BUSES, INC. | 03/19/1999 | 04/13/1999 | FRAME CRACKS-FRONT SHOCK MOUNT | 99V075000 | |
There is no summary currently available |